Search Results (17)

Objectives: Antiviral vaccines are usually created by inactivating viruses using physical or chemical methods. Inactivation of poliovirus with β-propiolactone (BPL) has advantages, including the absence of a requirement for long-term incubation with the inactivating agent, which minimizes the risk of negative effects of the potentially dangerous substance on the virus and reduces the duration of the inactivation process. Methods: BPL was applied at 0.2% (w/v) concentration under two conditions: 4 °C for 24 h and 37 °C for 3 h. Inactivation completeness was confirmed on Vero cell culture, while immunogenicity was assessed in guinea pigs via neutralizing antibody test. Conclusions: Two variants of virus inactivation made it possible to obtain inactivated samples that retained their immunogenic properties. BPL-inactivated samples retained sufficient D-antigen levels and elicited neutralizing antibodies comparable to or exceeding those from formaldehyde-inactivated controls. The inactivation method at 37 °C provided faster inactivation, while at 4 °C it provided a smooth decrease in virus titer. These results confirm that β-propiolactone is a viable alternative to formaldehyde for the production of inactivated polio vaccine (IPV), providing rapid inactivation of the virus compared to inactivation with formaldehyde while maintaining immunogenicity, as confirmed by guinea pig control. Full article

Subgenomic RNAs (sgRNAs) are potential markers of active SARS-CoV-2 replication, serving as templates for the synthesis of structural and accessory proteins in infectious viral particles. This study aimed to use RT-qPCR to quantify sgRNA and negative RNA intermediates, assessing viral replication in virus samples inactivated by β-propiolactone (βPL). Inactivated viruses subjected to five blind serial passages (BSs) were amplified by RT-qPCR using primers to target the envelope (ENV) and nucleoproteins (N1 and N2) of genomic genes, subgenomic envelope RNA (sgENV), and intermediate envelope RNA (ENV-). All positive controls showed consistent viral titers across passages (10 log10 copies/mL in N1/N2 and 11 log10 copies/mL in ENV) during BSs. Inactivated viral samples for ENV and ENV- targets ranged from 11.34 log10 copies/mL in BS1 to 11.20 log10 copies/mL in BS5. The sgENV was no longer detected in the inactivated SARS-CoV-2 samples after the second passage, suggesting successful inactivation. Replication kinetics showed consistent profiles for N1/N2, ENV, and ENV- targets in the first three post-infection hours (pih) and maintained approximately 5 log10 copies/mL at 1 pih, 2 pih, and 3 pih. A sharp exponential increase in the viral titer was observed from 24 pih onwards, peaking at 11.64 log10 copies/mL at 48 pih. Transmission electron microscopy confirmed viral particles only in cells infected with active SARS-CoV-2. These results support the use of sgRNA as a reliable marker for SARS-CoV-2 replication, especially in distinguishing between active replication and non-viable particles and in the development of diagnostic and therapeutic strategies. Full article

Inactivated vaccines are promising tools for tackling the COVID-19 pandemic. We applied several protocols for SARS-CoV-2 inactivation (by β-propiolactone, formaldehyde, and UV radiation) and examined the morphology of viral spikes, protein composition of the preparations, and their immunoreactivity in ELISA using two panels of sera collected from convalescents and people vaccinated by Sputnik V. Transmission electron microscopy (TEM) allowed us to distinguish wider flail-like spikes (supposedly the S-protein’s pre-fusion conformation) from narrower needle-like ones (the post-fusion state). While the flails were present in all preparations studied, the needles were highly abundant in the β-propiolactone-inactivated samples only. Structural proteins S, N, and M of SARS-CoV-2 were detected via mass spectrometry. Formaldehyde and UV-inactivated samples demonstrated the highest affinity/immunoreactivity against the convalescent sera, while β-propiolactone (1:2000, 36 h) and UV-inactivated ones were more active against the sera of people vaccinated with Sputnik V. A higher concentration of β-propiolactone (1:1000, 2 h) led to a loss of antigenic affinity for both serum panels. Thus, although we did not analyze native SARS-CoV-2 for biosafety reasons, our comparative approach helped to exclude some destructive inactivation conditions and select suitable variants for future animal research. We believe that TEM is a valuable tool for inactivated COVID-19 vaccine quality control during the downstream manufacturing process. Full article

