Next Article in Journal
Characterization of Maize Hybrids (Zea mays L.) for Detecting Salt Tolerance Based on Morpho-Physiological Characteristics, Ion Accumulation and Genetic Variability at Early Vegetative Stage
Next Article in Special Issue
Pharmacological Investigations in Traditional Utilization of Alhagi maurorum Medik. in Saharan Algeria: In Vitro Study of Anti-Inflammatory and Antihyperglycemic Activities of Water-Soluble Polysaccharides Extracted from the Seeds
Previous Article in Journal
Integrated Nutrient Management Enhances Productivity and Nitrogen Use Efficiency of Crops in Acidic and Charland Soils
Previous Article in Special Issue
Thonningia sanguinea Extract: Antioxidant and Cytotoxic Activities Supported by Chemical Composition and Molecular Docking Simulations
 
 
Search for Articles:
Title / Keyword
Author / Affiliation / Email
Journal
Article Type
 
 
Advanced Search
 
Section
Special Issue
Volume
Issue
Number
Page
 
Journals
Plants
Volume 10
Issue 11
10.3390/plants10112548
plants-logo
Submit to this Journal Review for this Journal Propose a Special Issue
► Article Menu

Article Menu

share Share announcement Help format_quote Cite question_answer Discuss in SciProfiles thumb_up
...
Endorse textsms
...
Comment
first_page
settings
Order Article Reprints
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Glucosinolates and Isothiocyantes in Processed Rapeseed Determined by HPLC-DAD-qTOF

by
Ana Miklavčič Višnjevec
1,*,
Angelica Tamayo Tenorio
2,
Anne Christine Steenkjær Hastrup
2,
Natanya Majbritt Louie Hansen
2,
Kelly Peeters
1,3 and
Matthew Schwarzkopf
1,3
1
Faculty of Mathematics, Natural Sciences and Information Technologies, University of Primorska, Glagoljaška 8, 6000 Koper, Slovenia
2
Center for Bioresources, AgroTech, Danish Technological Institute Gregersensvej, 2630 Taastrup, Denmark
3
InnoRenew CoE, Livade 6, 6310 Izola, Slovenia
*
Author to whom correspondence should be addressed.
Plants 2021, 10(11), 2548; https://doi.org/10.3390/plants10112548
Submission received: 25 October 2021 / Revised: 16 November 2021 / Accepted: 18 November 2021 / Published: 22 November 2021
(This article belongs to the Special Issue Chemical Profiling and Biological Activity of Plant Natural Compounds)
Browse Figure
Review Reports Versions Notes

Abstract

:
Glucosinolates are well known as natural antimicrobials and anticarcinogenic agents. However, these compounds can lose their properties and transform into antinutrients, depending on processing conditions. In addition, the bitterness of some glucosinolate in rapeseed meal can affect the likability of the final product. Therefore, it is important to identify and determine each glucosinolate and its derived form, not just the total glucosinolate content, in order to evaluate the potential of the final rapeseed protein product. This study provides a comprehensive report of the types and quantities of glucosinolates and their derived forms (isothiocyanates) associated with different rapeseed processing conditions. Glucosinolates and isothiocyanates were determined by HPLC-DAD-qTOF. In our study, the enzymatic degradation of glucosinolates by myrosinase was the main factor affecting either glucosinolate or isothiocyanate content. Other factors such as pH seemed to influence the concentration and the presence of glucosinolates. In addition, process parameters, such as extraction time and separation technology, seemed to affect the amount and type of isothiocyanates in the final protein extracts. Overall, both determined intact glucosinolates and their derived forms of isothiocyanates can give different types of biological effects. More studies should be performed to evaluate the impact of glucosinolates and isothiocyanates on human health.

