Search Results (22)

A blend with pumpkin and sunflower seed flours was prepared and dried at 41.5 °C for 5 h to create a minimally heat-treated blend for a raw food diet. The blend was inoculated with Lactobacillus acidophilus and Fusarium langsethiae to assess the effect of L. acidophilus on Fusarium growth and mycotoxin production. Drying did not affect the content of naturally occurring microorganisms but significantly reduced water activity (p < 0.05) and increased total phenolic content in samples with external microorganisms. Lactobacilli content remained unchanged after drying (4.8 log CFU/g), while F. langsethiae increased by 1.5 log CFU/g. Principal component analysis showed PC1 explained 95.1% of total variance, driven by Fusarium mycotoxin production. A significant difference in total mycotoxin was found between samples with F. langsethiae alone and those with both F. langsethiae and L. acidophilus (p < 0.05). Lactic acid bacteria could reduce fusarium mycotoxin risk in raw food diet mixtures. Full article

An electronic device based on the detection of volatile substances was developed in response to the need to distinguish between fungal infestations in food and was applied to wheat grains. The most common pathogens belong to the fungi of the genus Fusarium: F. avenaceum, F. langsethiae, F. poae, and F. sporotrichioides. The electronic nose prototype is a low-cost device based on commercially available TGS series sensors from Figaro Corp. Two types of gas sensors that respond to the perturbation are used to collect signals useful for discriminating between the samples under study. First, an electronic nose detects the transient response of the sensors to a change in operating conditions from clean air to the presence of the gas being measured. A simple gas chamber was used to create a sudden change in gas composition near the sensors. An inexpensive pneumatic system consisting of a pump and a carbon filter was used to supply the system with clean air. It was also used to clean the sensors between measurement cycles. The second function of the electronic nose is to detect the response of the sensor to temperature disturbances of the sensor heater in the presence of the gas to be measured. It has been shown that features extracted from the transient response of the sensor to perturbations by modulating the temperature of the sensor heater resulted in better classification performance than when the machine learning model was built from features extracted from the response of the sensor in the gas adsorption phase. By combining features from both phases of the sensor response, a further improvement in classification performance was achieved. The E-nose enabled the differentiation of F. poae from the other fungal species tested with excellent performance. The overall classification rate using the Support Vector Machine model reached 70 per cent between the four fungal categories tested. Full article

The massive import of uncontrolled technical grain from the East into the European Community poses a risk to public health when it ends up in the mills to be used as flour for food purposes instead of being burnt (biofuel). In fungal infections of wheat, the most dangerous species belong to the genus Fusarium. F. poae is a pathogen that is most commonly isolated from cereals worldwide and causes various types of diseases in animals and humans due to the numerous toxins it produces. The manuscript reports an attempt to distinguish between four species of Fusarium, F. avanceum, F. langsethiae, F. poae, and F. sporotrichioides, in wheat grains by measuring the volatiles emitted. The patterns obtained from the signals captured by the electronic nose PEN3 were used to build the Random Forests classification model. The recall and precision of the classification performance for F. poae reached 91 and 87%, respectively. The overall classification accuracy reached 70%. Gas chromatography coupled with mass spectrometry (GC–MS) was used to analyze the chemical composition of the emitted volatiles. The patterns found in the GC–MS results allowed an explanation of the main patterns observed when analyzing the electronic nose data. The mycotoxins produced by the Fusarium species analyzed were detected. The results of the reported experiment confirm the potential of the electronic nose as a technology that can be useful for screening the condition of the grain and distinguishing between different pathogenic infestations. Full article