Introduction: Severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) has spread around the world, caused millions of deaths and a severe illness which poses a serious threat to human health. Objective: To develop an antigen detection kit that can identify Omicron novel coronavirus mutants. Methods: BALB/c mice were immunized with the nucleocapsid protein of SARS-CoV-2 Omicron mutant treated with β-propiolactone. After fusion of myeloma cells with immune cells, Elisa was used to screen the cell lines capable of producing monoclonal antibodies. The detection kit was prepared by colloidal gold immunochromatography. Finally, the sensitivity, specificity and anti-interference of the kit were evaluated by simulating positive samples. Results: The sensitivity of the SARS-CoV-2 antigen detection kit can reach 62.5 TCID₅₀/mL, and it has good inclusiveness for different SARS-CoV-2 strains. The kit had no cross-reaction with common respiratory pathogens, and its sensitivity was still not affected under the action of different concentrations of interferences, indicating that it had good specificity and stability. Conclusion: In this study, monoclonal antibodies with high specificity to the N protein of the Omicron mutant strain were obtained by monoclonal antibody screening technology. Colloidal gold immunochromatography technology was used to prepare an antigen detection kit with high sensitivity to detect and identify the mutant Omicron strain. Full article

This study investigates inclusion behavior of amylose towards, poly(β-propiolactone) (PPL), that is a hydrophobic polyester, via the vine-twining process in glucan phosphorylase (GP, isolated from thermophilic bacteria, Aquifex aeolicus VF5)-catalyzed enzymatic polymerization. As a result of poor dispersibility of PPL in sodium acetate buffer, the enzymatically produced amylose by GP catalysis incompletely included PPL in the buffer media under the general vine-twining polymerization conditions. Alternatively, we employed an ethyl acetate–sodium acetate buffer emulsion system with dispersing PPL as the media for vine-twining polymerization. Accordingly, the GP (from thermophilic bacteria)-catalyzed enzymatic polymerization of an α-d-glucose 1-phosphate monomer from a maltoheptaose primer was performed at 50 °C for 48 h in the prepared emulsion to efficiently form the inclusion complex. The powder X-ray diffraction profile of the precipitated product suggested that the amylose-PPL inclusion complex was mostly produced in the above system. The ¹H NMR spectrum of the product also supported the inclusion complex structure, where a calculation based on an integrated ratio of signals indicated an almost perfect inclusion of PPL in the amylosic cavity. The prevention of crystallization of PPL in the product was suggested by IR analysis, because it was surrounded by the amylosic chains due to the inclusion complex structure. Full article

Severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) has caused huge social and economic distress. Given its rapid spread and the lack of specific treatment options, SARS-CoV-2 needs to be inactivated according to strict biosafety measures during laboratory diagnostics and vaccine development. The inactivation method for SARS-CoV-2 affects research related to the natural virus and its immune activity as an antigen in vaccines. In this study, we used size exclusion chromatography, western blotting, ELISA, an electron microscope, dynamic light scattering, circular dichroism, and surface plasmon resonance to evaluate the effects of four different chemical inactivation methods on the physical and biochemical characterization of SARS-CoV-2. Formaldehyde and β-propiolactone (BPL) treatment can completely inactivate the virus and have no significant effects on the morphology of the virus. None of the four tested inactivation methods affected the secondary structure of the virus, including the α-helix, antiparallel β-sheet, parallel β-sheet, β-turn, and random coil. However, formaldehyde and long-term BPL treatment (48 h) resulted in decreased viral S protein content and increased viral particle aggregation, respectively. The BPL treatment for 24 h can completely inactivate SARS-CoV-2 with the maximum retention of the morphology, physical properties, and the biochemical properties of the potential antigens of the virus. In summary, we have established a characterization system for the comprehensive evaluation of virus inactivation technology, which has important guiding significance for the development of vaccines against SARS-CoV-2 variants and research on natural SARS-CoV-2. Full article

