Search Results (13)

Microalgae are a subject of interest not only for fundamental research but for various biotechnological applications as well. In this study, the ability of newly isolated strains, i.e., Picochlorum costavermella VAS2.5, Picochlorum oklahomense SAG4.4, Microchloropsis gaditana VON5.3, and Nephroselmis pyriformis PAT2.7, to grow when cultured in an open raceway pond under laboratory conditions and produce various metabolites of high-added value was evaluated. N. pyriformis PAT2.7 and P. costavermella VAS2.5 were the greatest in biomass production (exceeding 0.4 g/L), while P. costavermella VAS2.5 and M. gaditana VON5.3 were the greatest in lipid production (reaching approximately 18%, wt/wt). The lipid fraction of glycolipids and sphingolipids was predominant (43.6–55.4%, wt/wt), followed by neutral lipids (27.1–50.1%, wt/wt) and phospholipids (6.9–17.4%, wt/wt). Picochlora and M. gaditana VON5.3 lipids were rich in ^{Δ5,8,11,14,17}C20:5 and/or ^Δ9,12,15C18:3, while N. pyriformis PAT2.7 synthesized ^Δ9C16:1 in large quantities (30–40%, wt/wt). All strains showed remarkable yields in polysaccharide and protein production, demonstrated a well-balanced amino acid profile, and synthesized pigments in amounts comparable to other studies. The biochemical profiles of these strains showcased their suitability for use primarily in the aquaculture sector. Full article

The microalgal strains Picochlorum costavermella VAS2.5, Picochlorum oklahomense SAG4.4, Picochlorum oklahomense PAT3.2B, Microchloropsis gaditana VON5.3, and Nephroselmis pyriformis PAT2.7 were cultured in a Stirred Tank Reactor at 25 °C or 20 °C in modified artificial seawater and their biotechnological potential was assessed. VAS2.5, VON5.3, and PAT2.7 were high in biomass production at both temperatures (i.e., 438.8–671.3 mg/L and 418.4–546.7 mg/L at 25 °C and 20 °C, respectively), though P. oklahomense strains grew only at 25 °C. The highest lipid percentage was recorded for the cultures of VAS2.5 (19.3 ± 0.7%) and VON5.3 (16.4 ± 1.5%) at 25 °C, notably rich in ^{Δ5,8,11,14,17}C20:5, while PAT2.7 proved a major producer of ^Δ9C16:1. The predominant lipid fraction was glycolipids and sphingolipids (41.3–57.4%) for VAS2.5, PAT2.7 at 25 °C and VON5.3 at 20 °C and neutral lipids (55.6–63.5%) in the other cultures, indicating the different effect of temperature on lipid synthesis of the various microalgae. Additionally, almost all strains stood out for their high protein content, exceeding 50% in the culture of PAT3.2B, but polysaccharide and pigment content were not high. The biochemical profiles of the isolates showcased their suitability for use primarily as feed additives in the aquaculture sector. Full article

The marine oleaginous microalga Microchloropsis gaditana (formerly Nannochloropsis gaditana) exhibits a high capacity to thrive in a broad range of environmental conditions, being predominantly utilized as feed in aquaculture. This article reports the characterization of the culturable yeast population present during the scale-up process of M. gaditana cultivation at Necton S.A. facilities, from 5 L flasks until tubular photobioreactors. The 146 yeast isolates obtained, molecularly identified based on D1/D2 and ITS nucleotide sequences, belong to the species Rhodotorula diobovata, R. mucilaginosa, R. taiwanensis, R. sphaerocarpa, Vishniacozyma carnescens, Moesziomyces aphidis, and Meyerozyma guilliermondii. The yeast abundance was found to increase throughout upscaling stages. The yeast populations isolated from microalgal cultures and water samples share phylogenetically close isolates, indicating a possible common source. The impressive high percentage of red yeasts isolated (90%) is consistent with the recognized role of carotenoid pigments in yeast photoprotection. Sixty yeast isolates were tested for lipid (Nile Red staining) and biosurfactant (oil drop dispersion and emulsification index) production. Results revealed that these capacities are common features. Microbial lipids and biosurfactants have promising biotechnological applications. Moreover, biosurfactants can fulfill various physiological roles and provide advantages in natural environments contributing to the promising use of yeasts as probiotics in microalgae production. Full article

