Search Results (13)

In this study different strategies have been adopted to promote the shelf-life prolongation of fresh chicken nuggets. Two different by-products, grape pomace powder (GPP) and pomegranate peel extract (PE), alone and in combination with lactic acid, were suggested as meat preservatives. The antioxidant properties measured by different assays confirmed the presence of bioactive compounds in both by-products. To test their effects on meat samples, a control nugget without any compounds and a nugget with sole lactic acid were also used for comparison. During a refrigerated storage of about 2 weeks, microbiological stability and changes in sensory properties were monitored to assess the product shelf life. Results demonstrated that GPP promoted a good preservation of meat, and its combination with other compounds further increased the effectiveness. The control without any active agent remained acceptable for less than 1 day, the control with lactic acid for less than 2 days (p > 0.05). The other active samples lasted longer depending on the combinations of active compounds. When the sole GPP was used, about 3 days of shelf life were recorded (p < 0.05). While the combination of GPP with PE promoted only a slight increase of shelf life by 1 day (2.9 vs. 3.9 days), the combination of GPP with LA prolonged the shelf life to more than 6 days (2.9 vs. 6.58 days) (p < 0.05). The best results were found when both LA and PE were combined with GPP because the nuggets lasted about 10 days (p < 0.05). To better highlight the single and combined effects of the tested active agents, a proper index $\left(∆\%\right),$ comprising the normalized percent difference between the shelf life of the sample with the most antimicrobials and that of the sample with the least antimicrobials, was calculated, thus comparing the various samples and demonstrating the potential synergic effects among them. Full article

Vegetarian and vegan diets are increasingly being adopted in Spain, a trend mainly driven by ethical concerns for animal welfare and the environment. This has resulted in a growing market for plant-based substitutes of meat products. However, available data on the nutritional value of such meat analogues in Mediterranean countries are still limited. In this study, the labelling information of four categories of plant-based meat analogues (n = 100) and the corresponding conventional meat products (n = 48) available on the Spanish market was surveyed and compared. The nutrient content of plant-based meat analogues varied significantly, due to the wide range of ingredients used in their formulation. Some of these products were found to have a low protein content, which in others was enhanced by the addition of cereals and legumes. Compared to the meat products, the plant-based analogues contained lower levels of total fat as well as saturated fat, which ranged from 30% of total fat in burgers to less than 15% in meatballs, sausages, and nuggets; in contrast, they contained higher amounts of fiber and complex carbohydrates. Overall, the meat analogues cannot be considered as nutritionally equivalent substitutes to conventional meat products due to a high variability of protein content and other nutrients. Full article

Reducing population-level sodium intake can reduce hypertension, an important preventative strategy to lower the risk of cardiovascular diseases, the leading cause of death in the United States. Considering that most dietary sodium is derived from prepackaged foods, this study quantitatively estimates the proportion contribution and mean sodium intake from key food category contributors to total sodium intake in the US population. Data from the 2017–2018 National Health and Nutrition Examination Survey, which collected interviewer-administered 24 h dietary recalls from Americans (n = 7081), were analyzed. Based on the average proportion contributed, the top 15 sources of sodium were identified overall and by age/sex, poverty–income and race/ethnicity. More than 50% of US population-level dietary sodium intake was contributed by: pizza (5.3%); breads, rolls and buns (4.7%); cold cuts and cured meats (4.6%); soups (4.4%); burritos and tacos (4.3%); savoury snacks (4.1%); poultry (4.0%); cheese (3.1%); pasta mixed dishes (2.9%); burgers (2.5%); meat mixed dishes (2.5%); cookies, brownies and cakes (2.4%); bacon, frankfurters and sausages (2.4%); vegetables (2.2%); and chicken nuggets (1.5%), with the results remaining consistent among population subgroups. The results identified the top sources of sodium in the American population overall, as well as in key population subgroups, which can inform policies and programs aimed at reducing sodium intake. Full article

