Search Results (37)

This study examined the ability of four beneficial strains (Lactobacillus rhamnosus LbRE-LSAS, Bifidobacterium animalis subsp. lactis Bb12, and two yogurt starters TA040 and LB340) to ferment MRS or milk containing free linoleic acid (0, 0.5, or 1 mg/mL). The goal was to produce an enriched conjugated linoleic acid (CLA) isomers’ yogurt-type beverage. Linoleic acid (LA) at 0.5 mg/mL did not interfere with the growth of the assayed bacteria on de Man Rogosa and Sharpe broth (MRS) or milk. On the other hand, increasing the content of LA in the MRS or yogurt-type beverage to 1 mg/mL slightly inhibited all strains and prevented accumulating high biomasses. A gas chromatography analysis of the fatty acid profiles confirmed the bioconversion of LA. The yogurt starters TA040 and LB340 had the highest bioconversion rates in the yogurt-type beverages, whereas the probiotic Bb12 strain was the most interesting at converting LA into its active CLA. CLA from the MRS supernatants of TA040, Bb12, and LbRE-LSAS had maximum antibacterial activities against S. typhimurium, E. coli, and S. aureus, respectively. Whey from the Bb12 beverage showed an inhibitory effect against all pathogens. These results suggest that all strains could be used as starter cultures in the proposition of a yogurt-type beverage with a high CLA content and antibacterial potential. Full article

Protein-enriched yogurts have become increasingly popular among consumers seeking to boost their daily protein intake. The incorporation of milk proteins and protein preparations in yogurt production not only enhances nutritional value but also improves texture, viscosity, and overall sensory properties—key factors that influence consumer acceptance. The main objective of this study was to evaluate the influence of casein and whey protein preparations on the physicochemical properties, viability of lactic acid bacteria, and sensory attributes of yogurts. Yogurts were enriched with 2% (w/w) protein preparations, including micellar casein preparation (CN85), whey protein isolate (WPI), whey protein concentrate (WPC60), and protein preparations obtained from skim milk by membrane filtration: micellar casein concentrate (CN75) and serum protein concentrate (SPC). The yogurts were produced using the thermostatic method, and their chemical composition, rheological properties, syneresis, firmness, lactic acid bacteria population, and sensory attributes were evaluated. The effects of high-protein preparations derived from skim milk through laboratory-scale membrane filtration processes (SPC, CN75) were compared with those of commercially available protein preparations (SMP, CN85, WPI, and WPC). Obtained results demonstrated that the membrane filtration-derived preparations (SPC and CN75) exhibited advantageous physicochemical properties and supported robust viability of yogurt and probiotic bacteria. However, their sensory quality was marginally inferior compared to the commercial preparations (SMP, CN85, WPI, and WPC). These findings indicate the potential applicability of membrane filtration-derived protein preparations in yogurt production while underscoring the necessity for further investigation to enhance and optimize their sensory characteristics. Full article

Sweet whey (SW) and yogurt acid whey (YAW) are dairy by-products of the cheese-making process and Greek-style yogurt production, respectively. Both of them are considered pollutants with huge volumes of SW and YAW produced due to the growing demand for dairy products worldwide. Moreover, whey-derived peptides, resulting from fermentation as well as from further hydrolysis during digestion, have been associated with various biological activities. In the present study, the angiotensin-converting enzyme (ACE)-inhibitory activity of 48 SW samples and 33 YAW samples from bovine, ovine, caprine, and ovine/caprine milk obtained were evaluated. Additionally, the SW and YAW digestates and two of their fractions (smaller than 10 kDa, SW-D-P10 and YAW-D-P10, and smaller than 3 kDa, SW-D-P3 and YAW-D-P3), which were obtained after in vitro digestion and subsequent ultrafiltration, were also subjected to evaluation. Our data indicated that the D-P10 and D-P3 fractions exhibited higher ACE-inhibitory activity compared to the corresponding values before digestion. The ACE-inhibitory capacity after in vitro digestion was higher for the ovine SW samples compared to their bovine and caprine counterparts. The effect of the D-P3 fraction on the inhibition of nitric oxide (NO) production and the expression of a selected panel of immune-response-related genes in LPS-stimulated RAW 264.7 macrophages was also evaluated. Fractions from both dairy by-products inhibited NO production in LPS-stimulated RAW 264.7 cells. Especially, ovine SW-D-P3 showed a strong NO inhibitory activity and suppressed inducible nitric oxide synthase (Nos2) mRNA levels. However, YAW-D-P3 could not trigger neither the gene expression of inflammatory macrophage mediators Nos2 and cyclooxygenase-2 (Ptgs2) nor tumor necrosis factor-α (Tnf) and interleukin 6 (Il6) in LPS-stimulated murine macrophages regardless of animal origin. These findings suggest that in vitro digestion could enhance the production of ACE-inhibitory peptides in both dairy by-products, while SW from ovine origin displays higher potential as an anti-inflammatory agent, effectively preventing excessive NO production. Full article