Sustainably farmed Atlantic salmon could drive global food system solutions by contributing essential nutrients to the human diet while delivering high-quality protein. One of the biggest obstacles to sustainable salmon aquaculture in Chile is the prevalence of piscirickettsiosis disease caused by the Gram-negative bacteria Piscirickettsia salmonis and the excessive amount of antibiotics used to eradicate this disease. Farmed salmon products can be consumed without prior processing and therefore present a substantial risk for the transfer of resistant pathogens to humans. Antibiotics also carry the risk of antibiotic residues and damage to the environment. An alternative to antibiotics is the use of natural antimicrobials without the negative influence on the consumer’s microbiome. Here, we evaluate the potential antimicrobial activity against P. salmonis of the marine microalgae Microchloropsis gaditana. A non-genetically modified M. gaditana was grown with nitrogen deprivation to improve the synthesis of the eicosapentaenoic fatty acid (EPA). A spray-dried M. gaditana concentrate (Mg) was elaborated and given to Atlantic salmon for a period of 49 days, and serum and fillet samples were collected. Our results showed a significant increase in the nutritional quality improving the levels of EPA+ Docosapentaenoic acid (DPA) (23%) and Vitamin D₃ (106%) of the fillets treated with Mg. Fish fed serum were challenged with P. salmonis, and serum antibacterial activity was measured. Sera from fish fed Mg-enriched diets showed a significant increase in antibacterial activity (85.68%) against P. salmonis. Our results indicate that Mg can be used as a viable alternative to address the critical problem of microbial resistance and to assure consumers that farm-raised Atlantic salmon is safe. Full article

The interdisciplinary nature of science, technology, engineering, and mathematics (STEM) offers the opportunity to implement educational approaches to biotechnology and process engineering issues. The focus should be on the promotion of scientific literacy in contexts relevant to research, industry, and society. This article specifically shows the development of suitable low-level experiments to provide a milestone for the implementation of biotechnological and process engineering issues in STEM education. The experiments show the successful transfer of inquiry-based bioprocess engineering experiments with a Do-It-Yourself (DIY) bioreactor and low-cost sensors. It was possible to achieve comparable trends of process-relevant state variables like mixing time and volumetric mass transfer coefficient (k_La) for the DIY bioreactor in comparison to established commercial systems. Furthermore, microalga Microchloropsis gaditana could be successfully cultivated under different cultivation conditions in the DIY system, and the respective growth curves could be observed. The DIY system is well suited for experimental application in schools and provides a scientifically substantiated basis for data interpretation. The scientific outreach approach and cooperation in a multiprofessional team for the transfer of process engineering questions to education can be evaluated as enriching. Experiments involving educational concepts offer a variety of connecting elements in the curriculum and opportunities to foster scientific literacy. Full article

The use of microalgae as a food ingredient has been gaining attention in recent years due to its nutritional benefits. The main goals of this study were to (i) assess the nutritional potential of Chlorella vulgaris, Tetraselmis chuii, Microchloropsis gaditana, and Phaeodactylum tricornutum; (ii) evaluate their bioactive properties (antioxidant activity, total phenolic content, and α-amylase inhibitory activity) and (iii) assess the main volatile compounds composition. The protein content was considerably high (32–44 mg/100 g dw) for all the microalgae strains. The DPPH scavenging potential range was 14–25 mg Trolox/100 g dw (highest for T. chuii) and the ferric reducing power ability range was 13–67 µmol Trolox/dw (higher for T. chuii). The total phenolic content range was 2–7 mg of gallic acid equivalents/g dw, for M. gaditana and T. chuii, respectively, which was mainly due to the presence of catechin (1–9 µg/g dw), epicatechin (3–29 µg/g dw), and vanillic acid (1–14 µg/g dw). The ɑ-amylase inhibitory potential range was 26–42%. C. vulgaris was richer in chlorophyll a (18 mg/g dw), whilst T. chuii was particularly rich in chlorophyll b (29 mg/g dw). P. tricornutum showed the highest carotenoid content (4 mg/g dw). Aldehydes and alkanes were the major compounds identified in M. gaditana, whereas alcohols and N-based compounds existed in higher amounts in P. tricornutum. T. chuii and C. vulgaris were enriched in ketones and alkenes. This study’s novelty lies in its comprehensive and integrative analysis of the nutritional, bioactive, and volatile properties of four distinct microalgae strains. By providing detailed comparisons and highlighting potential applications in functional foods, it offers a unique contribution to the field of microalgae research and its practical application in the food industry. This multifaceted approach sets it apart from existing studies, offering new insights and opportunities for leveraging microalgae as valuable food ingredients. Full article

