Search Results (91)

Hydrogenotrophic denitrification (H₂Den) is a promising strategy for NO₃⁻ removal from a supply water with low or negligible organic carbon content. However, its performance may be affected by emerging contaminants (ECs), which pose increasing risks to the environment and human health. This study investigates the acute effect of two widely detected ECs, acetaminophen (ACN) and chloramphenicol (CHP), at a 200 mg/L concentration, on H₂Den using anaerobic granular sludge (AnGS) as inoculum. Acute exposure to ACN enhanced NO₃⁻ removal, likely due to the formation of oxidizable metabolites serving as electron donors through the heterotrophic pathway. On day 3, the residual NO₃⁻ concentration had already dropped below the regulatory limit of 50 mg/L, reaching 4.3 mg NO₃⁻/L. In contrast, CHP initially inhibited the denitrification process, resulting in limited NO₃⁻ removal, i.e., a residual concentration of 145.4 mg NO₃⁻/L on day 3. Nevertheless, short-term microbial adaptation likely enabled performance recovery under CHP exposure. On day 6, both EC exposure tests allowed a NO₃⁻ removal above 97%, although CHP resulted in residual NO₂⁻, i.e., 37 mg NO₂⁻/L. In the presence of ACN, the accumulation of gaseous denitrification intermediates was observed, with NO concentration in the headspace peaking at 9.5% (i.e., 16.2 × 10⁻² µg NO/min/g VS) on day 6. Thus, in terms of either the production of gaseous intermediates or the presence of residual nitrogen in the liquid phase, ACN and CHP significantly influenced the denitrification performance, highlighting the importance of considering their presence in the operation of the denitrification process. Full article

The stabilization of two-stage bioenergy systems and optimization of the energy recovery efficiency have been found to be closely related to the management of VFA-rich effluent obtained after the dark fermentation of food waste. In this study, the performance of a mesophilic UASB reactor was investigated at different OLR levels. The focus of this study was to assess methane yield and substrate degradation during anaerobic digestion. The results revealed that the performance of the UASB reactor was stable within the range of 2.5–7.0 kg COD m⁻³ d⁻¹. At this range, it was possible to convert VFAs into methane gas through the synergistic interaction of fermentative bacteria and methanogenic archaea. The methane content was 67.9%, TCOD removal efficiency was 89.7% at the optimal OLR of 7.0 kg COD m⁻³ d⁻¹, and volumetric methane production rate was 2.41 L_CH4 L⁻¹ d⁻¹. The increase in OLR to 10.0 kg COD m⁻³ d⁻¹ resulted in instability of the anaerobic digestion process. The instability of the anaerobic digestion process was characterized by propionate accumulation and a high VFA/alkalinity ratio of 0.89. The Grau second-order and Modified Stover–Kincannon models were found to describe COD removal efficiency. The Monod model was found to show limited preliminary agreement under the conditions tested for high-rate granular sludge. The highest methane yield and efficiency of energy recovery were obtained at 7.0 kg COD m⁻³ d⁻¹. The recoverable energy obtained at this OLR was 2.04 MJ d⁻¹. The results of this study revealed that it is possible to integrate dark fermentation and anaerobic digestion through the use of UASB reactors. Full article

The Integrated Fixed-film Activated Sludge (IFAS) partial nitritation/anammox (PN/A) process offers robust nitrogen removal, yet startup using pre-colonized carriers incurs high logistical costs. This study investigated the mechanism of inoculating a pilot-scale IFAS system with granular anammox sludge to treat anaerobic digestion supernatant. The treatment train integrated coagulation, pre-aeration, and an IFAS-PN/A unit. The granular-inoculated IFAS-PN/A unit achieved stable biofilm formation and a nitrogen removal rate of 0.36 kg N m⁻³ d⁻¹, benefiting from the effective interception of excessive organic carbon by the preceding coagulation and pre-aeration steps. Microbial analysis identified Candidatus brocadia as the dominant anammox genus, revealing a distinct migration pathway: bacteria transferred from disintegrating granules to the suspended sludge—acting as a transitional vector—before ultimately colonizing the carriers. While granular biomass diminished, anammox abundance in the biofilm increased to 12.0% by day 166. Furthermore, distinct spatial niches were observed: ammonium-oxidizing bacteria (AOB) dominated the suspended sludge, while nitrite-oxidizing bacteria (NOB) were effectively suppressed. These findings demonstrate the feasibility of granular inoculation for cost-effective IFAS startup and provide critical insights into the bacterial migration dynamics required for stable operation. Full article