This work investigated the fermentation kinetics and characteristics of goat yogurt supplemented with bovine whey protein isolate (WPI) (0%, 2.5% and 5.0%) subjected to high shear dispersion (HSD) assisted by ultrasound (US). Protein supplementation and the physical processes increased the electronegativity of the zeta potential (≤60%), whereas particle size reduction was observed only with physical processes (≤42%). The addition of 2.5% WPI reduced yogurt fermentation time by 30 min. After 24 h of storage at 7 °C, lactic acid bacteria counts did not differ between samples (≥8 log CFU/mL), and the supplementation was sufficient to increase the apparent viscosity (≤5.65 times) and water-holding capacity (WHC) of the yogurt (≤35% increase). However, supplementation combined with physical processes promoted greater improvements in these parameters (6.41 times in apparent viscosity and 48% in WHC) (p < 0.05), as confirmed by the denser and better-organized protein clusters observed in microscopic evaluation. Thus, both approaches proved to be promising alternatives to improve goat yogurt quality. Therefore, the decision to adopt these strategies, either independently or in combination, should consider cost implications, the product quality, and market demand. Full article

Drinkable yogurts are low-viscosity beverages often created by diluting yogurt with water or high-value-fluid milk. Yogurt acid whey, a typically discarded byproduct of the Greek yogurt industry, may serve as an upcycled ingredient for these types of products with minimal processing. In this study, differing concentrations of acid whey (35%, 40%, and 45% w/w) were added to a mango yogurt beverage with 0.2% and 0.4% w/w stabilizer and analyzed for physicochemical properties over a 40-day period. The analysis indicated that the percentage of acid whey was positively correlated with both viscosity and water-holding capacity. A hedonic sensory analysis of the beverages indicated positive consumer acceptance of such upcycled products, with enhanced acceptance at 25–35% addition. This study demonstrates the potential for consumer acceptance of yogurt beverages upcycled with native-acid whey, providing insights into sustainable practices within the food industry. Full article

Soybean whey contains high levels of off-flavors and anti-nutritional factors and is generally considered unsuitable for direct application in the food industry. In this work, to reduce beany off-flavors and anti-nutritional factors, and to improve its fermentation characteristics, soybean whey was treated with electrodialysis desalination, vacuum concentration and lactic acid bacteria (LAB) fermentation. The results showed that electrodialysis desalination increased the fermentation rate and the number of viable lactic acid bacteria of soybean whey yogurt. More than 90% of the antinutritional factor level (urease and trypsin inhibitory activity) was removed due to high-temperature denaturation inactivation and LAB degradation. Concentrated desalted soybean whey yogurt (CDSWY) possessed larger values for firmness and consistency, and a denser network microstructure compared with undesalted yogurt. Over 90% of off-flavors including hexanal, 1-octen-3-ol and 1-octen-3-one were removed after electrodialysis desalination and concentration treatment. Meanwhile, the newly generated β-damascenone through carotenoid degradation and 2,3-butanedione improved the pleasant flavor and sensory quality of CDSWY, while the salty taste of CSWY lowered its sensory quality. This study provided a theoretical basis for better utilization of soybean whey to develop a plant-based yogurt like dairy yogurt. Full article

The growing global market of dairy products has led to the need for alternative approaches regarding whey valorization, which is the primary by-product of cheese and strained yogurt production. In this context, prebiotic galactooligosaccharides can be produced enzymatically from whey using commercially available β-galactosidases. A comparative study was conducted to assess the production of galactooligosaccharides from sweet and acid whey, thereby employing two commercial β-galactosidases from Aspergillus oryzae and Kluyveromyces lactis. The study considered the initial lactose content and enzyme load as variables. The maximum yields of galactooligosaccharides in concentrated sweet whey (15% w/v initial lactose) and raw acid whey (3.1% w/v initial lactose) reached 34.4 and 14.7% with lactase from Kluyveromyces lactis (0.13 U/mL), respectively. The corresponding galactooligosaccharide yields for lactase from Aspergillus oryzae were equal to 27.4 and 24.8% in the most concentrated sweet and acid whey, respectively, using enzyme loads of 2 U/mL in sweet whey and 1 U/mL in acid whey. Concerning the profile of the produced galactooligosaccharides, the Kluyveromyces lactis lactase hydrolyzed lactose more rapidly and resulted in higher levels of allolactose and lower levels of 6-galactosyl-lactose, compared to the lactase from Aspergillus oryzae, and achieved in both cases a polymerization degree of up to six. Full article

