Search Results (36)

To advance the development of protein-rich plant-based foods, a novel binder system for vegan sausage alternatives without the requirement of heat application was investigated. This enables long-term ripening of plant-based analogs similar to traditional fermented meat or dairy products, allowing for refined flavor and texture development. This was achieved by using a poorly water-soluble calcium source (calcium carbonate) to introduce calcium ions into a low-ester pectin—gluten matrix susceptible to crosslinking via divalent ions. The gelling reaction of pectin–gluten dispersions with Ca²⁺ ions was time-delayed due to the gradual production of lactic acid during fermentation. Firm, sliceable matrices were formed, in which particulate substances such as texturized proteins and solid vegetable fat could be integrated, hence forming an unheated raw-fermented plant-based salami-type sausage model matrix which remained safe for consumption over 21 days of ripening. Gluten as well as pectin had a significant influence on the functional properties of the matrices, especially water holding capacity (increasing with higher pectin or gluten content), hardness (increasing with higher pectin or gluten content), tensile strength (increasing with higher pectin or gluten content) and cohesiveness (decreasing with higher pectin or gluten content). A combination of three simultaneously occurring effects was observed, modulating the properties of the matrices, namely, (a) an increase in gel strength due to increased pectin concentration forming more brittle gels, (b) an increase in gel strength with increasing gluten content forming more elastic gels and (c) interactions of low-ester pectin with the gluten network, with pectin addition causing increased aggregation of gluten, leading to strengthened networks. Full article

The growing demand for healthier meat products has driven the reformulation of processed meats to reduce saturated fat while preserving sensory and technological attributes. Buffalo meat (Bubalus bubalis), with its high protein content, low intramuscular fat, and favorable fatty acid profile, offers a promising base for healthier formulations. However, its fat content may compromise texture, juiciness, and flavor, necessitating strategies to optimize product quality. This study investigated the effects of replacing pork fat with inulin and pumpkin seed oil in a cooked buffalo meat product, focusing on compositional, oxidative, microbiological, and sensory parameters. Two plant-based ingredients were selected: inulin from chicory, used as a fat mimic due to its gel-forming ability, and pumpkin seed oil, a structural analog with antimicrobial activity. Preliminary trials identified optimal concentrations for balancing technological and functional performance. A 2% inclusion of pumpkin seed oil, exceeding its in vitro MIC (0.4–1.5%), ensured effectiveness in the food matrix. Reformulated products exhibited significantly reduced fat (p < 0.05), enhanced fiber, and a lipid profile rich in polyunsaturated fatty acids (>45%), qualifying for European Union health claims. Oxidative stability improved (p < 0.01), and sensory analysis revealed enhanced aroma complexity, with nutty and roasted notes. Microbiological assessments confirmed a protective effect against spoilage bacteria. These results support the development of a nutritionally improved, microbiologically safer cooked product, such as mortadella-style sausage, while also offering strategies for broader innovation in reformulating functional meat products. Full article

This study reviews the feasibility of using cultivated mushrooms in the development of salt-reduced meat products. For this purpose, it is important to know the role of salt in meat products in order to develop viable strategies for its substitution. In addition, mushroom types and properties (composition, nutritional value, umami content, etc.) and examples of successful application as salt substitutes in meat products are addressed. Salt has important roles in meat product processing, mainly affecting its technological, antimicrobial, and sensory properties. Therefore, the different strategies that have been studied (meat product reformulation and technological advances) with the aim of reducing its content have to address these effects. The application of mushrooms as a salt substitute shows several advantages mainly related to the fact that mushrooms are a natural ingredient with a very healthy nutritional composition (rich in protein and dietary fiber but low in fat and sodium) and, from an economic and sustainable cultivation perspective, aligns well with current trends in food production and consumption. Salt substitutions of 50% have been achieved, mainly in fresh meat products (hamburgers) and heat-treated meat products (sausages, pâté, roast meat, etc.), with minimal physicochemical and sensory modifications of the final product. The meat industry could benefit from incorporating cultivated mushrooms as a salt-reducing ingredient, especially in the development of reduced salt meat products with a quality comparable to or superior to traditional products. The optimization of processes for their integration in the formulation of meat products should be the trend to ensure their viability. Full article