The poultry meat industry has gone through many changes. It moved from growing dual-purpose birds (meat and egg production) taking ~110 days to reach 1.2 kg 100 years ago, to developing specialized meat breeds that grow to 2.5 kg within ~40 days. It also moved from selling ~80% whole birds to mostly selling cut up and further processed products in the Western world. This necessitated building large, centralized processing plants, capable of processing 15,000 birds per hr on a single line (60 years ago only 2500), that require higher bird uniformity (size, color, texture). Furthermore, consumer demand for convenient products resulted in introducing many cut-up fresh poultry (some companies have 500 SKU) and further processed products (chicken nuggets did not exist 50 years ago). Those developments were possible due to advancements in genetics, nutrition, medicine, and engineering at the farm and processing plant levels. Challenges keep on coming and today a rise in myopathies (e.g., so called woody breast, white striping, spaghetti meat), requires solutions from breeders, farmers, and processing plants, as more automation also requires more uniformity. This review focuses on the changes and challenges to the processing industry segment required to keep supplying high quality poultry to the individual consumer. Full article

A commonly observed chicken meat issue is its lipid oxidation that leads to deterioration of its organoleptic and nutritional properties and its further-processed products. Basil (Ocimum basilicum L.) is one of the traditional culinary herbs exhibiting food preservation properties. The current study investigated the essential oil composition, antioxidant activity and in vitro cytotoxic capacity of the essential oil of basil indigenous to Pakistan. GC–MS analysis of the essential oil revealed the presence of 59 compounds that constituted 98.6% of the essential oil. O. basilicum essential oil (OB-EO) exhibited excellent antioxidant activity, i.e., IC₅₀ 5.92 ± 0.15 µg/mL as assayed by the DPPH assay, 23.4 ± 0.02 µmoL Fe/g by FRAP, and 14.6 ± 0.59% inhibition by H₂O_2. The brine shrimp lethality assay identified an average mortality of ~18% with OB-EO at 10–1000 µg/mL, while that of the same concentration range of the standard drug (etoposide) was 72%. OB-EO was found to be non-toxic to HeLa and PC-3 cell lines. TBARS contents were significantly decreased with increase of OB-EO in chicken nuggets. The lowest TBARS contents were recorded in nuggets supplemented with 0.3% OB-EO, whereas the highest overall acceptability score was marked to the treatments carrying 0.2% OB-EO. The results suggest OB-EO as a promising carrier of bioactive compounds with a broad range of food preservation properties, and which has a sensory acceptability threshold level for chicken nuggets falling between 0.2-0.3% supplementation. Future research must investigate the antibacterial impact of OB-EO on meat products preserved with natural rather than synthetic preservatives. Full article

The prevalence of plant-based alternatives (PBAs) to meat in the marketplace has been increasing in recent years due to consumer demand. One of these plant-based products has aimed to mimic chicken products, specifically chicken nuggets. However, few sensory studies have been conducted on these products. The objective of this study is to evaluate the sensory properties, acceptability, and consumer perception of these PBAs. Participants (n = 105) were asked to evaluate five PBAs and a control (chicken nugget) using hedonic scales and a check-all-that-apply question. They also answered an open-ended comment question about PBAs. The participants separated the control from the PBAs in terms of their hedonic scores and sensory properties. They separated the PBAs based on their textural properties and if they had off-flavors. Participants disliked PBAs that were associated with an aftertaste, as well as beany, fibrous, and chewy attributes. The participants believed the PBAs currently on the market did not successfully mimic a chicken nugget and that improvement is needed, but they did believe PBAs are environmentally friendly. Full article