Polyethylenimine (PEI) has been widely used in gene delivery. However, its high cytotoxicity and undesired non-specific protein adsorption hinder the overall delivery efficacy and the practical applications of PEI-based gene delivery systems. In this study, we prepared hydrophobically modified PEIs (H-PEIs) via the reaction of octanal with 40% of primary amines in PEI_25k and PEI_10k, respectively. Two common zwitterionic molecules, 1,3-propanesultone and β-propiolactone, were then used for the modification of the resulting H-PEIs to construct polycationic gene carriers with zwitterionic properties (H-zPEIs). The siRNA delivery efficiency and cytotoxicity of these materials were evaluated in Hela-Luc and A549-Luc cell lines. Compared with their respective parental H-PEIs, different degrees of zwitterionic modification showed different effects in reducing cytotoxicity and delivery efficiency. All zwitterion-modified PEIs showed excellent siRNA binding capacity, reduced nonspecific protein adsorption, and enhanced stability upon nuclease degradation. It is concluded that zwitterionic molecular modification is an effective method to construct efficient vectors by preventing undesired interactions between polycationic carriers and biomacromolecules. It may offer insights into the modification of other cationic carriers of nucleic acid drugs. Full article

Seneca Valley virus (SVV), also known as Senecavirus A (SVA), is a non-enveloped and single-strand positive-sense RNA virus, which belongs to the genus of Senecavirus within the family Picornaviridae. Porcine idiopathic vesicular disease (PIVD) caused by SVV has frequently been prevalent in America and Southeast Asia (especially in China) since the end of 2014, and has caused continuing issues. In this study, an SVV strain isolated in China, named SVV LNSY01-2017 (MH064435), was used as the stock virus for the preparation of an SVV-inactivated vaccine. The SVV culture was directly inactivated using binary ethyleneimine (BEI) and β-propiolactone (BPL). BPL showed a better effect as an SVV inactivator, according to the results of pH variation, inactivation kinetics, and the detection of VP1 content during inactivation. Then, SVV inactivated by BPL was subsequently emulsified using different adjuvants, including MONTANIDE^TM ISA 201 VG (ISA 201) and MONTANIDE^TM IMG 1313 VG N (IMS 1313). The immunoreactivity and protection efficacy of the inactivated vaccines were then evaluated in finishing pigs. SVV-BPL-1313 showed a better humoral response post-immunization and further challenge tests post-immunization showed that both the SVV-BPL-201 and SVV-BPL-1313 combinations could resist challenge from a virulent SVV strain. The SVV LNSY01-2017-inactivated vaccine candidate developed here represents a promising alternative to prevent and control SVV infection in swine. Full article

The development of a safe and effective vaccine to protect against COVID-19 is a global priority due to the current high SARS-CoV-2 infection rate. Currently, there are over 160 SARS-CoV-2 vaccine candidates at the clinical or pre-clinical stages of development. Of these, there are only three whole-virus vaccine candidates produced using β-propiolactone or formalin inactivation. Here, we prepared a whole-virus SARS-CoV-2 vaccine (SARS-CoV-2 PsIV) using a novel psoralen inactivation method and evaluated its immunogenicity in mice using two different adjuvants, alum and Advax-2. We compared the immunogenicity of SARS-CoV-2 PsIV against SARS-CoV-2 DNA vaccines expressing either full-length or truncated spike proteins. We also compared the psoralen-inactivated vaccine against a DNA prime, psoralen-inactivated vaccine boost regimen. After two doses, the psoralen-inactivated vaccine, when administered with alum or Advax-2 adjuvants, generated a dose-dependent neutralizing antibody responses in mice. Overall, the pattern of cytokine ELISPOT responses to antigen-stimulation observed in this study indicates that SARS-CoV-2 PsIV with the alum adjuvant promotes a Th2-type response, while SARS-CoV-2 PsIV with the Advax-2 adjuvant promotes a Th1-type response. Full article