One of the major classes of mycotoxins posing serious hazards to humans and animals and potentially causing severe economic impact to the cereal industry are the trichothecenes, produced by many fungal genera. As such, indicative limits for the sum of T-2 and HT-2 were introduced in the European Union in 2013 and discussions are ongoing as to the establishment of maximum levels. This review provides a concise assessment of the existing understanding concerning the toxicological effects of T-2 and HT-2 in humans and animals, their biosynthetic pathways, occurrence, impact of climate change on their production and an evaluation of the analytical methods applied to their detection. This study highlights that the ecology of F. sporotrichioides and F. langsethiae as well as the influence of interacting environmental factors on their growth and activation of biosynthetic genes are still not fully understood. Predictive models of Fusarium growth and subsequent mycotoxin production would be beneficial in predicting the risk of contamination and thus aid early mitigation. With the likelihood of regulatory maximum limits being introduced, increased surveillance using rapid, on-site tests in addition to confirmatory methods will be required. allowing the industry to be proactive rather than reactive. Full article

Frequent occurrences of high levels of Fusarium mycotoxins have been recorded in Norwegian oat grain. To elucidate the influence of tillage operations on the development of Fusarium and mycotoxins in oat grain, we conducted tillage trials with continuous oats at two locations in southeast Norway. We have previously presented the content of Fusarium DNA detected in straw residues and air samples from these fields. Grain harvested from ploughed plots had lower levels of Fusarium langsethiae DNA and HT-2 and T-2 toxins (HT2 + T2) compared to grain from harrowed plots. Our results indicate that the risk of F. langsethiae and HT2 + T2 contamination of oats is reduced with increasing tillage intensity. No distinct influence of tillage on the DNA concentration of Fusarium graminearum and Fusarium avenaceum in the harvested grain was observed. In contrast to F. graminearum and F. avenaceum, only limited contents of F. langsethiae DNA were observed in straw residues and air samples. Still, considerable concentrations of F. langsethiae DNA and HT2 + T2 were recorded in oat grain harvested from these fields. We speculate that the life cycle of F. langsethiae differs from those of F. graminearum and F. avenaceum with regard to survival, inoculum production and dispersal. Full article

Fusarium Head Blight is a devastating disease of wheat caused by a complex of Fusarium species producing a wide range of mycotoxins. Fusarium species occurrence is variable in different geographical areas and subjected to a continuous evolution in their distribution. A total of 141 durum wheat field samples were collected in different regions of Italy in three years, and analyzed for Fusarium species and related mycotoxin occurrence. Mycotoxin contamination varied according to year and geographical origin. The highest mycotoxin contamination was detected in 2014. Deoxynivalenol was detected with an average of 240 µg/kg only in Central and Northern Italy; and T-2 and HT-2 toxins with an average of 150 µg/kg in Southern Italy. Approximately 80% of samples from Southern Italy in 2013/2014 showed T-2 and HT-2 levels over the EU recommended limits. Fusarium graminearum occurred mostly in Northern Italy, while F. langsethiae occurred in Southern Italy. These data showed that a real mycotoxin risk related to Fusarium exists on the whole in Italy, but varies according with geographical areas and environmental conditions. Consistent monitoring of Fusarium species and related mycotoxin distribution on a long period is worthwhile to generate more accurate knowledge on Fusarium species profile and mycotoxins associated and better establish the climatic change impact on wheat Fusarium epidemiology. Full article

The contamination of oats with Fusarium toxins poses a high risk for food safety. Among them, trichothecenes are the most frequently reported in European oats, especially in northern countries. The environmental conditions related to the climate change scenario might favour a distribution shift in Fusarium species and the presence of these toxins in Southern European countries. In this paper, we present an ambitious work to determine the species responsible for trichothecene contamination in Spanish oats and to compare the results in the United Kingdom (UK) using a metataxonomic approach applied to both oat grains and soil samples collected from both countries. Regarding T-2 and HT-2 toxin producers, F. langsethiae was detected in 38% and 25% of the oat samples from the UK and Spain, respectively, and to the best of our knowledge, this is the first report of the detection of this fungus in oats from Spain. The relevant type B trichothecene producer, F. poae, was the most frequently detected Fusarium species in oats from both origins. Other important trichothecene producers, such as the Fusarium tricinctum species complex or Fusarium cerealis, were also frequently detected in oat fields. Many Fusarium toxins, including T-2 and HT-2 toxins, deoxynivalenol, or nivalenol, were detected in oat samples. The results obtained in this work revealed a clear change in the distribution of trichothecene producers and the necessity to establish the potential of these species to colonize oats and their ability to produce mycotoxins. Full article