1. Introduction

Glucosinolates are natural sulphur-containing compounds that are produced by the secondary metabolism of plants from the order Capparales, which among other families includes the Brassicacea. Several of these Brassica species are important for feed ingredients, notably rapeseed protein, whereas other species are commonly used in human nutrition, such as cauliflower, cabbages, broccoli and Brussels sprouts. Glucosinolates and their derived products determine the typical flavour and (bitter) taste of these vegetables and feedstock [1]. According to Wallsgrove et al. [2], more than 100 different glucosinolates have been identified. The general structure of glucosinolates is characterized by a SCN group, a sulphate, and a β-D-glucopyranosyl. According to the chemical structure of the side chain (-R), among others, alkenyl-, phenyl- and indolylmethyl glucosinolates can be distinguished [3]. These compounds are involved in plant defense mechanisms against depredation, and some of these compounds appear to be protective against chemical carcinogens [2]. Glucosinolates are naturally converted into isothiocyanates by enzymes in the plants. Isothiocyanates contain the chemical group –N=C=S, formed by substituting the oxygen in the isocyanate group with a sulphur. Glucosinolates can also be converted to the aglycone by enzymatic hydrolysis with myrosinase [4]. Depending on the substrate, pH and availability of ferrous ions, glucosinolates can decompose into isothiocyanates, thiocyanates or nitriles. At physiological pH levels, isothiocyanates are the major product. Glucosinolates and the enzyme myrosinase are segregated in intact plant tissues [5]. When the compartmentalization of glucosinolates and myrosinase is lost by the plant, physical damage that can occur after freezing and thawing, chopping and the myrosinase-catalyzed metabolism of glucosinolates occurs [6,7,8,9]. Isothiocyanates formed by hydrolysis of glucosinolates may act as chemoprotective agents against carcinogens and have a positive effect on cardiovascular and neurological diseases [10]. Moreover, isothiocyanates may act as inhibitors of mitosis in tumour cells [11,12,13].
Glucosinolates and their derived forms are detected and identified by high-performance liquid chromatography with tandem mass spectrometry (HPLC-MS/MS). All intact glucosinolates contain at least two sulphur atoms and, therefore, yield a characteristic molecular ion isotope pattern. This aids in confirmation of the presence of sulphur atoms and, therefore, of glucosinolates [14]. The glucosinolates characteristic fragment ions [SO4]−, and [SO4H]− (m/z 96, 97) are formed with high abundance in the high and programmed cone voltage ESI method. The simultaneous occurrence of both m/z 96 and 97 ions is a highly diagnostic fingerprint for glucosinolates, even when these compounds are present in complex mixtures [14]. Although the abundance ratios were not constant for all glucosinolates examined by Mellon et al. [14], they all fell within the range 1:2 to 1:4 ([m/z 96]/[m/z 97]) [14]. Therefore, the identities of the glucosinolate peaks can be then established by extracting the full-scan spectra at the retention times indicated by the increase in abundance of the m/z 96 and 97. The mass spectra of HPLC peaks that lacked the 96, 97 pair of ions can also be checked to determine whether these are glucosinolates. Mellon et al. [14] showed that in all cases HPLC peaks lacking the 96, 97 pair of ions were proven not to be glucosinolates. Regarding isothiocyanates, high-sensitivity detection and quantification by LC-MS/MS can be achieved by derivatization with ammonia to the corresponding thiourea derivative and positive ion electrospray ionization LC-MS/MS. Thiourea derivatives can be detected by LC-MS/MS with multiple reaction monitoring (MRM) transitions that generally involve a loss of ammonia [4].
The detection and identification of glucosinolates and their derivatives are of importance during the processing of raw materials such as rapeseed cake, due to the concentration steps towards protein products, where glucosinolates or isothiocyanates can accumulate and may reach undesirable levels. Rapeseed meal and pressed cake are mostly by-products from the oil extraction processing of rapeseed. These meals/cakes contain between 30–40% high-quality protein and have been the subject of considerable attention. Rapeseed meal produced from hot pressing, followed by hexane extraction, results in substantial denaturation of proteins due to excessive heat exposure, rendering a proportion insoluble in water and, therefore, more difficult to isolate using aqueous extraction processing. Moreover, rapeseed meals and cakes contain glucosinolates and degradation products that impart bitter tastes, and phytate (inositol hexa-phosphate), which are all anti-nutritional compounds and limit the utilization of rapeseed meals/cakes. Nevertheless, processing technologies are being developed to ensure a low glucosinolate content of products that can be an alternative source of protein for various food and feed applications.
With the current pressure on protein prices, increasing demand for functional ingredients, and remaining controversy over wider use of soy, there is an excellent case for fractionating rapeseed residues after oil extraction to produce protein concentrates and isolates while removing glucosinolates and phytates [15,16]. This study examines glucosinolate and isothiocyanate content of rapeseed protein products obtained from different processing conditions, using hot and cold pressed rapeseed cake as raw material. To our knowledge, this is the first study to provide a comprehensive report of the types and quantities of glucosinolates and their derived forms (isothiocyanates) associated with different rapeseed processing conditions towards final protein products.

