Search Results (11)

Topical and transdermal dosage forms can localize therapy or provide controlled systemic exposure, but translation is limited by the selective stratum corneum (SC) barrier and post-application changes in formulation. Existing reviews often address individual enhancers or carriers without integrating drug properties, vehicle microstructure, post-application transformation, quality of evidence, and product development constraints. This review fills that gap by comparing passive formulations, chemical permeation enhancers, vesicular and lipid-based carriers, supersaturating systems, and physical barrier bypass technologies within a skin barrier-informed framework. Increased permeation alone does not establish translational value. Passive delivery remains most feasible for potent, moderately lipophilic small molecules. Chemical enhancers are scalable but limited by irritation and drug-dependent compatibility; nanocarriers may improve solubilization and cutaneous deposition but often lack human confirmation; and physical methods broaden delivery to macromolecules while adding device, manufacturing, usability, and regulatory burdens. Solvent evaporation, residual film composition, supersaturation, precipitation, and drug–vehicle affinity further determine the effective post-application driving force. Accordingly, we propose an evidence-ranked framework linking payload properties and target compartment to mechanism, safety, clinical readiness, and regulatory complexity. It distinguishes mechanistic promise from clinically demonstrated delivery and identifies the evidence needed to advance reproducible topical and transdermal products. Full article

Background/Objectives: Oral surgical procedures in patients at risk of/diagnosed with MRONJ require systemic antibiotic therapy, which can fail to achieve an adequate local drug concentration. This research aims to design mucoadhesive buccal patches (containing erythromycin or the erythromycin–resveratrol combination) tailored to the therapeutic needs of patients at risk of MRONJ undergoing oral surgery. Methods: Erythromycin (ERY) and resveratrol (RSV) were embedded into lipid-based microparticles prepared via hot melt dispersion. The microparticles, recovered in the form of dry powders, were characterized in terms of yield, softening/melting temperature, active(s) content, physical state (amorphous vs. crystalline), and individual and bulk properties. Then, they were loaded into a hydrophilic gel, which was dried, obtaining microparticle-loaded buccal patches. The optimized patches were characterized in terms of uniformity, folding endurance, swelling, mucoadhesion, and oromucosal permeation/retention. Results: The microparticles were efficiently produced via a green approach, resulting in reproducible pharmaceutical powders with high loading efficacy (≈90%), spherical morphology, particle sizes in the range of approximately 106–425 μm, and a softening temperature close to body temperature. The buccal patches were also obtained via a green approach, and were found to be thin, flexible, homogeneous, highly swellable, extremely mucoadhesive, and able to promote ERY and RSV accumulation in the buccal tissue (≈25% and 2% of ERY and RSV, respectively, after 2 h) while avoiding active(s) absorption. Conclusions: The proposed buccal patches are viable candidates for further clinical trials aimed at evaluating both the effectiveness of locoregional antibiotic treatment and the usefulness of the co-administration of RSV and ERY. Full article

Hydroxytyrosol (HXT), a phenolic compound from olive, shows great potential as a neuroprotective agent and a translational target for claim-ready nutrition and food products. Human studies increasingly report benefits for vascular function, inflammatory tone, and early cognitive/psychomotor outcomes, consistent with engagement of redox and signalling pathways (Keap1–Nrf2–ARE, PI3K/Akt–ERK, and AMPK–SIRT1–PGC-1α). HXT is rapidly absorbed and likely reaches the brain, acting on endothelial and microglial targets. On the neurovascular axis, it reduces oxidative stress, preserves nitric-oxide bioavailability, lower inflammatory markers, and favourable intrinsic connectivity. For product development, bitterness from oleuropein-rich inputs can be mitigated by hydrolysis, followed by structure-guided delivery to balance sensory quality with exposure. Viable formats include cyclodextrin inclusion, microencapsulation, and (micro)emulsions in lipid matrices, plus stability engineering for aqueous systems (acidification, chelation, low-oxygen handling, or barrier packaging). Matrix effects are consequential; some proteins and fibers may decrease HXT bioaccessibility, whereas lipid phases and microstructured carriers often enhance it. Clinically, recommended doses are ~7–15 mg/day chronically and ~30–60 mg acutely. As conclusions of this review, future work should prioritize harmonized pharmacokinetics–pharmacodynamics readouts, cognition anchored to a compact neurovascular/blood–brain barrier biomarker core, and head-to-head comparisons of manufacturable delivery formats. Full article