Over recent decades, the Norwegian cereal industry has had major practical and financial challenges associated with the occurrence of Fusarium head blight (FHB) pathogens and their associated mycotoxins in cereal grains. Deoxynivalenol (DON) is one of the most common Fusarium-mycotoxins in Norwegian oats, however T-2 toxin (T2) and HT-2 toxin (HT2) are also commonly detected. The aim of our study was to rank Nordic spring oat varieties and breeding lines by content of the most commonly occurring Fusarium mycotoxins (DON and HT2 + T2) as well as by the DNA content of their respective producers. We analyzed the content of mycotoxins and DNA of seven fungal species belonging to the FHB disease complex in grains of Nordic oat varieties and breeding lines harvested from oat field trials located in the main cereal cultivating district in South-East Norway in the years 2011–2020. Oat grains harvested from varieties with a high FHB resistance contained on average half the levels of mycotoxins compared with the most susceptible varieties, which implies that choice of variety may indeed impact on mycotoxin risk. The ranking of oat varieties according to HT2 + T2 levels corresponded with the ranking according to the DNA levels of Fusarium langsethiae, but differed from the ranking according to DON and Fusarium graminearum DNA. Separate tests are therefore necessary to determine the resistance towards HT2 + T2 and DON producers in oats. This creates practical challenges for the screening of FHB resistance in oats as today’s screening focuses on resistance to F. graminearum and DON. We identified oat varieties with generally low levels of both mycotoxins and FHB pathogens which should be preferred to mitigate mycotoxin risk in Norwegian oats. Full article

In malt production, steeping and germination steps offer favorable environmental conditions for fungal proliferation when barley is already contaminated by Fusarium species, T-2 toxin producers. However, the use of G. candidum as a biocontrol agent can prevent this proliferation. Indeed, in previous work, a correlation between phenyllactic acid (PLA) production by G. candidum and the reduction in Fusarium sporotrichioides and F. langsethiae growth and T-2 toxin concentration was demonstrated. In the present study, to improve the efficiency of G. candidum, the effects of the inoculum concentration and the inoculation method of G. candidum on PLA and T-2 toxin concentrations were evaluated. First, co-culture experiments with Fusarium species and G. candidum were conducted in a liquid synthetic medium. The results showed that inoculation of G. candidum in the freeze-dried form at 0.4 g/L allowed the production of PLA from the second day of incubation associated with a reduction in T-2 toxin concentration of 82% and 69% produced by F. sporotrichioides and F. langsethiae, respectively. Moreover, the activated form of G. candidum at 0.4 g/L enhanced PLA concentration leading to better T-2 toxin reduction. Second, experiments were conducted on artificially infected barley kernels with both Fusarium species under conditions mimicking the malting step. As for co-culture experiments, the use of the activated form of G. candidum was established as the best condition for T-2 toxin concentration reduction for a 3 day malting period. Full article