2. Results and Discussion

2.1. Glucosinolates in Raw Material

Table 1 shows the results for glucosinolates determined in cold-pressed rapeseed cake (CPR), listing the name of the identified compound, its molecular formula, molar mass, m/z, retention time (RT), characteristic fragments and the 96/97 ratios. In addition, the concentrations of the most important glucosinolates such as progoitrin, gluconapin, sinigrin, sinalbin and gluconasturtiin were determined using appropriate analytical standards.
As shown in Table 1, progoitrin, sinigrin, sinalbin, gluconapoliferin, glucoalyssin, gluconapin, 2-methylpropyl glucosinolate or butyl glucosinolate, glucobrassicanapin, 4-methyltiobutyl glucosinolate, gluconasturtiin, three isomers of methylpentyl glucosinolate and neoglucobrassicin were tentatively identified in CPR. Progoitrin, sinigrin, sinalbin, gluconapin and gluconasturtiin were confirmed by analytical standards. No distinction was possible between isomers such as 2-methylpropyl glucosinolate or butyl glucosinolate having the same molecular formulas. The identified glucosinolates in CPR are in accordance with the literature [17,18,19,20]. The most commonly identified glucosinolates in rapeseed in the literature [17,18,19,20] are gluconapin, glucobrassicanapin, progoitrin, gluconapoliferin, glucobrassicin and gluconasturtiin. These compounds were also identified in our study, except for glucobrassicin. Glucobrassicin could be present in our samples at concentrations below the measuring concentration range, as has been previously reported by Heaney [17]. From different studies [17,18,19,20], including the current one, it is evident that the glucosinolate profile differs between the same types of rapeseed cake, probably due to genetic and environmental factors.
Within different groups divided according to different anabolic pathways of glucosinolates, the most abundant were aliphatic glucosinolates such as progoitrin, sinigrin, gluconapoliferin, glucoalyssin, gluconapin, etc. Aliphatic glucosinolates are compounds mainly derived from methionine, but also valine alanine, leucine and isoleucine. This group of glucosinolates showed the strongest inverse association with cancer risk. At a more precise level, glucosinolates and their degradation products have been shown to reduce the risk of several cancers, such as colon [21,22], bladder [23], lung [24], breast [25] and prostate [26]. Dietary glucosinolates have been reported to block the formation of endogenous or exogenous carcinogens to prevent the onset of carcinogenesis [27]. They are indirect antioxidants because they do not neutralize free radicals directly, but do so by modulating xenobiotic metabolic enzymes (phase I and phase II enzymes) [28]. However, it must be pointed out that health risks and health benefits associated with the consumption of glucosinolates in the glucosinolate-derived ingredient are defined by structure, including the stereochemistry of food compounds, and their dietary concentrations. Both intact glucosinolates and their metabolites can give different types of biological effects [29] including hypothyroidism and enlargement of the thyroid gland in mammalian species [1]. Glucosinolates have been shown to be mutagenic and weakly genotoxic [30,31,32,33].
The main quantified compounds present in cold-pressed rapeseed cake (CPR) were gluconapin that amounts to 2413 ± 27 mg/kg and progoitrin that amounts to 1014 ± 56 mg/kg. The same compounds were some of the most abundant in rapeseed according to Millan et al. [20]. They reported 120–2233 mg/kg in the case of progoitrin and 93–966 mg/kg in the case of gluconapin. The exception was 4-hydroxyglucobrassicin that was not identified in our study and was present in the range of 139.4–2133 mg/kg according to Millan et al. [20]. However, Sosulski et al. [19], did not identify this compound. They determined neoglucobrassicanapin (4350 mg/kg), progoitrin (1550 mg/kg) and gluconapin (970 mg/kg) as the most abundant in rapeseed meal. In contrast to Sosulski et al. [19], neoglucobrasicanapin in CPR was tentatively identified near the limit of detection in MS in our study, wheres Millan et al. [20] did not identify this compound. The total quantified glucosinolates were near the lowest determined values in most of the cases, but in the ranges according to the literature [1,19,20,34]. Differences in the amount of glucosinolates in Brassica plants are attributed to genetic and environmental factors, including plant age, temperature, water stress and soil type [35,36].
The determined concentrations in the raw material (CPR) showed that the selected sample exhibited results similar to plant varieties with low glucosinolate content. The measured values were more than 50% lower compared with the limit value of 20 mmol/kg seed dry matter for plants with low glucosinolate content [1].