Wheat germ is a byproduct of the cereal industry that contains high levels of protein, fiber, B vitamins, minerals, and other functional microcomponents. However, so far, few applications have been found in the meat industry despite the growing interest in replacing meat with vegetable proteins. Therefore, the use of wheat germ for the production of low-fat frankfurters was considered. Five different formulations were prepared: control with pork meat and the following four to achieve 25%, 50%, 75%, and 100% lean meat substitution by wheat germ. Proximal composition, color, texture, emulsion characterization, fatty acid profile, fat oxidation, and consumer acceptance were then analyzed. The results showed that the incorporation of wheat germ improved emulsion stability, decreasing significantly total expressible fluid and jelly/fat separation, although increasing the back extrusion force. In terms of the final product, the progressive substitution of meat by germ resulted in significant increases in carbohydrates, in special of fiber, and ash as well as significant decreases in moisture and total fat. Sausages made with germ were darker (L*), as well as harder, chewier, and gummier, but less cohesive and elastic. Similarly, wheat germ substitution improved the quality of the lipid profile showing higher levels of, but decreased acceptability for replacements > 25%. Substitution of meat was feasible up to 25%, a formulation for which there was hardly any significant difference with the control. Full article

The physicochemical and microbiological properties of traditional Portuguese ready-to-eat dry fermented sausage chouriça de carne samples from 14 regional producers were analysed and subjected to multivariate analysis to determine the relationships between them and to evaluate how the quality and safety of these sausages is affected by these properties. Producer-mean values for physicochemical analyses were quite variable, with intervals of 4.87–6.11 for pH, 0.803–0.965 for a_w, moisture 19.5–48.5%, protein 32.0–60.1% (db), fat 22.0–53.3% (db), ash 3.52–9.69% (db), and carbohydrates 1.66–13.5% (db). Mesophilic counts varied (5.61–8.68 log CFU/g), while lactic acid bacteria were generally high (MRS: 8.21–10.2; M17: 7.66–10.0 log CFU/g). S. aureus was enumerated in levels up to 2.55 log CFU/g, while presumptive C. perfringens never surpassed 2 log CFU/g. Salmonella spp. and Listeria spp. were also detected in the samples tested. Principal component (PC) analysis yielded a three-dimension solution that explained 60% of the data variation; PC1 (26%) characterized chorizo formulations with more meat, while PC2 (19.3%) described sausages with longer/rapid fermentation, and PC3 (14.5%) highlighted chouriços with poorer hygiene. Cluster analysis identified three quality groups: (i) chorizos with high moisture, high protein content, and lowest pH; (ii) sausages with low moisture, high fat content, and elevated pH; and (iii) chouriças with high moisture and high protein but lower fat contents, low pH, and improved hygiene. Lastly, factor analysis yielded a varimax-rotated three-factor solution that explained 65% of the data, with similar results to PCA; factor 1 (23.5%) depicted chorizos with low pH but high moisture, factor 2 (20.8%) described sausages with more meat in the formulation, and factor 3 (20.6%) longer or rapid fermentation. Overall, the results evidenced the great variability in the quality attributes of Portuguese chorizo sausages, very likely to arise from multiple recipes, ingredients, and manufacturing practices. The definition of quality clusters is expected to play a crucial role for the self-denominated “artisanal” food companies to benchmark their chouriço sausages against the proper artisanal quality group. Full article

Background: Physical fitness and a healthy body mass are important predictors of a good performance of military tasks. The purpose of this study was to assess the physical activity level and nutrition, in terms of the frequency of consumption of individual food groups, of Polish Navy soldiers and Maritime Unit of the Border Guard officers. Materials and Methods: This study was conducted on 131 Polish Navy soldiers aged 33.1 ± 6.3 years old and 132 Maritime Unit of the Border Guard officers aged 38.6 ± 5.5 years old. In order to carry out research on physical activity, the International Physical Activity Questionnaire was used. Eating habits were assessed based on a Food Frequency Questionnaire for 61 groups of food products. Results: Over 80% of the soldiers and officers studied indicated high levels of physical activity. Only 8.2% of soldiers and 4.3% of officers indicated a low level of physical activity. Of the 61 food product groups analyzed, significant differences were found in the frequency of consumption of 17 products. These differences concerned almost all groups (except dairy products and eggs). Conclusions: To summarize, soldiers and officers presented high and moderate levels of physical activity. Taking into account the demonstrated frequent consumption of high-energy and high-fat products, such as sausages and red meat, as well as margarine, mayonnaise, and sugar, with the low frequency of fruit and vegetable consumption in both studied groups, it is advisable to conduct training among soldiers and officers in the field of health education. Full article