Given the sustainable increase in kitchen waste production, the treatment of organic waste is quite important for both alleviating environmental risks and recovering biomass energy. Anaerobic digestion (AD) could achieve the goals of both organic stabilization and the green energy production of biogas. However, AD conducted at a high organic loading rate can easily suffer from low treatment efficiency due to the accumulation of volatile fatty acids and an imbalance in the microbial community. This study investigated the functional microbial enhancement strategy for enhancing AD performance. The results suggested that adding 10 g of granular sludge every 5 days could enhance AD efficiency. In that case, the daily average methane production rate was increased by 43.21% compared to that in the control group, and the pH and ammonia nitrogen concentration were maintained at the optimal level. Humic acid production was strengthened; it served as an electron shuttle, which facilitated direct interspecies electron transfer. Both Cloacimonadota and Methanobacterium were enriched in the system inoculated with the granular sludge. Metabolomics indicated that the acetyl–CoA conversion was strengthened, and that energy metabolism (complex I and archaeal ATPase) was also enhanced. The granular sludge inoculation also activated the archaeal genetic information processing system. This technology could promote the generation of green energy, which is more conducive to sustainable resource development. This study provides the theoretical basis for a microbial enhancement strategy that can enhance kitchen waste AD. Full article

Following on from a circular economy in water, membrane technologies can play a role in resource recovery and high-quality water production but should also consider membrane industry circularity. Anaerobic membrane bioreactors (AnMBRs) are being used for advanced wastewater treatment, and their applications are growing due to advantages like lower sludge volume, better permeate quality, and the generation of biogas. High-Rejection (HR) AnMBRs retain a higher fraction of dissolved and particulate components to further promote resource recovery and obtain improved effluent quality. With the development of membrane technologies, end-of-life (EOL) membrane recycling is emerging for various applications. The feasibility of transforming EOL Reverse Osmosis (RO) membranes into ultrafiltration (UF)- and nanofiltration (NF)-like membranes and applying these membranes to submerged HR-AnMBR applications was evaluated. A small pilot AnMBR with granular biomass was operated with EOL RO membranes converted to submerged UF- and NF-like membranes and compared to commercial microfiltration (MF) membranes. UF- and NF-like plates were constructed, characterized, and introduced step-by-step into the AnMBR by the substitution of MF plates. A chemical oxygen demand (COD) removal study showed that while 77% removal of COD was possible with MF membranes, improved COD removal (i.e., 81.40% and 88.39%) was achieved using UF-like and NF-like membranes, respectively. Because of the higher retention of salts of the NF-like membrane, the salinity in the membrane bioreactor increased from 1300 to 1680 µS·cm⁻¹ but stabilized quickly and without a negative impact on system performance. Even without cleaning, minimal fouling and flux decline were observed for all tested configurations thanks to the use of granular biomass and low permeation flux. Permeate flux in the case of the NF-like membrane was slightly lower due to the required higher pressure. The present study demonstrated that the EOL-RO membranes may find applications in HR-AnMBRs to achieve superior permeate quality and move toward circular membrane processes. Full article

Anaerobic digestion (AD) technology is universally acknowledged as the most economically viable and efficient approach for energy recovery from livestock manure. To validate the efficacy of riboflavin-functionalized carbon-based conductive materials (CCM-RF) in enhancing methane production at pilot scale, three pilot-scale upflow anaerobic sludge blanket (UASB) reactors were constructed and separately supplemented with carbon cloth (CC), granular activated carbon (GAC), and a combination of CC and GAC. During reactor initialization, riboflavin and a concentrated inoculum of Methanosarcina barkeri (M. barkeri) were introduced to investigate the mechanistic role of CCM-RF in promoting direct interspecies electron transfer (DIET) and optimizing treatment efficiency during anaerobic digestion of cattle manure wastewater. The results showed that all reactors improved AD performance and maintained stable operation at the OLR of 15.66 ± 1.95 kg COD/(m³·d), with a maximum OLR of 20 kg COD/(m³·d) and the HRT as short as 5 days. Among the configurations, the CC reactor outperformed the others, achieving a methane volumetric yield of 6.42 m³/(m³·d), which represents an eight-fold increase compared to conventional AD systems. Microbial community analysis revealed that, although M. barkeri was initially inoculated in large quantities, Methanothrix—a methanogen with DIET capability—eventually became the dominant species. The enrichment of Methanothrix and the simultaneous enhancement in sludge conductivity collectively verified the mechanistic role of CCM-RF in promoting CO₂-reductive methanogenesis through strengthened DIET pathways. Notably, M. barkeri showed progressive proliferation under conditions of high organic loading rates (OLR) and short hydraulic retention time (HRT). This phenomenon provides a critical theoretical basis for the development of future strategies aimed at the targeted enrichment of Methanosarcina-dominant microbial consortia. Full article