Many therapies require the transport of therapeutic compounds or substances encapsulated in carriers that reduce or, if possible, eliminate their direct contact with healthy tissue and components of the immune system, which may react to them as something foreign and dangerous to the patient’s body. To date, inorganic nanoparticles, solid lipids, micelles and micellar aggregates, liposomes, polymeric micelles, and other polymer assemblies were tested as drug carriers. Specifically, using polymers creates a variety of options to prepare nanocarriers tailored to the chosen needs. Among polymers, aliphatic polyesters are a particularly important group. The review discusses controlled synthesis of poly(β-butyrolactone)s, polylactides, polyglycolide, poly(ε-caprolactone), and copolymers containing polymacrolactone units with double bonds suitable for preparation of functionalized nanoparticles. Discussed are syntheses of aliphatic polymers with controlled molar masses ranging from a few thousand to 10⁶ and, in the case of polyesters with chiral centers in the chains, with controlled microstructure. The review presents also a collection of methods useful for the preparation of the drug-loaded nanocarriers: classical, developed and mastered more recently (e.g., nanoprecipitation), and forgotten but still with great potential (by the direct synthesis of the drug-loaded nanoparticles in the process comprising monomer and drug). The article describes also in-vitro and model in-vivo studies for the brain-targeted drugs based on polyester-containing nanocarriers and presents a brief update on the clinical studies and the polyester nanocarrier formulation approved for application in the clinics in South Korea for the treatment of breast, lung, and ovarian cancers. Full article

Exploring the effect of bile salts on the properties of emulsion carriers containing hydrophobic bioactive compounds is particularly critical to understanding the stability and bioavailability of these hydrophobic bioactive compounds in the digestive process. In this study, the effects of bile salts on the stability and digestive characteristics of the ursolic acid (UA) self-stabilized water-in-oil (W/O) emulsion were investigated via static and dynamic (with or without enzyme) in vitro simulated digestive systems. The results showed that under the static system, the basic conditions had less interference, while the bile salts had a significant effect on the appearance and microstructure of the emulsion. The primary mechanism of emulsion instability is hydrophobic binding and depletion flocculation. Under the dynamic condition, it was found that the low concentrations of bile salts can promote the release amount and the rate of free fatty acids via displacement, while high concentrations of bile salts inhibit the decomposition of lipid, which may be related to the secondary coverage formed at the interface by the bile salts. These findings provide a theoretical basis for understanding the digestive behavior of the UA emulsion and its interaction with bile salts, which are conducive to developing and designing new emulsions to improve the bioaccessibility of UA. Full article

The objective of this study was to extract the rapeseed protein from by-products and further examine the effect of lab-made rapeseed protein on the droplet size, microstructure, colour, encapsulation and apparent viscosity of emulsions. Rapeseed protein-stabilised emulsions with an increasing gradient of milk fat or rapeseed oil (10, 20, 30, 40 and 50%, v/v) were fabricated using a high shear rate homogenisation. All emulsions showed 100% oil encapsulation for 30 days of storage, irrespective of lipid type and the concentration used. Rapeseed oil emulsions were stable against coalescence, whereas the milk fat emulsion showed a partial micro-coalescence. The apparent viscosity of emulsions raised with increased lipid concentrations. Each of the emulsions showed a shear thinning behaviour, a typical behaviour of non-Newtonian fluids. The average droplet size was raised in milk fat and rapeseed oil emulsions when the concentration of lipids increased. A simple approach to manufacturing stable emulsions offers a feasible hint to convert protein-rich by-products into a valuable carrier of saturated or unsaturated lipids for the design of foods with a targeted lipid profile. Full article

Different mucoadhesive systems have been studied in recent years to increase the residence time of the delivery systems and to prolong the release of the drug. The aim of this work was to evaluate the mucoadhesive properties of chitosan-based Microstructured Lipid Carrier (CH-MLC) with a new approach which requires chitosan and mucin to be compacted into a tablet and mucoadhesion to be assessed on a non-mucoadhesive substrate. This type of test showed that chitosan maintains a close bond with mucin even in the presence of a fluid and even encapsulated in microparticles. After this, using a bioreactor, the release of N-acetylcysteine (NAC) from the microparticles (NA-CH-MLC) through a layer of mucus mimicking the pathological conditions of a patient with cystic fibrosis was tested. The release of the active from NAC-CH-MLC demonstrated how the chitosan inside the microparticles acts as a penetration enhancer and how the microparticles can impart a prolonged release over time. Full article