Yogurt acid whey (YAW) is a by-product of Greek strained yogurt production. The disposal of YAW constitutes an environmental problem, and given the increasing demand of Greek yogurt worldwide, its handling is a challenge. However, whey-derived peptides, resulting from microbial fermentation as well as those resulting from further hydrolysis during the digestion process, have been linked to enhanced biological activities. In this study, the antioxidant capacity of 33 samples of YAW obtained from Greek dairy companies of bovine, ovine or caprine origin was investigated using both cell-free and cell-based assays. The YAW samples, their in vitro digestion products (YAW-Ds) and a fraction of the digests (less than 3 kDa; YAW-D-P3) were assessed using four biochemical assays, namely ORAC, ABTS, FRAP and P-FRAP. Our data revealed a higher antioxidant capacity for digested samples compared with undigested samples, with all four methods. ORAC values after in vitro digestion were higher for the ovine samples compared to their bovine (YAW-D and YAW-D-P3) and caprine (YAW-D-P3) counterparts. Furthermore, the YAW-D-P3 fraction derived from samples collected in the summer months exhibited higher ORAC values when compared to the respective fraction from the winter months’ samples. The cellular antioxidant activity of ovine YAW-D-P3 was improved in H₂O₂-treated HT29 cells compared to the control H₂O₂-treated cells. However, YAW-D-P3 could not trigger either the pathways involving the transcription factors NF-κB or NFE2L2 or the gene expression of SOD1, CAT and HMOX1 in LPS-challenged THP-1-derived macrophages. These results suggest that YAW, and particularly YAW from ovine origin, could be used as a natural source for its antioxidant potential in human and animal nutrition. Full article

The increasing popularity of Greek yogurt generates large amounts of acid whey worldwide. The use of yogurt acid whey in animal nutrition is limited. The aim of this study was to determine the effect of a yogurt acid whey powder (YAWP) addition to maize forage prior to ensiling on the nutritional, microbial and fermentation quality of maize silage. Depending on the addition level of the YAWP to maize forage, there were the following four experimental treatments: YAWP 0, 2.5, 5 and 10% w/w. An increasing YAWP inclusion level linearly increased the maize silage dry matter, crude protein and ash concentrations, whereas it reduced the crude fiber, neutral-detergent fiber and acid-detergent fiber concentrations. The silage pH decreased quadratically with the increasing YAWP level, with the lower plateau noted for the YAWP 5% addition. Concentrations of total bacteria in the silage and Lactobacillus spp. decreased linearly with the YAWP increase. The silage acetic acid content decreased linearly, whereas propionic acid, lactic acid and the ratio of lactic to acetic acid increased linearly with the increasing YAWP level. The ammonia-N content decreased linearly with the increasing YAWP level. In conclusion, the incorporation of the 5 and 10% YAWP addition in silage preparation improved the nutritional and fermentative quality of the produced silage. Full article