The anaerobic ammonium oxidation (anammox) process offers potential for saline wastewater treatment but is hindered by salt inhibition. This study investigates the salt tolerance mechanisms of granular (R1), biofilm-carrier (R2), and floccular (R3) sludge in up-flow anaerobic sludge blanket (UASB) reactors under 0–20 g/L NaCl. Granular sludge outperformed other biomass types, maintaining >90% ammonia nitrogen (${\mathrm{NH}}_4^{+}$-N) removal at 20 g/L NaCl due to structural stability and extracellular polymeric substances (EPS) adaptation (shift from hydrophobic proteins to polysaccharides). Microbial analysis revealed a transition from Planctomycetes/Proteobacteria to salt-tolerant Pseudomonadota, with Candidatus_Kuenenia replacing Candidatus_Brocadia as the dominant anaerobic ammonium oxidation bacteria (AnAOB) (reaching 14.5% abundance in R1). Genetic profiling demonstrated coordinated nitrogen metabolism: Hzs/Hdh inhibition (>85%) and NirBD/NrfAH activation (0.23%) elevated ${\mathrm{NH}}_4^{+}$-N, while NarGIV/NapA decline (1.10%→0.58%) increased nitrate nitrogen (${\mathrm{NO}}_3^{-}$-N). NxrB/NirSK maintained low nitrite nitrogen (${\mathrm{NO}}_2^{-}$-N), and GltBD upregulation (0.43%) enhanced osmoregulation. These findings underscore the superior resilience of granular sludge under high salinity, linked to microbial community shifts and metabolic adaptations. This study provides critical insights for optimizing anammox processes in saline environments, emphasizing the importance of biomass morphology and microbial ecology in mitigating salt inhibition. Full article

The biotechnological conversion of CO₂ to biomethane represents an energy-efficient, environmentally friendly, and sustainable approach within the waste-to-energy cycle. This process, in which CO₂ and H₂ are converted to biomethane in anaerobic bioreactors, is referred to as hydrogenotrophic biomethane production. While several studies have investigated hydrogenotrophic biomethane production, there is a lack of research comparing flocculent and granular sludge inoculum in continuously operated systems fed with a gas substrate. Both granular and flocculent sludge possess distinct advantages: granular sludge offers higher density, stronger microbial cohesion, and superior settling performance, whereas flocculent sludge provides faster substrate accessibility and more rapid initial microbial activity. In this study, two UASB (Upflow Anaerobic Sludge Blanket) reactors operated under mesophilic conditions were continuously fed with synthetic off-gas composed of pure H₂ and CO₂ in a 4:1 ratio and were compared in terms of microbial community shifts and their effects on hydrogenotrophic biomethane production. Biomethane production reached 75 ± 2% in the granular sludge reactor, significantly higher than the 64 ± 1.3% obtained with flocculent sludge. Although hydrogen consumption did not differ significantly, the granular sludge reactor exhibited higher CO₂ removal efficiency. Microbial analyses further revealed that granular sludge was more effective in supporting methanogenic archaea under conditions of gas substrate feeding. These findings offer advantageous suggestions for improving biogas production, enhancing waste gas management, and advancing sustainable energy generation. Full article