The current study evaluated the effect of pomegranate peel-based edible coating on chicken nuggets in order to develop a functional and safe product, high in nutritional value. For this purpose, 2,2-diphenyl-1-picrylhydrazyl (DPPH) and total phenolic content (TPC) assays were performed to check the potential antioxidant activity of chicken nuggets; microbial control, including total aerobic count and coliforms population, was performed for quality and safety purposes; and thiobarbituric acid reactive substances (TBARS) and peroxide value (POV) were performed to determine the oxidative stability of chicken nuggets. Different treatments were applied at different storage periods (0th, 7th, 14th and 21st day). The higher value of total aerobic count (5.09 ± 0.05 log CFU/g) and coliforms (3.91 ± 0.06 log CFU/g) were obtained for the uncoated samples, while the lower population was enumerated in the combination of sodium alginate (SA) and pomegranate peel powder (PPP). However, DPPH (64.65 ± 2.15%) and TPC (135.66 ± 3.07 GAE/100 g) values were higher in the coated chicken nuggets (SA (1.5%) and PPP (1.5%)) and lowest in the control samples. The higher value of TBARS (1.62 ± 0.03 MDA/kg) and POV (0.92 ± 0.03 meq peroxide/kg) were observed in the uncoated chicken nuggets. In the Hunter color system, L*, a*, and b* peak values were determined in the coated chicken nuggets with SA (1.5%) + PPP (1.5%) at the 21st day of storage. The uncoated chicken nuggets had different sensory characteristics (appearance, color, taste, texture, and overall acceptability) compared to the coated samples. Conclusively, coating based on the combination of SA (1.5%) and PPP (1.5%) increased the quality, safety, and nutritional properties of chicken nuggets. Full article

Meat analogue is a food product mainly made of plant proteins. It is considered to be a sustainable food and has gained a lot of interest in recent years. Hybrid meat is a next generation meat analogue prepared by the co-processing of both plant and animal protein ingredients at different ratios and is considered to be nutritionally superior to the currently available plant-only meat analogues. Three-dimensional (3D) printing technology is becoming increasingly popular in food processing. Three-dimensional food printing involves the modification of food structures, which leads to the creation of soft food. Currently, there is no available research on 3D printing of meat analogues. This study was carried out to create plant and animal protein-based formulations for 3D printing of hybrid meat analogues with soft textures. Pea protein isolate (PPI) and chicken mince were selected as the main plant protein and meat sources, respectively, for 3D printing tests. Then, rheology and forward extrusion tests were carried out on these selected samples to obtain a basic understanding of their potential printability. Afterwards, extrusion-based 3D printing was conducted to print a 3D chicken nugget shape. The addition of 20% chicken mince paste to PPI based paste achieved better printability and fibre structure. Full article

Meat analogue research and development focuses on the production of sustainable products that recreate conventional meat in its physical sensations (texture, appearance, taste, etc.) and nutritional aspects. Minced products, like burger patties and nuggets, muscle-type products, like chicken or steak-like cuts, and emulsion products, like Frankfurter and Mortadella type sausages, are the major categories of meat analogues. In this review, we discuss key ingredients for the production of these novel products, with special focus on protein sources, and underline the importance of ingredient functionality. Our observation is that structuring processes are optimized based on ingredients that were not originally designed for meat analogues applications. Therefore, mixing and blending different plant materials to obtain superior functionality is for now the common practice. We observed though that an alternative approach towards the use of ingredients such as flours, is gaining more interest. The emphasis, in this case, is on functionality towards use in meat analogues, rather than classical functionality such as purity and solubility. Another trend is the exploration of novel protein sources such as seaweed, algae and proteins produced via fermentation (cellular agriculture). Full article

Optimally designed functional foods are considered the most important part of a balanced and healthy diet. Goat meat nuggets, an otherwise healthy option, are packed with undesirable saturated and unsaturated fats. The present work suggests an optimal functional formulation to reduce the surplus fat content of goat meat nuggets by adding two optimally calculated functional ingredients, namely, fenugreek leaves (FL) and psyllium husk (PH). Response surface optimization was performed to determine the optimal content of the functional ingredients (FL and PH), resulting in minimum fat content without affecting the overall acceptability (OA) and other properties representing the taste and texture (e.g., ash content, pH, crude fiber content, and moisture content) of the nuggets. Functional additives at optimum levels successfully reduced the fat content of the weight-conserved nuggets by almost 39% compared with the control nuggets. Minimal and acceptable effects were observed regarding OA and other properties representative of the taste and texture of the nuggets. An optimally designed, fat-attenuated goat meat nugget formulation is therefore prescribed, which complies with the nutritional standards of a balanced diet. Full article