2.2. Glucosinolates during the Processing of the Pressed Rapeseed Cake

Rapeseed cake coming from hot or cold pressing processes was submitted to different processing phases to obtain a final protein powder. All included samples went through (1) extraction, (2) separation, (3) concentration and (4) spray drying. However, different process conditions (e.g., solid to water ratio, separation technologies) were tested in the various trials during pilot-scale process developmental. Figure 1 shows the whole process of extraction, separation and concentration of CPR, and glucosinolate and isothiocyanate content in samples taken at different stages. Glucosinolates were only found in Sample S1 (aqueous extract before soaking), containing a smaller amount of progoitrin and gluconapin, and neoglucobrassicin identified at the limit of detection (0.3 mg/kg dry weight). These results could be due to enzymatic degradation of glucosinolates by myrosinase, resulting in a number of secondary reaction products such as isothiocyanates, nitriles, thiocyanates, epithionitriles, or oxazolidin-2-thiones [37]. Isothiocyanates were found in samples S3–S8 and they were expected to be formed due to the processing conditions used. The decomposition of glucosinolates is influenced by different factors such as pH. At pH 5–7, isothiocyanates are usually formed, whereas at slightly lower pH values, nitriles are usually formed [38]. Native conditions (pH~5) were used during the processing of CPR in this study. Besides degradation of glucosinolates by myrosinase, hydrolysis is also expected during the aqueous extraction process [1].

2.3. Glucosinolates in Different Extracted Rapeseed Protein Sample

In the protein products from trials carried out with CPR (Trials CPR-1; CPR-2; CPR-3; and CPR-4), the glucosinolate content was below the limit of detection (LOD). However, different glucosinolates were found in protein products from trials carried out with hot-pressed rapeseed cake (HPR) (Trials HPR-1; HPR-2; and HPR-3 (Tables S2–S4). The highest peaks in all three samples corresponded to progoitrin and gluconapin (Table 2). In the case of HPR, the processing temperatures exceed 70 °C during oil pressing. Therefore, the enzyme myrosinase is likely to have less than 22% of its activity [39]. In this raw material, most of the glucosinolates are still present.
Ten different glucosinolates were identified in the extracted rapeseed protein extract from Trial HPR-3, namely progoitrin, gluconapoliferin, glucoalyssin, gluconapin, 2-methylpropyl glucosinolate/butyl glucosinolate, glucobrassicanapin, gluconasturtiin, neoglucobrassicin, 3-methylpentyl glucosinolates and 4-methyltiobutyl glucosinolate. All the glucosinolates that were found in Trial HPR-3 were identified in Trial HPR-2, with the exception of 4-methyltiobutyl glucosinolate (Table 2). In Trial HPR-1, only five glucosinolates were identified. Progoitrin, gluconapoliferin, gluconapin and neoglucobrassicin were identified with lower concentrations compared with other samples, whereas butyl glucosinolate/2-methylpropyl glucosinolate was identified with approximately the same concentrations as in Trial HPR-2. The differences in glucosinolate content between the samples might be due to the different processing parameters tested such as enzymatic extraction at different pH conditions, reaction time and filtration technologies (see the Materials and Methods). For instance, pH was adjusted to pH 8 in Trial HPR-1, pH 6.7 in Trial HPR-2 and pH 5, followed by pH 7 in Trial HPR-3, suggesting that basic medium might affect the stability and conversion of glucosinolates. Jing et al. [40] observed a diminished glucosinolate content after adjusting the pH from 8 to 9, whereas the content of glucosinolates changed only slightly between the pH range from 3 to 8.
Table 2 shows the quantification results of the identified glucosinolates. Highest concentrations of determined glucosinolates were found for progoitrin and gluconapin, and the highest levels were found in Trial HPR-3 with a total amount of 4972 ± 348 mg/kg (13.0 ± 0.9 mmol/kg). About 20% lower concentrations were found in Trial HPR-2 (3917 ± 274 mg/kg; 10.1 ± 0.7 mmol/kg) and about 40% lower concentrations were found in Trial HPR-1 (3129 ± 219 mg/kg; 8.1 ± 0.8 mmol/kg) compared with Trial HPR-3. The high levels observed in Trial HPR-3 exceed the EFSA recommended restriction of total glucosinolates level, which amounts to 1–1.5 mmol/kg for monogastric animals [1]. However, data on the toxicity of individual glucosinolates for food-producing animal species are very limited. In addition, the extracted rapeseed protein is meant for human consumption, and reliable data on limited recommended intakes for human consumption are rather difficult to obtain. In literature, only rough estimates are found for the recommended limit values, which amount to 0.25 µmol/kg body weight/day for the Netherlands, 0.5 to 0.6 µmol/kg body weight/day for Canada and the United States of America and 1.6 µmol/kg body weight/kg body weight for the United Kingdom [41]. According to the lowest (Netherlands) and the highest (United Kingdom) recommended value, for a person of 70 kg, the consumption of rapeseed final protein product should not exceed 1.3–8.6 g/day from Trial HPR-3, 1.7–11.1 g/day from Trial HPR-2 and 2.2–14 g/day from Trial HPR-1. More studies should be carried out to evaluate the impact of the identified glucosinolates on human health at expected lower concentrations.