This study combines machine vision technology and deep learning models to rapidly assess the activity of anaerobic ammonium oxidation (Anammox) granular sludge. As a highly efficient nitrogen removal technology for wastewater treatment, the Anammox process has been widely applied globally due to its energy-saving and environmentally friendly features. However, existing sludge activity monitoring methods are inefficient, costly, and difficult to implement in real-time. In this study, we collected and enhanced 1000 images of Anammox granular sludge, extracted color features, and used machine learning and deep learning training methods such as XGBoost and the ResNet50d neural network to construct multiple models of sludge image color and sludge denitrification efficiency. The experimental results show that the ResNet50d-based neural network model performed the best, with a coefficient of determination (R²) of 0.984 and a mean squared error (MSE) of 523.38, significantly better than traditional machine learning models (with R² up to 0.952). Additionally, the experiment demonstrated that under a nitrogen load of 2.22 kg-N/(m³·d), the specific activity of Anammox granular sludge reached its highest value of 470.1 mg-N/(g-VSS·d), with further increases in nitrogen load inhibiting sludge activity. This research provides an efficient and cost-effective solution for online monitoring of the Anammox process and has the potential to drive the digital transformation of the wastewater treatment industry. Full article

Industrial activated sludge plants in many sectors, including the dairy industry, face sludge separation problems caused by sludge bulking. Aerobic granular sludge (AGS) could be a solution by forming well-settling granules. The key to successful granulation is the microbial selection of slow-growing glycogen-accumulating organisms (GAOs) by introducing an anaerobic feeding/reaction step. The objective of the current study was to investigate the impact of two slow feeding strategies to achieve granulation in existing sequencing batch reactors treating real dairy wastewater, by microbial selection only. The first strategy consisted of slow 90 min mixed feeding. The second strategy combined 45 min static and 45 min mixed feeding to build up a substrate gradient. The feeding strategies did not affect the effluent quality, but significantly impacted the sludge morphology, settling properties, and microbial community composition. Mixed feeding led to filamentous overgrowth by Thiothrix species, up to 45% abundance, and deteriorating settling, with sludge volume index (SVI) values up to 125 mL/g. In contrast, static feeding yielded densified sludge with SVI values below 45 mL/g and up to 35% GAO abundance. In conclusion, the results show successful granulation when using a simple static slow feeding mode, which could benefit the industrial application of AGS technology. Full article

Anaerobic digestion (AD) is one of the most significant processes for treating fecal sludge. However, a substantial amount of microplastics (MPs) have been identified in septic tanks, and it remains unclear whether they impact the resource treatment of feces. To investigate this, polyethylene terephthalate (PET) was used as an indicator of MPs to study their effect on the anaerobic digestion of fecal sludge (FS). Two digestion systems were developed: FS mono-digestion and FS co-digestion with anaerobic granular sludge. The results indicated that the effects of PET varied between the two systems. PET inhibited volatile fatty acid synthesis in both systems, but the inhibition period differed. During mono-digestion, PET slightly increased gas and methane production, in contrast to the co-digestion system, where PET reduced methane production by 75.18%. Furthermore, in the mono-digestion system, PET increased soluble chemical oxygen demand and ammonia nitrogen concentrations while blocking phosphorus release, whereas the co-digestion system showed the opposite effects. Ultimately, the choice of digestion method is crucial for the resource utilization of septic tank sludge, and the impact of MPs on AD cannot be ignored. Full article

The work presents the concept of aerobic granular sludge (AGS) and its potential for wastewater treatment. The work also evaluates the condition of the SBR (Sequencing Batch Reactor) type of municipal wastewater-treatment plant (WWTP) after its reconstruction into a system with AGS. The WWTP parameters achieved before and after reconstruction were compared. Operational measurements of the process during the individual phases of the treatment process showed a balanced concentration profile of the monitored parameters in the span of the semicontinuous cycle. Laboratory tests showed that the sludge from the WWTP has nitrification and denitrification rates comparable to the rates achieved for flocculent sludge, and it is also comparable to the nitrification and denitrification rates of AGS with size of granules below 400 µm. Despite the fact that complete sludge granulation was not achieved, the results measured at the WWTP confirmed the advantages of the AGS concept. Neither anaerobic nor anoxic conditions were identified in the SBR during the individual phases of operation, yet high removal efficiencies of ammonia and nitrate nitrogen and orthophosphate phosphorus were achieved. The concentration of ammonia and nitrate nitrogen at the WWTP effluent was below 5 mg/L, and the concentration of phosphorus was below 0.5 mg/L. Full article