Fusarium head blight (FHB) is one of the most important diseases of wheat, causing yield losses and mycotoxin contamination of harvested grain. A complex of different toxigenic Fusarium species is responsible for FHB and the composition and predominance of species within the FHB complex are determined by meteorological and agronomic factors. In this study, grain of three different susceptible winter wheat cultivars from seven locations in northern Germany were analysed within a five-year survey from 2013 to 2017 by quantifying DNA amounts of different species within the Fusarium community as well as deoxynivalenol (DON) and zearalenone (ZEA) concentrations. Several Fusarium species co-occur in wheat grain samples in all years and cultivars. F. graminearum was the most prevalent species, followed by F. culmorum, F. avenaceum and F. poae, while F. tricinctum and F. langsethiae played only a subordinate role in the FHB complex in terms of DNA amounts. In all cultivars, a comparable year-specific quantitative occurrence of the six detected species and mycotoxin concentrations were found, but with decreased DNA amounts and mycotoxin concentrations in the more tolerant cultivars, especially in years with higher disease pressure. In all years, similar percentages of DNA amounts of the six species to the total Fusarium DNA amount of all detected species were found between the three cultivars for each species, with F. graminearum being the most dominant species. Differences in DNA amounts and DON and ZEA concentrations between growing seasons depended mainly on moisture factors during flowering of wheat, while high precipitation and relative humidity were the crucial meteorological factors for infection of wheat grain by Fusarium. Highly positive correlations were found between the meteorological variables precipitation and relative humidity and DNA amounts of F. graminearum, DON and ZEA concentrations during flowering, whereas the corresponding correlations were much weaker several days before (heading) and after flowering (early and late milk stage). Full article

Fusarium sporotrichioides and F. langsethiae are present in barley crops. Their toxic metabolites, mainly T-2 toxin, affect the quality and safety of raw material and final products such as beer. Therefore, it is crucial to reduce Fusarium spp. proliferation and T-2 toxin contamination during the brewing process. The addition of Geotrichum candidum has been previously demonstrated to reduce the proliferation of Fusarium spp. and the production of toxic metabolites, but the mechanism of action is still not known. Thus, this study focuses on the elucidation of the interaction mechanism between G. candidum and Fusarium spp. in order to improve this bioprocess. First, over a period of 168 h, the co-culture kinetics showed an almost 90% reduction in T-2 toxin concentration, starting at 24 h. Second, sequential cultures lead to a reduction in Fusarium growth and T-2 toxin concentration. Simultaneously, it was demonstrated that G. candidum produces phenyllactic acid (PLA) at the early stages of growth, which could potentially be responsible for the reduction in Fusarium growth and T-2 toxin concentration. To prove the PLA effect, F. sporotrichioides and F. langsethiae were cultivated in PLA supplemented medium. The expected results were achieved with 0.3 g/L of PLA. These promising results contribute to a better understanding of the bioprocess, allowing its optimization at an up-scaled industrial level. Full article

New sources of resistance to fungal diseases, including FHB (Fusarium head blight), need to be identified. The results of research investigating ancient wheat species with desirable traits appear promising. The aim of this study was to determine the presence of Fusarium culmorum (W. G. Sm.) Sacc., F. graminearum Schwabe, F. poae (Peck) Wollenw, F. avenaceum (Fr.) Sacc. and F. langsethiae Torp & Nirenberg in the grain and glumes of diploid Triticum monococcum ssp. monococcum, tetraploid T. turgidum ssp. dicoccum, T. turgidum ssp. polonicum and T. turgidum ssp. durum, and hexaploid T. aestivum ssp. spelta and T. aestivum ssp. aestivum grown in north-eastern and south-eastern Poland and to analyze the trichothecene genotypes of the isolated strains. The results of this study also point to shifts in the genotype of Polish F. culmorum and F. graminearum populations from 3-ADON to NIV and 15-ADON to 3-ADON genotypes, respectively. Our findings indicate that selected einkorn lines could potentially be used as sources of genetic material for breeding new varieties resistant to FHB. The fungal genotypes should be closely screened in Poland and the neighboring countries to assess the effects of potential genotypes profile change on fungal virulence, toxin loading and host specificity. Full article