Fermented dairy products not only have a long shelf-life but also have beneficial nutritional values. The products are deficient in dietary fiber and certain bioactive compounds. Adding grains to dairy products is a widespread practice to improve the nutritional and economic aspects. In this work, we studied the effect of fermented millet–milk beverages (FMBs) using pearl millet grains and three different dairy by-products (sweet whey, sweet buttermilk, and skimmed milk). A control treatment prepared with water was also manufactured for comparison. Samples were continuously prepared and fermented using a commercial yogurt starter culture (YC-381) containing L. delbrueckii subsp. bulgaricus, Streptococcus thermophilus, and a pure strain of L. paracasei subsp. Paracasei. Four FMBs (water based: WB-FMB, whey based: WHB-FMB, buttermilk based: BMB-FMB, and skimmed milk based: SMB-FMB) were analyzed during cold storage at 4 °C for up to 15 days for chemical, microbiological properties, minerals content, antioxidant properties, glycemic index, and glycemic load on days 1, 8, and 15. The sensory characteristics of the FMBs were also evaluated during cold storage (4 °C/15 days). In general, the progression of acidity was slower in SMB-FMB and WHB-FMB samples during fermentation compared to in the BMB-FMB sample. The longest fermentation time was for the SMB-FBM sample (3 h), while the shortest was for the BMB-FMB sample (1.5 h). Reflecting the good manufacturing practices, all samples were free of coliform, mold, and yeast. No bacterial growth was detected in the WB-FMB sample at days 8 and 15 of storage, while the growth of Lactobacillus spp. and S. thermophilus was significantly higher (9.97 ± 0.01 and 9.48 ± 0.06, respectively) in the BMB-FMB sample compared to in the other three FMBs. The FMBs produced using dairy by-products had more antioxidant properties. All samples were better perceived during sensory evaluation by panelists than the water-based sample, except for the BMB-FMB sample, in which a bitter taste appeared. In the BMB-FMB sample, the proteolytic degree was significantly higher (4.8 ± 0.09) after 3 h of fermentation by about 460% than in the fresh sample. All samples had a low glycemic index and glycemic load. In addition, acidity progression was slower in SMB-FMB and WHB-FMB samples during fermentation and storage compared to the WB-FMB sample. Therefore, it could be recommended that it is more beneficial to prepare fermented millet–milk beverages using dairy by-products and suitable starter cultures under optimal fermentation conditions instead of using water to maximize the nutritional and economic aspects. Full article

Yogurt acid whey (YAW), a by-product of strained yogurt production, is a strong environmental pollutant because of its high organic load. Hence, efforts are made for its utilization to minimize its disposal in the environment. This study deals with the incorporation of YAW in yogurt ice cream (YIC) by partial replacement of yogurt with simultaneous lactose hydrolysis (LH) of the formulated YIC mix. Six YIC mix formulations were made, two without YAW (non-LH- and LH-control samples, A and AH), two with 12.5% YAW (samples B and BH), and two with 18.75% YAW (samples C and CH). The results showed that the partial replacement of yogurt with YAW decreased significantly (p < 0.05) the total solids of B, BH, C, and CH products (31.72 ± 0.14%, 31.92 ± 0.21%, 30.94 ± 0.14%, and 31.27 ± 0.10%, respectively) compared to the total solids of control products A and AH (33.30 ± 0.36% and 33.74 ± 0.06%, respectively). In contrast, the overruns increased (51.50 ± 2.36%, 58.26 ± 0.09%, 56.86 ± 1.92%, and 65.52 ± 1.30% for the B, BH, C, and CH products, respectively) compared to control samples (42.02 ± 2.62% and 49.53 ± 2.12% for A and AH, respectively). LH significantly decreased the freezing point and the viscosity of the YIC mixes but increased the overruns of the products as shown previously. YAW significantly decreased the hardness of the B and C products (56.30 ± 2.11 N and 43.43 ± 3.91 N, respectively) compared to control A (81.14 ± 9.34 N), and LH decreased it even more, leading to a rather soft scoop YIC. AH, BH, and CH YICs exhibited better melting properties despite the lack of fat destabilization in all samples. After 60 days of storage, counts of yogurt starter microorganisms were still >10⁷ cfu/g and DPPH radical scavenging activity had increased in all products. In the sensory evaluation test, lactose-hydrolyzed samples AH, BH, and CH had less intense sandiness and, as expected, more intense sweetness. In conclusion, in the framework of the circular economy, it is possible for the YAW to be used as a resource material at a ratio of 12.5% to produce a YIC product without leaving behind any new waste. Full article

Cheese whey (CW) is the liquid by-product of cheese and yogurt making. This potential pollutant has high-quality nutrients exploitable through fermentation processes. Using high-intensity ultrasound on dairy products has shown several technological advantages for bioprocesses. Therefore, this study aimed to investigate the effect of high-intensity ultrasound (HIUS) on kefir grains biomass increase and specific metabolites in CW kefir. Fresh CW was ultrasonicated at 9.0 ± 2.7 and 18.0 ± 3.0 W/cm² for 30 and 180 s, inoculated with kefir grains, and fermented for 40 h. Total exopolysaccharide production, kefir grains biomass increase, titratable acidity, pH, and soluble solids were analyzed every 8 h. CW pretreated with 18.0 ± 3.0 W/cm² for 180 s and fermented for 16 h had significantly higher (p < 0.05) total exopolysaccharide concentration than the control: 212.7 ± 0.0 and 186.6 ± 0.0 mg/L, respectively. Ultrasonicated CW at 18 W/cm² for 30 and 180 s at 24 h fermentation time had significantly higher kefir grains biomass (p < 0.05) than the control: 44.2 ± 0.8 and 43.6 ± 0.9 g/L, and 40.5 ± 0.4 g/L, respectively. Fresh CW pretreated with HIUS enhanced the biosynthesis of kefir beverage total exopolysaccharides concentration and kefir grains biomass. Full article