The present study was conducted to develop turkey sausages by incorporating freeze-dried apple pomace (FDAP) at 3, 5, and 8% by replacing turkey breast meat. Three sausage formulations and the control of turkey sausages were subjected to physicochemical properties: proximate content, water-holding capacity (WHC), cooking yield, pH, color, textural parameters, antioxidant activity, and microbiological and sensory properties. The parameters were analyzed during storage from days 0 to 7. The addition of FDAP to turkey sausages resulted in a significant (p ≤ 0.05) decrease in moisture and protein contents, whereas no significant difference was found in fat and ash contents. The increased incorporation of FDAP resulted in decreased pH, cooking loss, lightness, redness, and yellowness in turkey sausages, whereas an increase in total phenolic content, fiber content, ABTS, and DPPH values was observed. FDAP, as a low-cost source of valuable phenolic content, strongly inhibited microorganism growth during the storage of turkey sausages. The sensory scores of turkey sausages containing 3% FDAP for other sensory traits, such as flavor, texture, juiciness, tenderness, and overall acceptability, were comparable to those of the control. Scores for sensory attributes declined significantly with a further increase in FDAP in turkey sausages. It is concluded that turkey sausages with very good acceptability can be prepared by incorporating freeze-dried apple pomace each at a 3% level. Full article

Gluten-related disorders are treated with a gluten-free diet. The “basic food basket” (BFB) consists of a list of basic foods consumed by low-income groups in society, including those lowest-cost versions within each food category. To evaluate the cost, availability, and nutritional quality of the BFB and gluten-free BFB (GF-BFB), foods were photographed, registering their cost, availability, and nutritional characteristics, in high quality and mid-range supermarkets, wholesalers, health shops, and corner shops, matching each regular BFB product with a gluten-free equivalent. Of the 1177 potential products, the selection of lowest-cost foods yielded 55 and 47 products (BFB and GF-BFB, respectively). Breads/cereals and drinks showed the highest differences (279% and 146%, respectively) while meats and sausages showed the lowest ones (18.6%). The GF-BFB cost represents 30.1% of the minimum wage, which covers the cost of 5.2 and 3.3 of the BFB and GF-BFB per month, respectively. Availability ranged between 22.7 and 42.4%. Lower availability was associated with poorer nutritional quality in the GF-BFB, which provides 5% less energy, 26% more fat, and 25% less protein than the BFB. Only 47% of gluten-free products declared their “gluten-free” condition. The results strongly suggest that the GF-BFB must be redesigned to be both gluten-free and nutritionally adequate. Full article

Mechanically separated meat (MSM) is a by-product of the poultry industry that requires routine quality assessment. Calcium content is an indirect indicator of bone debris in MSM but is difficult to determine by EDTA titration due to the poor solubility of calcium phosphate. Therefore, 1,2-diaminocyclohexane-N,N,N’,N’-tetraacetic acid was used instead, which has two orders of magnitude higher affinity for calcium ions. In addition, the auxiliary complexing agents triethanolamine and Arsenazo III, an indicator that is sensitive to low calcium concentrations, were used. Automatic titration endpoint detection was performed using an immersion probe at 660 nm. It has been shown that the color change in Arsenazo III can also be read with an RGB camera. The CDTA titration procedure has been tested on commercial Bologna-type sausages and the results were in line with AAS and ICP reference data. The content of calcium in sausages turned out to be very diverse and weakly correlated with the content of MSM. The tested MSM samples had a wide range of calcium content: from 62 to 2833 ppm. Calcium-rich poultry by-products include fat and skin (115 to 412 ppm), articular cartilage (1069 to 1704 ppm), and tendons (532 to 34,539 ppm). The CDTA titration procedure is fully suitable for small meat processing plants due to its simplicity of use and low cost. Full article