2.4. Isothiocyanates in Raw Material and during Processing of Rapeseed Pressed Cake

Isothiocyanates were determined in the raw material and during the processing of the cold-pressed rapeseed cake (Figure 1). In the CPR raw material, only 4-hydroxybutyl isothiocyanate was found at the limit of detection. The lack of isothiocyanates in the raw material can be explained by a temporary low activity of the enzyme myrosinase in CPR, whereas the CPR it is in its dry form. Since this raw material has only been treated at mild temperatures (<70 °C), once water is added for extraction, the enzyme myrosinase is expected to be active and able to catalyze the cleavage of glucosinolates to aglycons that further decompose into isothiocyanates, thiocyanates, nitriles or epithionitriles. Figure 1 shows the concentrations of the main compound goitrin, which is present at the different stages of pilot-scale rapeseed protein extraction for Trial CPR-1. Goitrin loss during processing of rapeseed was assessed to the amount of 669 ± 50 mg/kg wet weight. This compound is derived from 2-hydroxy-3-butenyl isothiocyanate formed by hydrolysis of progoitrin, which was one of the main compounds in the raw material. Goitrin was also the main compound found in samples from other Trials with CPR (Trials CPR-2, CPR-3 and CPR-4; see Table 3 and Table S2).
In addition to goitrin, 2-phenylethyl isothiocyanate was found at the limit of detection in the remaining solids after the aqueous extraction in Trial CPR-1 (Table S3). That process stream is discarded, thereby eliminating 2-phenylethyl isothiocyanate from the process. In addition, small intensities of alyssin (the conversional product of glucoallysin) that were below limit of quantification were still present in S4, the liquid fraction that continues the process, but this compound was not detected in the subsequent samples; 2-phenylethyl isothiocyanate, the conversional product of gluconasturtiin, was present in the final protein product from Trial CPR-3 (Table 3) at the limits of detection; 4-methylthiobutyil isothiocyanate, the conversional product of 4-methylthiobutyl glucosinolate was detected in the raw material and the final protein product in Trial CPR-2, although at the limit of the detection (Table 3); 3-butenyl isothiocyanate, the conversional product of gluconapin, was only found in the final protein product in Trial CPR-4, but below the limit of quantification. The differences in isothiocyanates detected in samples from different trials should be due to different processing conditions (See Materials and Methods), as was previously reported by Deng et al. [42]. Especially at the beginning of the processing, after the solid/liquid separation, different filtration technologies were applied that could affect the accumulation/elimination of the converted isothiocyanates. For instance, the highest content of goitrin was determined in the protein extract from Trial CPR-2. In this trial, goitrin had twice the concentration compared with Trial CPR-1 (Table 3). The concentration was approximately 13 times higher compared with Trial CPR-3 and approximately 4 times higher compared with Trial CPR-4. This might be due to the filtration procedure (i.e., 0.2 µ microfiltration followed by 5 kDa ultrafiltration) used in trial CPR-2, compared with trial CPR-1 (i.e., manual liquid/liquid separation followed by 5 kDa ultrafiltration) and