Anaerobic wastewater treatment technology has been intensively and extensively investigated in the industry and scientific research. Inspired by the advantages of multi-stage and multi-phase anaerobic reactor technology (SMPA) in recent years, a three-stage anaerobic reactor (3S-AR) was designed and applied to treat poplar chemical–mechanical pulp wastewater, and various operation parameters, including the volume loading rate (VLR), hydraulic retention time (HRT), ascending velocity, reflux ratio, pH and temperature of the 3S-AR, were optimized to evaluate the reactor’s removal efficiency for poplar wastewater. The properties of anaerobic granular sludge and the composition of wastewater were also characterized to assess microorganism growth and pollutant migration. Results show that the COD removal rate was over 75% with a volume loading rate range of 15–25 gCOD/(L·d) in the 3S-AR; the hydraulic retention time was also found to be an important factor affecting the performance of the 3S-AR reactor. The volume loading rate and degradation efficiency of the 3S-AR reactor are higher than those of the up-flow anaerobic sludge blanket (UASB) reactor. Microorganism separation can be achieved in the 3S-AR, which is conducive to the growth and methanogenesis activity of bacteria, thereby leading to enhanced removal and buffering efficiency. After treatment in the 3S-AR, the main pollutants of poplar wastewater were benzene aromatic acids and long-chain esters, which do no biodegrade easily; in contrast, most of the fatty acid substances with small molecules were completely degraded. Full article

This study investigates the densification/granulation of activated sludge with poor settleability, treating real industrial wastewater from a tank truck cleaning company. The wastewater is low in nutrients, acidic in nature, and high and variable in chemical oxygen demand (COD, ranging from 2770 mg·L⁻¹ to 14,050 mg·L⁻¹). A microbial selection strategy was applied to promote slow-growing glycogen-accumulating microorganisms (GAO) by the implementation of an anaerobic feast/aerobic famine strategy in a sequencing batch reactor (SBR). After 60 to 70 days, the uptake of carbon during the anaerobic phase exceeded 80%, the sludge morphology improved, and the sludge volume index (SVI) dropped below 50 mL·g⁻¹. 16S rRNA gene sequencing showed the enrichment of the GAOs Defluviicoccus and Candidatus Competibacter. Stable sludge densification was maintained when using a constant organic loading rate (OLR) of 0.85 ± 0.05 gCOD·(L·d)⁻¹, but the sludge quality deteriorated when switching to a variable OLR. In view of the integration of densified/granular sludge in a membrane bioreactor configuration, the filtration properties of the densified SBR sludge were compared to the seed sludge from the full-scale plant. The densified sludge showed a significantly lower resistance due to pore blockage and a significantly higher sustainable flux (45 vs. 15 L·(m²·h)⁻¹). Full article

This study compared the behavior of the biomass in two fixed-film anaerobic reactors operated under equivalent organic loading rates but at different temperatures, i.e., 30 °C (RMM) and 55 °C (RMT). The reactors were fed with sugarcane vinasse and molasses (both fermented) in a simulation of sequential periods of season and off-season. The dynamics of biomass growth and retention, as well as the microbial composition, were assessed throughout 171 days of continuous operation, coupled with an additional 10-day test assessing the microbial activity in the bed region. Despite the different inoculum sources used (mesophilic granular vs. thermophilic flocculent sludge types), the biomass growth yield was identical (0.036–0.038 g VSS g⁻¹COD) in both systems. The retention rates (higher in RMT) were regulated according to the initial amount of biomass provided in the inoculation, resulting in similar amounts of total retained biomass (46.8 vs. 43.3 g VSS in RMT and RMM) and biomass distribution patterns (30–35% in the feeding zone) at the end of the operation. Meanwhile, hydrogenotrophic methanogenesis mediated by Methanothermobacter coupled to syntrophic acetate oxidation prevailed in RMT, while the Methanosaeta-mediated acetoclastic pathway occurred in RMM. The results show that different anaerobic consortia can behave similarly in quantitative terms when subjected to equivalent organic loads, regardless of the prevailing methane-producing pathway. The community grows and reaches a balance (or a given cell activity level) defined by the amount of substrate available for conversion. In other words, while the metabolic pathway may differ, the endpoint (the amount of biomass) remains the same if operational stability is maintained. Full article