Two garlic-derived compounds, Propyl Propane Thiosulfonate (PTS) and Propyl Propane Thiosulfinate (PTSO), were examined for their efficacy against mycotoxigenic Fusarium species (F. graminearum, F. langsethiae, F. verticillioides). The objectives were to assess the inhibitory effect of these compounds on growth and mycotoxin production in vitro, and in situ in artificially inoculated wheat, oats and maize with one isolate of each respectively, at different water activity (a_w) conditions when stored for up to 20 days at 25 °C. In vitro, 200 ppm of either PTS or PTSO reduced fungal growth by 50–100% and mycotoxin production by >90% depending on species, mycotoxin and a_w conditions on milled wheat, oats and maize respectively. PTS was generally more effective than PTSO. Deoxynivalenol (DON) and zearalenone (ZEN) were decreased by 50% with 80 ppm PTSO. One-hundred ppm of PTS reduced DON and ZEN production in wheat stored at 0.93 a_w for 20 days, although contamination was still above the legislative limits. Contrasting effects on T-2/HT-2 toxin contamination of oats was found depending on a_w, with PTS stimulating production under marginal conditions (0.93 a_w), but at 0.95 a_w effective control was achieved with 100 ppm. Treatment of stored maize inoculated with F. verticilliodies resulted in a stimulation of total fumonsins in most treatments. The potential use of such compounds for mycotoxin control in stored commodities is discussed. Full article

Fusarium langsethiae is amongst the most recently discovered pathogens of small grains cereals. F. langsethiae is the main producer, in Europe, of T2 and HT-toxins in small grain cereals, albeit often asymptomatic; this makes its control challenging. The European Union (EU) is pushing hard on the use of biocontrol agents to minimize the use of fungicides and pesticides, which are detrimental to the environment and responsible for serious pollution of the soil and superficial water. In line with EU directives (e.g., 128/2009), here we report the use of protein fractions, purified from the culture filtrate of the basidiomycete Trametes versicolor, for controlling F. langsethiae. T. versicolor, a so-called medicinal mushroom which is applied as a co-adjuvant in oncology and other pathologies as a producer of biological response modifiers. In this study, the exo-proteome of T. versicolor proved highly efficient in inhibiting the growth of F. langsethiae and the biosynthesis of the T2 toxin. Results are promising for its future use as a sustainable product to control F. langsethiae infection in cereals under field conditions. Full article

Recent increases of Fusarium head blight (FHB) disease caused by infections with F. poae (FP) and F. langsethiae (FL) have been observed in oats. These pathogens are producers of nivalenol (NIV) and T-2/HT-2 toxin (T-2/HT-2), respectively, which are now considered major issues for cereal food and feed safety. To date, the impact of FP and FL on oat grains has not yet been identified, and little is known about oat resistance elements against these pathogens. In the present study, the impact of FL and FP on oat grains was assessed under different environmental conditions in field experiments with artificial inoculations. The severity of FP and FL infection on grains were compared across three field sites, and the resistance against NIV and T-2/HT2 accumulation was assessed for seven oat genotypes. Grain weight, β-glucan content, and protein content were compared between infected and non-infected grains. Analyses of grain infection showed that FL was able to cause infection on the grain only in the field site with the highest relative humidity, whereas FP infected grains in all field sites. The FP infection of grains resulted in NIV contamination (between 30–500 μg/kg). The concentration of NIV in grains was not conditioned by environmental conditions. FL provoked an average contamination of grains with T-2/HT-2 (between 15–132 μg/kg). None of the genotypes was able to fully avoid toxin accumulation. The general resistance of oat grains against toxin accumulation was weak, and resistance against NIV accumulation was strongly impacted by the interaction between the genotype and the environment. Only the genotype with hull-less grains showed partial resistance to both NIV and T-2/HT-2 contamination. FP and FL infections could change the β-glucan content in grains, depending on the genotypes and environmental conditions. FP and FL did not have a significant impact on the thousand kernel weight (TKW) and protein content. Hence, resistance against toxin accumulation remains the only indicator of FHB resistance in oat. Our results highlight the need for new oat genotypes with enhanced resistance against both NIV and T-2/HT-2 to ensure food and feed safety. Full article