Tilapia lake virus (TiLV) is a newly emerging pathogen responsible for high mortality and economic losses in the global tilapia industry. Currently, no antiviral therapy or vaccines are available for the control of this disease. The goal of the present study was to evaluate the immunological effects and protective efficacy of formaldehyde- and β-propiolactone-inactivated vaccines against TiLV in the presence and absence of the Montanide IMS 1312 VG adjuvant in tilapia. We found that β-propiolactone inactivation of viral particles generated a vaccine with a higher protection efficacy against virus challenge than did formaldehyde. The relative percent survivals of vaccinated fish at doses of 10⁸, 10⁷, and 10⁶ 50% tissue culture infectious dose (TCID₅₀)/mL were 42.9%, 28.5%, and 14.3% in the absence of the adjuvant and 85.7%, 64.3%, and 32.1% in its presence, respectively. The vaccine generated specific IgM and neutralizing antibodies against TiLV at 3 weeks following immunization that were significantly increased after a second booster immunization. The steady state mRNA levels of the genes tumor necrosis factor-α (TNF-α), interleukin-1β (IL-1β), interferon γ (IFN-γ), cluster of differentiation 4 (CD4), major histocompatibility complex (MHC)-Ia, and MHC-II were all increased and indicated successful immune stimulation against TiLV. The vaccine also significantly lowered the viral loads and resulted in significant increases in survival, indicating that the vaccine may also inhibit viral proliferation as well as stimulate a protective antibody response. The β-propiolactone-inactivated TiLV vaccine coupled with the adjuvant Montanide IMS 1312 VG and booster immunizations can provide a high level of protection from virus challenge in tilapia. Full article

[6]-Gingerol from ginger has received considerable attention as a potential cancer therapeutic agent because of its chemopreventive and chemotherapeutic effects, as well as its safety. In the current study, we examined [6]-gingerol as a natural scavenger of nine ultimate chemical carcinogens to which we are frequently exposed: glycidamide, styrene oxide, aflatoxin B1 exo-8,9-epoxide, β-propiolactone, ethylene oxide, propylene oxide, 2-cyanoethylene oxide, chloroethylene oxide, and vinyl carbamate epoxide. To evaluate [6]-gingerol efficacy, we expanded our research with the examination of glutathione—the strongest natural scavenger in human cells. The corresponding activation free energies were calculated using Hartree-Fock method with three flexible basis sets and two implicit solvation models. According to our results, [6]-gingerol proves to be an extremely effective scavenger of chemical carcinogens of the epoxy type. On the other hand, with the exception of aflatoxin B1 exo-8,9-epoxide, glutathione represents a relatively poor scavenger, whose efficacy could be augmented by [6]-gingerol. Moreover, our quantum mechanical study of the alkylation reactions of chemical carcinogens with [6]-gingerol and glutathione provide valuable insights in the reaction mechanisms and the geometries of the corresponding transition states. Therefore, we strongly believe that our research forms a solid basis for further computational, experimental and clinical studies of anticarcinogenic properties of [6]-gingerol as well as for the development of novel chemoprophylactic dietary supplements. Finally, the obtained results also point to the applicability of quantum chemical methods to studies of alkylation reactions related to chemical carcinogenesis. Full article

Zwitterionic polymers are suitable for replacing poly(ethylene glycol) (PEG) polymers because of their better antifouling properties, but zwitterionic polymers have poor mechanical properties, strong water absorption, and their homopolymers should not be used directly. To solve these problems, a reversible-addition fragmentation chain transfer (RAFT) polymerization process was used to prepare copolymers comprised of zwitterionic side chains that were attached to an ITO glass substrate using spin-casting. The presence of 4-vinylpyridine (4VP) and zwitterion chains on these polymer-coated ITO surfaces was confirmed using 1H NMR, FTIR, and GPC analyses, with successful surface functionalization confirmed using water contact angle, X-ray photoelectron spectroscopy (XPS), and atomic force microscopy (AFM) studies. Changes in water contact angles and C/O ratios (XPS) analysis demonstrated that the functionalization of these polymers with β-propiolactone resulted in hydrophilic mixed 4VP/zwitterionic polymers. Protein adsorption and cell attachment assays were used to optimize the ratio of the zwitterionic component to maximize the antifouling properties of the polymer brush surface. This work demonstrated that the antifouling surface coatings could be readily prepared using a “P4VP-modified” method, that is, the functionality of P4VP to modify the prepared zwitterionic polymer. We believe these materials are likely to be useful for the preparation of biomaterials for biosensing and diagnostic applications. Full article