Marine microalgae offer a sustainable alternative source for the human diet’s essential omega-3-fatty acids, including docosahexaenoic acid (DHA, C22:6) and eicosapentaenoic acid (EPA, C20:5). However, none of them can produce DHA and EPA in a nutritionally balanced ratio of 1:1. As shown recently, the phototrophic co-cultivation of the golden-brown microalgae Tisochrysis lutea (DHA producer) with the green microalgae Microchloropsis salina (EPA producer) can provide microalgae biomass with a balanced DHA-to-EPA ratio with increased productivity compared to monocultures. This study evaluates whether other golden-brown (Isochrysis galbana) and green microalgae (Nannochloropsis oceanica, Microchloropsis gaditana) can enable the phototrophic batch production of omega-3 fatty acids in a nutritionally balanced ratio in co-culture. All co-cultivations applying a physically dynamic climate simulation of a repeated sunny summer day in Australia in LED-illuminated flat-plate gas lift photobioreactors resulted in increased biomass concentrations compared to their respective monocultures, achieving balanced DHA-to-EPA ratios of almost 1:1. Using urea instead of nitrate as a nitrogen source increased the EPA content by up to 80% in all co-cultures. Light spectra measurements on the light-adverted side of the photobioreactor showed that increased biomass concentrations in co-cultures could have been related to enhanced light use due to the utilization of different wavelengths of the two microalgae strains, especially with the use of green light (500–580 nm) primarily by golden-brown microalgae (I. galbana) and orange light (600–620 nm) predominantly used by green microalgae (N. oceanica). Phototrophic co-cultivation processes thus promise higher areal biomass yields if microalgae are combined with complimentary light-harvesting features. Full article

Non-concentrated algae storage can bridge the period between algae harvesting and processing while avoiding the stress conditions associated with the concentration step required for concentrate storage. This study aimed to examine organic matter losses during the non-concentrated storage of Microchloropsis gaditana at pilot-scale. Algae cultures (400–500 L) were stored for up to 12 days either at an 8 °C target temperature or at 19 °C as the average temperature. The centrifugation yield of stored algal cultures decreased from day 5 or day 8 onwards for all storage conditions. After 12 days, the centrifugation yields were between 57% and 93% of the initial yields. Large differences in centrifugation yields were noted between the algae batches. The batch-to-batch difference outweighed the effect of storage temperature, and the highest yield loss was observed for the 8 °C cooled algae batch. The analysis of stored algae before and after centrifugation suggested that the decreasing yields were not related to respiration losses, but rather, the decreasing efficiency with which organic matter is collected during the centrifugation step. Full article

Oxygenic photosynthetic organisms (OPOs) are primary producers on Earth and generate surface and atmospheric biosignatures, making them ideal targets to search for life from remote on Earth-like exoplanets orbiting stars different from the Sun, such as M-dwarfs. These stars emit very low light in the visible and most light in the far-red, an issue for OPOs, which mostly utilize visible light to photosynthesize and grow. After successfully testing procaryotic OPOs (cyanobacteria) under a simulated M-dwarf star spectrum (M7, 365–850 nm) generated through a custom-made lamp, we tested several eukaryotic OPOs: microalgae (Dixoniella giordanoi, Microchloropsis gaditana, Chromera velia, Chlorella vulgaris), a non-vascular plant (Physcomitrium patens), and a vascular plant (Arabidopsis thaliana). We assessed their growth and photosynthetic efficiency under three light conditions: M7, solar (SOL) simulated spectra, and far-red light (FR). Microalgae grew similarly in SOL and M7, while the moss P. patens showed slower growth in M7 with respect to SOL. A. thaliana grew similarly in SOL and M7, showing traits typical of shade-avoidance syndrome. Overall, the synergistic effect of visible and far-red light, also known as the Emerson enhancing effect, could explain the growth in M7 for all organisms. These results lead to reconsidering the possibility and capability of the growth of OPOs and are promising for finding biosignatures on exoplanets orbiting the habitable zone of distant stars. Full article

Five microalgae strains, namely Isochrysis galbana, Microchloropsis gaditana, Scenedesmus obliquus, Nannochloropsis oculata and Tetraselmis suecica, were selected as potential candidates for polyunsaturated fatty acids’ production, evaluating biomass productivity and their capacity to accumulate high lipid contents under different trophic modes. Microalgae strains were cultivated in the presence of 1% glucose using mixotrophic and heterotrophic conditions, while autotrophic cultures served as control experiments. The results demonstrate that S. obliquus performed the highest biomass productivity that reached 0.13 and 0.14 g L⁻¹ d⁻¹ under mixotrophic and heterotrophic conditions, respectively. I. galbana and S. obliquus utilized elevated contents of glucose in mixotrophy, removing 55.9% and 95.6% of the initial concentration of the carbohydrate, respectively, while glucose consumption by the aforementioned strains also remained high under heterotrophic cultivation. The production of lipids was maximal for I. galbana in mixotrophy and S. obliquus in heterotrophy, performing lipid productivities of 24.85 and 22.77 mg L⁻¹ d⁻¹, respectively. The most abundant saturated acid detected for all microalgae strains evaluated was palmitic acid (C16:0), while oleic and linolenic acids (C18:1n9c/C18:3n3) comprised the most abundant unsaturated fatty acids. I. galbana performed the highest linoleic acid (C18:2n6c) content under heterotrophic nutrition, which reached 87.9 mg g⁻¹ of ash-free dry weight. Among the microalgae strains compared, the biomass and lipid production monitored for I. galbana and S. obliquus confirm that both strains could serve as efficient bioproducers for application in algal biorefineries. Full article