The low fatization of high-fat foods is a significant trend that will impact the future developments of food products. Consumers have regarded health attributes as a critical indicator for purchasing food. In this study, enzyme-modified soy protein isolate, sea fish collagen, and ovalbumin were used to prepare the composite fat substitute for the protein matrix. This matrix was applied to the traditional surimi-based product Nemipterus virgatus fish sausage to replace the exogenous fat, and a new type of low-fat fish sausage was developed. This change is expected to reduce the exogenous fat in the traditional fish sausage without reducing the flavor and sensory quality of the original product. The results showed that taking the sensory evaluation and gel strength value of the product as indicators, the optimal ratio of compound fat substitute (enzyme-modified soy protein isolate:sea fish collagen:ovalbumin) was 2:1:3 when using the orthogonal test method for the first time. In the next step, with compound fat substitutes, exogenous fats and transglutaminase as the main factors, single factor and response surface method were used to explore the best formula of new low-fat Nemipterus virgatus fish sausage. The results showed that the best gel strength and sensory evaluation scores were obtained when the compound fat substitute, TGase, and exogenous fat were 0.59 g, 0.245 g, and 8.03 g, respectively. The optimal formulation of the low-fat Nemipterus virgatus fish sausage was obtained as follows: surimi, 67.52%; complex fat substitute, 0.66%; TGase, 0.28%; fat, 9.04%; starch, 6.75%; sugar, 3.94%; salt, 2.25%; monosodium glutamate, 0.23%; I&G, 0.34%; and water, 9%. Compared with the traditional fish sausage, the content of exogenous fat in the new, low-fat Nemipterus virgatus fish sausage was reduced by 54.8%. Meanwhile, the sensory score of fish sausage was increased by 21.79%, maintaining its good flavor and sensory quality. This study provides an important reference value for developing new low-fat surimi-based products. Full article

Dosidicus gigas is a kind of low-fat food with poor gel properties. Fermentation has been proved to be an effective food processing method that could improve the gel properties of meat. Here, we inoculated D. gigas with two strains, Lacticaseibacillus casei and Staphylococcus carnosus, that have been approved for use in meat processing, and studied their impact on the quality of the product. Compared with the uninoculated samples, inoculation with L. casei and mixed inoculation with L. casei and S. carnosus were able to significantly reduce pH during fermentation. The plate counting results showed that L. casei may have adapted well to the environment in the inoculated groups, while the growth of Staphylococcus may have been inhibited in the mixed inoculated group. 16s rRNA sequencing confirmed that inoculation significantly altered the bacterial composition of squid surimi sausages. Both inoculation with L. casei and mixed inoculation with L. casei and S. carnosus were able to inhibit the accumulation of the main biogenic amines, and in the mixed inoculated group, the main biogenic amines were lower. Compared with unfermented squid surimi sausages, mixed inoculation changed the texture, gel properties, color, and appearance of squid surimi sausages. These results showed that mixed inoculation can not only ensure safety, but also improve the quality of squid surimi sausages. Full article

Background: Sedentary behavior may affect the types of food consumed in children and adolescents’ daily diets. Previous published studies are limited to local surveys. This study aimed to explore the relationship between sedentary behavior and food intake among children and adolescents. Methods: A stratified sampling technique was employed in the present cross-sectional study. Demographic characteristics, sedentary behavior, transportation modes, and food intake were investigated. Results: We found that children and adolescents who watched movies or TV programs online or on their smartphones on weekends and who chatted online on weekends, including on QQ (an instant messaging software service) and WeChat (an instant messaging software service), increased their intake of instant noodles and fried pasta (Spearman’s rho = 0.468, 0.575, 0.465, and 0.323; p < 0.05). Children and adolescents who chatted online on weekends, including on QQ and WeChat, increased their intake of tofu skin (Spearman’s rho = 0.461; p < 0.05), and those who browsed online on weekdays increased their intake of whole-fat liquid milk (Spearman’s rho = 0.455; p < 0.05). Children and adolescents who browsed and chatted online on weekends, including on QQ and WeChat, and who played computer or smartphone games, increased their intake of fried potato chips (French fries or other fried snacks) (Spearman’s rho = 0.568, 0.270, and 0.412; p < 0.05). With respect to modes of transportation used to travel to and from school, children and adolescents who took buses and subways increased their intake of rice, instant noodles, sweet potatoes, soybean milk, tofu skin, processed meat products (sausage, ham sausage, or lunch meat), fish, shrimp, vegetables, nuts, and sweet cookies (buns, cakes, Dim sum, and moon cakes) (Spearman’s rho = 0.394, 0.536, 0.630, 0.408, 0.485, 0.441,0.410, 0.424, 0.444, 0.541, and 0.366; p < 0.05). Conclusions: Sedentary behavior affects the types of food consumed in children and adolescents’ daily diets. Children and adolescents who browsed online on weekdays increased their intake of whole-fat liquid milk, but also increased their intake of foods with high fat, high salt, and low nutrient density. Children and adolescents taking buses and subways increased their intake of low-nutrition quality products. Public awareness efforts should focus on reducing the consumption of low-nutrition quality products and nutritional education. Full article