In recent years, enterovirus D68 (EVD68) has been reported increasingly to be associated with severe respiratory tract infections and acute flaccid myelitis (AFM) in children all over the world. Yet, no effective vaccines or antiviral drugs are currently available for EVD68. Although several experimental animal models have been developed, immunogenicity and protective efficacy of inactivated EVD68 vaccines has not been fully evaluated. To promote the development of vaccines, we established an Institute of Cancer Research (ICR) suckling mouse model of EVD68 infection in this study. The results showed that ICR neonatal mice up to about nine days of age were susceptible to infection with EVD68 clinical strain US/MO/14-18947 by intraperitoneal injection. The infected mice exhibited progressive limb paralysis prior to death and the mortality of mice was age- and virus dose-dependent. Tissue viral load analysis showed that limb muscle and spinal cord were the major sites of viral replication. Moreover, histopathologic examination revealed the severe necrosis of the limb and juxtaspinal muscles, suggesting that US/MO/14-18947 has a strong tropism toward muscle tissues. Additionally, β-propiolactone-inactivated EVD68 vaccine showed high purity and quality and induced robust EVD68-specific neutralizing antibody responses in adult mice. Importantly, results from both antisera transfer and maternal immunization experiments clearly showed that inactivated EVD68 vaccine was able to protect against lethal viral infection in the mouse model. In short, these results demonstrate the successful establishment of the mouse model of EVD68 infection for evaluating candidate vaccines against EVD68 and also provide important information for the development of inactivated virus-based EVD68 vaccines. Full article

Although the copolymerizations of l-lactide (LA) with seven- or six-membered ring lactones have been extensively studied, the copolymerizations of LA with four-membered ring lactones have scarcely been reported. In this work, we studied the copolymerization of LA with β-propiolactone (PL) and the properties of the obtained copolymers. The copolymerization of LA with PL was carried out using trifluoromethanesulfonic acid as a catalyst and methanol as an initiator to produce poly(LA-co-PL) with M_n of ~50,000 and PL-content of 6–67 mol %. The T_g values of the copolymers were rapidly lowered with increasing PL-contents. The T_m and ΔH_m of the copolymers gradually decreased with increasing PL-contents, indicating their decreased crystallinity. Biodegradation test of the copolymers in compost demonstrated their improved biodegradability in comparison with the homopolymer of LA. Full article

Inactivated vaccines are commonly produced by incubating pathogens with chemicals such as formaldehyde or β-propiolactone. This is a time-consuming process, the inactivation efficiency displays high variability and extensive downstream procedures are often required. Moreover, application of chemicals alters the antigenic components of the viruses or bacteria, resulting in reduced antibody specificity and therefore stimulation of a less effective immune response. An alternative method for inactivation of pathogens is ionizing radiation. It acts very fast and predominantly damages nucleic acids, conserving most of the antigenic structures. However, currently used irradiation technologies (mostly gamma-rays and high energy electrons) require large and complex shielding constructions to protect the environment from radioactivity or X-rays generated during the process. This excludes them from direct integration into biological production facilities. Here, low-energy electron irradiation (LEEI) is presented as an alternative inactivation method for pathogens in liquid solutions. LEEI can be used in normal laboratories, including good manufacturing practice (GMP)- or high biosafety level (BSL)-environments, as only minor shielding is necessary. We show that LEEI efficiently inactivates different viruses (influenza A (H3N8), porcine reproductive and respiratory syndrome virus (PRRSV), equine herpesvirus 1 (EHV-1)) and bacteria (Escherichia coli) and maintains their antigenicity. Moreover, LEEI-inactivated influenza A viruses elicit protective immune responses in animals, as analyzed by virus neutralization assays and viral load determination upon challenge. These results have implications for novel ways of developing and manufacturing inactivated vaccines with improved efficacy. Full article