Lipid-based biphasic microparticles are generally produced by long and complex techniques based on double emulsions. In this study, spray congealing was used as a solvent-free fabrication method with improved processability to transform water-in-oil non-aqueous emulsions into spherical solid lipid-based particles with a biphasic structure (b-MPs). Emulsions were prepared by melt emulsification using different compositions of lipids (Dynasan^®118 and Compritol^®888 ATO), surfactants (Cetylstearyl alcohol and Span^®60) and hydrophilic carriers (PEGs, Gelucire^®48/16 and Poloxamer 188). First, pseudo-ternary phase diagrams were constructed to identify the area corresponding to each emulsion type (coarse emulsion or microemulsion). The hydrophobicity of the lipid mostly affected the interfacial tension, and thus the microstructure of the emulsion. Emulsions were then processed by spray congealing and the obtained b-MPs were characterized in terms of thermal and chemical properties (by DSC and FT-IR), external and internal morphology (by SEM, CLSM and Raman mapping). Solid free-flowing spherical particles (main size range 200–355 µm) with different architectures were successfully produced: microemulsions led to the formation of particles with a homogeneous internal structure, while coarse emulsions generated “multicores-shell” particles consisting of variable size hydrophilic cores evenly distributed within the crystalline lipid phase. Depending on their composition and structure, b-MPs could achieve various release profiles, representing a more versatile system than microparticles based on a single lipid phase. The formulation and technological strategy proposed, provides a feasible and cost-effective way of fabricating b-MPs with tunable internal structure and release behavior. Full article

The local controlled release of siRNA is an attractive and rational strategy to enhance and extend the effectiveness of gene therapy. Since naked and unmodified siRNA has a limited cell uptake and knockdown efficiency, the complexation of siRNA with non-viral carriers is often necessary for the delivery of bioactive RNA. We evaluated the performance of three different non-viral siRNA carriers, including DOTAP lipoplexes (DL), chitosan polyplexes (CP), and solid lipid complexes (SLC). The physicochemical properties of the siRNA-nanocarriers were characterized by dynamic light scattering and gel electrophoresis. After in vitro characterization, the carrier with the most appropriate properties was found to be the DL suspension, which was subsequently loaded into a gellan gum hydrogel matrix and examined for its drug load, stability, and homogeneity. The hydrogels microstructure was investigated by rheology to assess the impact of the rheological properties on the release of the siRNA nanocarriers. A controlled release of complexed siRNA over 60 days in vitro was observed. By comparing the results from fluorescence imaging with data received from HPLC measurements, fluorescence imaging was found to be an appropriate tool to measure the release of siRNA complexes. Finally, the bioactivity of the siRNA released from hydrogel was tested and compared to free DL for its ability to knockdown the GFP expression in a DLD1 colon cancer cell model. The results indicate controlled release properties and activity of the released siRNA. In conclusion, the developed formulation is a promising system to provide local controlled release of siRNA over several weeks. Full article

The daily oral administration of acetylcholinesterase (AChE) inhibitors for Alzheimer’s disease features low patient compliance and can lead to low efficacy or high toxicity owing to irregular intake. Herein, we developed a subcutaneously injectable hyaluronic acid hydrogel (MLC/HSA hydrogel) hybridized with microstructured lipid carriers (MLCs) and human serum albumin (HSA) for the sustained release of donepezil (DNP) with reduced initial burst release. The lipid carrier was designed to have a microsized mean diameter (32.6 ± 12.8 µm) to be well-localized in the hydrogel. The hybridization of MLCs and HSA enhanced the structural integrity of the HA hydrogel, as demonstrated by the measurements of storage modulus (G′), loss modulus (G″), and viscosity. In the pharmacokinetic study, subcutaneous administration of MLC/HSA hydrogel in rats prolonged the release of DNP for up to seven days and reduced the initial plasma concentration, where the C_max value was 0.3-fold lower than that of the control hydrogel without a significant change in the AUC_last value. Histological analyses of the hydrogels supported their biocompatibility for subcutaneous injection. These results suggest that a new hybrid MLC/HSA hydrogel could be promising as a subcutaneously injectable controlled drug delivery system for the treatment of Alzheimer’s disease. Full article

The aim of this work was the development of microstructured lipid carriers (MLC) based on chitosan (CH) and containing N-acetylcysteine (NAC), a mucolytic and antioxidant agent, to inhibit the formation of Pseudomonas aeruginosa biofilm. MLC were prepared using the high shear homogenization technique. The MLC were characterized for morphology, particle size, Z potential, encapsulation efficiency and drug release. The antioxidant properties of NAC-loaded microstructured carriers were evaluated through an in vitro spectrophotometer assay. Finally, the activity of NAC-CH-MLC on biofilm production by Pseudomonas aeruginosa was also evaluated. Results obtained from this study highlighted that the use of chitosan into the inner aqueous phase permitted to obtain microstructured particles with a narrow size range and with good encapsulation efficiency. NAC-loaded MLC showed higher antioxidant activity than the free molecule, demonstrating how encapsulation increases the antioxidant effect of the molecule. Furthermore, the reduction of biofilm growth resulted extremely high with MLC being 64.74% ± 6.2% and 83.74% ± 9.95%, respectively, at 0.5 mg/mL and 2 mg/mL. In conclusion, this work represents a favorable technological strategy against diseases in which bacterial biofilm is relevant, such as cystic fibrosis. Full article