trial CPR-3 (i.e., 0.2 µ microfiltration followed by 10 kDa ultrafiltration) suggesting that accumulation of goitrin can occur under specific filtration conditions. Moreover, trial CPR-4 used the same filtration condition but included a second aqueous extraction step, which might have affected the glucosinolate conversion. Another process parameter that differs among these trials is the duration: 5-day process for trial CPR-2 vs. 4-day process for trials CPR-1, CPR-3 and CPR-4. The additional extraction day seemed to have affected the glucosinolates and isothiocyanates. Finally, goitrin might be the most abundant of the isothiocyanates also due to its stability and could be used as a biomarker of glucosinolate conversion to isothiocyanates in rapeseed and its products.
Isothiocyanates were also analyzed in samples from trials using hot-pressed rapeseed cake (HPR); however, none were detected. In this raw material, the enzyme myrosinase is expected to be completely inactivated during oil pressing, due to heat inactivation. HPR processing involves temperatures above 70 °C, which is higher than the inactivation temperature of myrosinase [43]. Therefore, glucosinolates cannot be converted into isothiocyanates in HPR.
Isothiocyanates were determined in our study, not just because they can be conversional products of glucosinolates but also because they are potentially the most bioactive products of glucosinolate hydrolysis [44]. The most harmful degradation product detected in our study was oxazolidin-2-thione (goitrin) derived from progoitrin [35]. The parent compound (progoitrin) accumulates in rapeseed and causes goiter and other adverse effects on animal health, such as depressed growth, poor chicken egg production and liver damage [45]. Goitrin is an inhibitor of thyroid peroxidase and prevents the oxidation of iodide to iodine for subsequent iodination of tyrosine residues in T3 and T4 thyroxine biosynthesis. Thiocyanate anions act as a competitive iodide inhibitor, thereby preventing iodide uptake into the thyroid [46]. Langer et al. [47] reported that 25 mg (194 µmol) was the minimal amount of goitrin that decries the uptake of radioiodine. According to the results obtained in this study (Table 3), this amount is reached by consuming 0.26 kg CPR-2, 3.57 kg CPR-3 and 1.14 kg CRP-4. Moreover, high levels of progoitrin found in HPR-1, HPR-2 and HPR-3 can be also converted in goitrin. In this case the amount would be reached by consuming only grams of final protein products. The excesses consumption of these protein products should be avoided. However, there was no evidence of any effect of goitrin on humans due to its ingestion [45]. In addition, it has been shown that goitrin can cause a nitrosation reaction that can affect human health when nitrate levels in water are high [46]. The exact cause of this is not fully understood, but it may be related either to the presence of intact glucosinolates or to the production of nitriles in the digestive tract [18].
On the other hand, studies have shown that progoitrin, epiprogoitrin and their derivatives (goitrin and epigoitrin) are thought to exhibit a number of biological activities, including antiviral, anti-inflammatory, and anti-tumour effects [48,49]. Additional studies should be performed in order to fully evaluate isothiocyanates bioactive effects in humans and animals exposed at low doses.