The impact of different amounts (2%, 4% and 6%) of enoki (Flammulina velutipes) mushroom stem waste (MSW) powder on the physicochemical quality, color and textural, oxidative stability, sensory attributes and shelf-life of goat meat nuggets was evaluated. These mushroom by-products (MSW powder) contained a good source of protein (13.5%), ash (8.2%), total phenolics content (6.3 mg GAE/g), and dietary fiber (32.3%) and also exhibited the potential to be strong antioxidants, due to their good metal chelating ability (41.3%), reducing power (60.1%), and free radical scavenging activity (84.2%). Mushroom stem waste improved (p < 0.05) the emulsion stability, dietary fiber, ash and phenolics content of nuggets compared to control. Although no significant differences (p > 0.05) in expressible water and textural properties were observed among the formulations, but MSW powder improved the water holding capacity and slightly decreased the hardness. Further, the inclusion of MSW significantly (p < 0.05) improved the oxidative stability and shelf-life of treated nuggets by reducing lipid oxidation during the nine-day storage period. Again, the inclusion of MSW did not negatively affect the color and sensory attributes of treated meat nuggets. Overall, our results suggest that enoki mushroom stem waste (4%) can be used as a value-added functional ingredient to produce nutritionally improved and healthier meat products. Full article

The present work investigated the efficacy of Moringa flower (MF) extract to develop a functional chicken product. Three groups of cooked chicken nuggets—control (C), T1 (with 1% MF) and T2 (2% MF)—were elaborated and their physicochemical, nutritional, storage stability and sensory attributes were assessed during refrigerated storage at 4 °C up to 20 days. In addition, MF extracts were characterised in terms of chemical composition, total phenolic content and its components using high-performance liquid chromatography with a diode-array detector (HPLC-DAD), dietary fibre and antioxidant capacity. MF contained high protein (17.87 ± 0.28 dry matter), dietary fibre (36.14 ± 0.77 dry matter) and total phenolics (18.34 ± 1.16 to 19.49 ± 1.35 mg gallic acid equivalent (GAE)/g dry matter) content. The treated nuggets (T1 and T2) had significantly enhanced cooking yield, emulsion stability, ash, protein, total phenolics and dietary fibre compared to control. Incorporation of MF extract at 2% not only significantly reduced the redness/increased the lightness, but also decreased the hardness, gumminess and chewiness of the product compared to control. Moreover, the addition of MF extract significantly improved the oxidative stability and odour scores by reducing lipid oxidation during storage time. Sensory attributes of nuggets were not affected by the addition of MF extract and the products remained stable and acceptable even on 15th day of storage. These results showed that MF extract could be considered as an effective natural functional ingredient for quality improvement and reducing lipid oxidation in cooked chicken nuggets. Full article

In the present study, the efficacy of litchi fruit pericarp (LFP) extract (0.5%, 1.0% and 1.5% concentration) in retarding lipid oxidation of cooked sheep meat nuggets was evaluated and compared to butylated hydroxyl toluene (BHT, 100 ppm). The total phenolic content and antioxidant potential of LFP extracts were determined. The thiobarbituric acid reactive substance (TBARS) values were evaluated to assess the potential of LFP extracts as natural antioxidants for oxidative stability of cooked nuggets during 12 days of refrigerated storage. Results show that total phenolics content in 10 mg LFP powder was comparable to 100 ppm BHT, but 15 mg LFP powder had significantly higher (p < 0.05) total phenolics content and reducing power than the synthetic antioxidant. LFP extract did not affect pH, cooking yield and the sensory attributes of cooked nuggets. Non-treated control and nuggets with 1.0% LFP extract had significantly lower total phenolics than nuggets with 1.5% extract and BHT. TBARS values were significantly lower (p < 0.05) throughout the storage period in cooked meat nuggets containing either LFP extract or BHT than in non-treated control. Results indicate that LFP extracts are promising sources of natural antioxidants and can potentially be used as functional food additives in meat products at 1.5% without affecting products’ acceptability. Full article