The main objective of this study was to optimize the extraction of dietary fiber (insoluble dietary fiber and soluble dietary fiber) and degree of esterification from yellow dragon fruit peels using ultrasound-assisted extraction. Additionally, the study aimed to investigate the potential application of this fiber as a fat replacement in alpaca-based sausages. The optimization process for extracting dietary fiber and degree of esterification involved considering various factors, including the liquid-to-solid ratio, pause time, and total ultrasound application time. A Box–Behnken design consisting of 15 treatments was employed to determine the optimal levels for ultrasound-assisted extraction. The optimized conditions were found to be a liquid-to-solid ratio = 30 mL/g, pause time = 1 s, and total ultrasound application time = 60 min, which resulted in the highest values of insoluble dietary fiber (61.3%), soluble dietary fiber (10.8%), and the lowest value of degree of esterification (39.7%). The predicted values were validated against experimental data and showed no significant differences (p > 0.05). Furthermore, a completely randomized design was utilized to assess the effect of dietary fiber on replacing fat content during the production of alpaca-based sausages. The findings revealed that up to 78% of the fat content could be successfully replaced by soluble dietary fiber obtained from yellow dragon fruit peels when compared to high-fat sausages. Additionally, experimental sausages using soluble dietary fiber showed similar (p > 0.05) quality characteristics, such as hardness (24.2 N), chewiness (11.8 N), springiness (0.900), cohesiveness (0.543), redness (a* = 17.4), and chroma values (20.0), as low-fat commercial sausages. Full article

Vegetarian and vegan diets are increasingly being adopted in Spain, a trend mainly driven by ethical concerns for animal welfare and the environment. This has resulted in a growing market for plant-based substitutes of meat products. However, available data on the nutritional value of such meat analogues in Mediterranean countries are still limited. In this study, the labelling information of four categories of plant-based meat analogues (n = 100) and the corresponding conventional meat products (n = 48) available on the Spanish market was surveyed and compared. The nutrient content of plant-based meat analogues varied significantly, due to the wide range of ingredients used in their formulation. Some of these products were found to have a low protein content, which in others was enhanced by the addition of cereals and legumes. Compared to the meat products, the plant-based analogues contained lower levels of total fat as well as saturated fat, which ranged from 30% of total fat in burgers to less than 15% in meatballs, sausages, and nuggets; in contrast, they contained higher amounts of fiber and complex carbohydrates. Overall, the meat analogues cannot be considered as nutritionally equivalent substitutes to conventional meat products due to a high variability of protein content and other nutrients. Full article

The expansion of the assortment of low-saturated-fat sausages is a trend in healthy eating, and the use of alternative ways to reduce their saturated fat content is required. This study aimed to partially substitute pork fat with 7% and 10% oleogel, obtained by structuring sunflower oil with a two-component mixture of monoglyceride and beeswax, in the recipe for semi-smoked sausage. The physicochemical characteristics of the sausages were evaluated, and the fatty acid profile and sensory properties were analyzed. In the samples where pork fat was partially replaced with oleogel at 7% and 10%, there was a decrease in the content of saturated fatty acids (SFA) by 35% and 38%, respectively. The addition of oleogel to sausages significantly reduced the content of stearic and palmitic acid, increased the content of linoleic acid, and improved the fatty acid profile. The microstructure of the sausages showed a more homogeneous structure with a lower content of large lipid granules as the amount of oleogel added increased. The sensory analysis showed that the addition of 7% oleogel did not deteriorate the organoleptic properties. Therefore, the partial substitution of pork fat with 7% oleogel can be recommended to produce healthy sausages with improved fatty acid profile and sensory properties. Full article