3. Materials and Methods

3.1. Sample Description

All samples tested (e.g., HPR-2 Trials) for this study were obtained from the Biorefinery Pilot Plant of Danish Technological Institute (DTI), Taastrup, Denmark.
In CPR cake, the pressing occurs at slightly lower temperatures than HPR since no external heating is involved during pressing [50]. However, this does not mean that the process occurs at low temperatures (>10 °C) because friction inside the pressing equipment creates some heat, and temperatures as high 70 °C can be reached.
HPR cake, as described by the Pro-Enrich supplier Emmelev, is produced as follows: rapeseeds are dried to about 5.5% water content, followed by sieving, milling, pressing, transfer to a cascade mixer at minimum 81 °C and final separation and cooling of the rapeseed cake before storage and later shipment. During pressing, the machine is heated to improve oil release and the temperatures normally exceed 100 °C.
All the samples were stored at −18 °C prior to analysis.

Pilot-Scale Rapeseed Protein Extraction

All trials were performed under the same unit operations, notably: extraction process, separation and filtration, and spray drying. During the extraction, the rapeseed cakes at different solid-to-water ratios were subjected to various conditioning regimes (Figure 1, Table 4). A decanter centrifuge was employed for solid/liquid separation. Membrane filtration was used for liquid/liquid separation (i.e., 0.2 µm microfiltration) and concentration (i.e., 10 kDa ultrafiltration or 300 Da nanofiltration). No further filtration was carried out before analysis. The final protein extract was dried by spray drying, resulting in a fine powder. Liquid samples were taking from reactor or buffer tanks under continuous stirring. Solids samples were collected from (1) the decanter/centrifuge outlet after all the material was separated, aiming at a homogeneous sample, and (2) from the spray drier at the product outlet. Either the liquid or the dry form of the protein extract was used for glucosinolate content analysis. The liquid samples were freeze-dried (Alpha 1–4, Martin Christ Buchi) prior to analysis. The dry powder yield of the protein end products CPR-1 to CPR-4 and HPR–1 to HPR-3 is shown in Table 5. All trials were performed a single time as part of upscaling activities for industrial process development.

3.2. Determination of Glucosinolates

The extractions of glucosinolates in rapeseed meal and protein product samples were performed according to instructions by Tolra et al. [3], with some modifications. Certified reference material (CRM) ERM-BC190 rapeseed (S, total glucosinolate, medium level) was previously ground to a fine powder. The glucosinolates were extracted from 100 mg of the dry sample and CRM with 70% aqueous methanol (v/v) in a boiling water bath for 5 min. After cooling and centrifugation (4000 RPM, 5 min), the proteins of the supernatant were precipitated with 200 µL of a 0.1 M solution containing lead acetate and 200 µL of a 0.1 M solution containing barium acetate. After centrifugation (4000 RPM, 5 min), the supernatants were filtered through Whatman No. 4 paper. After that, samples were evaporated with a rotavap at 35 °C to remove methanol and water. Water was added to the obtained pellets and filtered through a 0.2 µm/PA (Nylon) filter before being analysed by HPLC-ESI-qTOF, as was described by Torla et al. [3]. CRM ERM-BC190 rapeseed was used to check the recovery of the extraction method, as was previously reported by Torla et al. [3], and the found value (21.4 ± 1.1 mmol/kg) was in good agreement with the certified values (23 mmol/kg ± 4 mmol/kg). The method rendered a 93 ± 7% recovery, and that was in agreement with previously reported data [3].
Glucosinolates were characterized using a high-pressure liquid chromatography system (HPLC), interfaced with a qTOF mass spectrometer (HPLC-ESI-QTOF/MS). The HPLC was equipped with a Poroshell 120 column (EC-C18; 2.7 µm; 3.0 × 150 mm). Elution was performed using mobile phase A (0.1% formic acid aqueous solution) and mobile phase B (0.1 formic Acid: acetonitrile, 50:50). The flow rate was 0.4 mL/min, and detection was at 229 nm. Two gradient systems were used were as follows: 2–10% B, 0–10 min; 10–50% B, 10–25 min; 50–90% B, 25–30 min; 20–30% B. The re-equilibration time was 5 min [51]. The separation compounds were first monitored using DAD (230 nm), and then MS scans were performed in the range m/z 40–1000, in the following conditions: capillary voltage, 2.5 kV; gas temperature 250 °C; drying gas 8 L/min; sheath gas temperature 375 °C; sheath gas flow 11 L/min. The MS acquisition was performed in negative ionisation mode as was reported by Mellon et al. [14]. In those conditions, the instruments were expected to provide experimental data with accuracy within ± 3 ppm. All data were processed using Qualitative Workflow B.08.00 and Qualitative Navigator B.080.00 software. The screening strategies were the same as reported elsewhere [4,14] (Table S1). In addition, more specific characteristic ions 259.012 (C6H11SO9−) and 96.960 (HSO4−) in MS2 [52] were used for identification confirmation of the glucosinolates. Gluconapin potassium salt (SI-PHL89765-10MG, Sigma Aldrich, Merck KGaA, Darmstadt, Germany), progoitrin potassium salt (SI-PHL89765-10MG, Sigma Aldrich, Merck KGaA, Darmstadt, Germany), sinalbin potassium salt (SI-PHL89793-10MG, Sigma Aldrich, Merck KGaA, Darmstadt, Germany), gluconastuirtiin potassium salt (SI-PHL89689-10MG, Sigma Aldrich, Merck KGaA, Darmstadt, Germany) and sinigrin hidrat (SL-00290-10MG, Sigma Aldrich, Merck KGaA, Darmstadt, Germany) were used for quantification of glucosinolates. The calibration plots indicated good correlations between peak areas and commercial standard concentrations (Figures S1–S5). Regression coefficients were higher than 0.990 (5 points per calibration graphs). LOD varied from 0.1 mg/kg to 0.37 mg/kg dried weight, whereas LOQ varied in the range from 1.0 mg/kg to 3.7 mg/kg dried sample. The standard deviation between duplicates was less than 7%.