Cell wall disrupted and dried Microchloropsis gaditana (Mg), Tetraselmis chui (Tc) and Chlorella vulgaris (Cv) microalgae biomasses, with or without ethanol pre-treatment, were added to wheat bread at a wheat flour substitution level of 12%, to enrich bread protein by 30%. Baking performance, protein quality and basic sensory properties were assessed. Compared to wheat, Mg, Tc and Cv contain higher amounts of essential amino acids and their incorporation markedly improved protein quality in the bread (DIAAS 57–66 vs. 46%). The incorporation of microalgae reduced dough strength and bread volume and increased crumb firmness. This was most pronounced for Cv and Tc but could be improved by ethanol treatment. Mg gave adequate dough strength, bread volume and crumb structure without ethanol treatment. To obtain bread of acceptable smell, appearance, and colour, ethanol treatment was necessary also for Mg as it markedly reduced the unpleasant smell and intense colour of all algae breads. Ethanol treatment reduced the relative content of lysine, but no other essential amino acids. However, it also had a negative impact on in vitro protein digestibility. Our results show that Mg had the largest potential for protein fortification of bread, but further work is needed to optimize pre-processing and assess consumer acceptance. Full article

Open microalgal ponds used in industrial biomass production are susceptible to a number of biotic and abiotic environmental stressors (e.g., grazers, pathogens, pH, temperature, etc.) resulting in pond crashes with high economic costs. Identification of signature chemicals to aid in rapid, non-invasive, and accurate identification of the stressors would facilitate targeted and effective treatment to save the algal crop from a catastrophic crash. Specifically, we were interested in identifying volatile organic compounds (VOCs) that can be used to as an early diagnostic for algal crop damage. Cultures of Microchloropsis gaditana were subjected to two forms of algal crop damage: (1) active grazing by the marine rotifer, Brachionus plicatilis, or (2) repeated freeze–thaw cycles. VOCs emitted above the headspace of these algal cultures were collected using fieldable solid phase microextraction (SPME) fibers. An untargeted analysis and identification of VOCs was conducted using gas chromatography-mass spectrometry (GC-MS). Diagnostic VOCs unique to each algal crop damage mechanism were identified. Active rotifer grazing of M. gaditana was characterized by the appearance of carotenoid degradation products, including β-cyclocitral and various alkenes. Freeze–thaw algae produced a different set of VOCs, including palmitoleic acid. Both rotifer grazing and freeze–thawed algae produced β-ionone as a VOC, possibly suggesting a common stress-induced cellular mechanism. Importantly, these identified VOCs were all absent from healthy algal cultures of M. gaditana. Early detection of biotic or abiotic environmental stressors will facilitate early diagnosis and application of targeted treatments to prevent algal pond crashes. Thus, our work further supports the use of VOCs for monitoring the health of algal ponds to ultimately enhance algal crop yields for production of biofuel. Full article

The increasing cultivation of microalgae in photobioreactors warrants efficient and non-invasive methods to quantify biomass density in real time. Nephelometric turbidity assessment, a method that measures light scatter by particles in suspension, was introduced already several decades ago but was only recently validated as a high-throughput tool to monitor microalgae biomass. The light scatter depends on the density of the suspended particles as well as on their physical properties, but so far there are hardly any accounts on how nephelometric assessment relates to classic methods such as dry weight and spectrophotometric measurement across a broad biomass density range for different microalgae species. Here, we monitored biomass density online and in real time during the semi-continuous cultivation of three commercial microalgae species Chloromonas typhlos, Microchloropsis gaditana and Porphyridium purpureum in pilot-scale photobioreactors, and relate nephelometric turbidity to dry weight and optical density. The results confirm a relatively strong (R² = 0.87–0.93) and nonlinear relationship between turbidity and biomass density that differs among the three species. Overall, we demonstrate how nephelometry can be used to monitor microalgal biomass in photobioreactors, and provide the necessary means to estimate the biomass density of the studied species from turbidity data to facilitate automated biomass monitoring. Full article