The production of cream cheese, curd, high-protein yogurt, or caseinate results in large amounts of acid whey as a by-product. So far acid whey is often disposed as animal feed or organic fertilizer. However, these approaches ignore the valorization potential that arises from the unique composition of the whey protein fraction. Whey contains the biofunctional proteins lactoferrin and immunoglobulin G, which possess immune-supporting, antibacterial, antiviral, and numerous further health-promoting functions. However, the concentration of these proteins in bovine milk or whey is below a physiologically relevant level. Based on literature research we specified a daily intake of 200 mg lactoferrin as the minimal functional dose. By means of cross-flow ultrafiltration, an attempt was made to increase the concentration of biofunctional proteins. Therefore, a membrane for the selective retention of lactoferrin and immunoglobulin G was identified, and the process parameters were optimized. Finally, a concentration experiment was conducted, whereby the concentration of biofunctional proteins was increased up to factor 30. The biofunctionality was assessed in a microbiological assay. Surprisingly, the antimicrobial growth inhibition of the produced concentrate was even higher than in pure lactoferrin. The presented approach offers a strategy to convert an abundant but underutilized by-product into valuable products for human nutrition. Full article

As the Greek-style yogurt market continues to experience prosperous growth, finding the most appropriate destination for yogurt acid whey (YAW) is still a challenge for Greek yogurt manufacturers. This study provides a direct alternative treatment of YAW by leveraging the abilities of Mucor circinelloides and Mucor genevensis to raise the pH of YAW and to produce fungal biomass with a high lipid content. Aerobic cultivations of these species were conducted in YAW, both with and without the addition of lactase, at 30 °C, and 200 rpm agitation. The density, pH, biochemical oxygen demand (BOD), biomass production, lipid content, fatty acid profile, and sugar and lactic acid concentrations were regularly measured throughout the 14-day cultivations. The data showed that M. genevensis was superior at deacidifying YAW to a pH above 6.0—the legal limit for disposing of cultured dairy waste. On the other hand, M. circinelloides generated more fungal biomass, containing up to 30% w/w of lipid with high proportions of oleic acid and γ-linolenic acid. Additionally, the treatments with lactase addition showed a significant decrease in the BOD. In conclusion, our results present a viable treatment to increase the pH of YAW and decrease its BOD, meanwhile generating fungal oils that can be further transformed into biodiesel or processed into functional foods or dietary supplements. Full article

The aim of this work was to develop a yogurt fortified with curcumin. Curcumin is a lipophilic compound with a wide range of biological activities; however, it presents low water solubility and low bioavailability, and therefore it was the first to be encapsulated in solid lipid nanoparticles (SLNs). Then the influence of the incorporation of curcumin-loaded SLNs on the physicochemical (i.e., pH, titratable acidity, syneresis and color) and rheological properties of yogurt during its shelf-life (30 days at 4 °C) was evaluated. SLN incorporation into yogurt did not affect pH and titratable acidity compared to the control (i.e., plain yogurt) during shelf-life, even though the yogurt with SLNs presented lower values of pH (4.25 and 4.34) and acidity (0.74% lactic acid and 0.84% lactic acid) than the control in the end, respectively. Furthermore, the yogurt with SLNs presented slightly higher values of syneresis than the control during the shelf-life; however, it did not present visual differences in whey separation. Relative to the color, the incorporation of SLNs into the yogurt imparted a strong yellow color to the sample but did not affect color stability during shelf-life. Both samples showed flow curves with yield stress and shear-thinning behavior during shelf-life, and, regarding the viscoelastic behavior, both showed a typical weak viscoelastic gel with an elastic structure. Overall, curcumin-loaded SLNs incorporation did not affect the physicochemical and rheological stability of yogurt during shelf-life, showing a promising application for the development of new functional foods. Full article