3.3. Determination of Isothiocyanates

High-sensitivity detection and quantification of isothiocyanates by LC-MS/MS was achieved by derivatization with ammonia to the corresponding thiourea derivative and positive ion electrospray ionization LC-MS/MS. Thiourea derivatives were detected by LC-MS/MS with MRM transitions that generally involved a loss of ammonia [4]. For the derivatization procedure, 50–250 mg of powder sample (or 200 µL standard) was mixed with 2M ammonia in isopropanol (3 mL, 2 mL- std) and homogenized. The homogenate was left at room temperature for 24 h. Excess ammonia and isopropanol were evaporated using a rotavapor at 35 °C. To the obtained pellets, 1 mL (2 mL for std) of methanol was added and filtered through a 0.2 µm/PA (Nylon) filter before analysis by HPLC-ESI-qTOF [4].
Isothiocyanates were characterized using an HPLC-ESI-QTOF / MS. The HPLC was equipped with a Poroshell 120 column (EC-C18; 2.7 µm; 3.0 × 150 mm). The elution gradient of water/formic acid (99.05: 0.5, v/v) (A) and methanol (B) was performed as follows: with a linear gradient of 0 to 80% methanol from 0 to 20 min and isocratic 80% methanol from 20 to 35 min. The separation was performed at a flow rate of 0.5 mL/min, using 1 µL of injection volume. The separation compounds were first monitored using DAD (240 nm) and then MS scans were performed in the range m/z 40–1000, in the following conditions: capillary voltage, 2.5 kV; gas temperature 250 °C; drying gas 8 L/min; sheath gas temperature 375 °C; sheath gas flow 11 L/min. The MS acquisition was performed in positive ionisation mode as was reported by Song et al. [4]. In those conditions, the instruments were expected to provide experimental data with accuracy within ± 3 ppm. All data were processed using Qualitative Workflow B.08.00 and Qualitative Navigator B.080.00 software. The screening strategies were the same as reported elsewhere [4]. Goitrin (SI-PHL85696, Sigma Aldrich, Merck KGaA, Darmstadt, Germany) and 2-phenylethyl isothiocyanate (AL-253731-5G) were used for quantification. LOD varied from 0.07 mg/kg sample to 0.42 mg/kg sample, whereas LOQ varied from 0.7 mg/kg sample to 4.2 mg/kg dried sample. The standard deviation between duplicates was less than 7%.

4. Conclusions

In this study, glucosinolates and isothiocyanates were determined from different processing strategies for the extraction of protein from rapeseed cake. The enzymatic degradation of glucosinolates by myrosinase was the main factor in our study affecting glucosinolate and isothiocyanate content. In the case of hot-pressed rapeseed cake (HPR), temperatures higher than 70 °C were used during oil pressing, and, therefore, the enzyme myrosinase was deactivated, leaving intact glucosinolates in the samples during protein extraction. Thus, no isothiocyanates were determined due to the lack of conversion of glucosinolates by the enzyme. In the case of cold-pressed rapeseed cake (CPR), only isothiocyanates were detected in the final products since all glucosinolates were converted by myrosinase. This enzyme is presumed to be active in CPR due to the lower temperatures to which the rapeseeds are exposed during pressing. Other factors such as pH seemed to influence the concentration and the presence of glucosinolates. In basic media (pH = 8), the concentration of glucosinolates was lower compared with lower pH (near 7), probably due to the partial degradation of glucosinolates that can occur in alkaline pH conditions. In addition, process parameters, such as extraction time and separation technology, seemed to affect the amount and type of isothiocyanates in the final protein extracts. More studies should be performed to evaluate the impact of the identified glucosinolates on human health since both intact glucosinolates and their metabolites can give different types of biological effects.

Supplementary Materials

The following are available online at https://www.mdpi.com/article/10.3390/plants10112548/s1, Table S1. The molecular formulas and molar masses of the glucosinolates that were selected according to Tolra et al. 2000 and Metlin Metabolites dataset for identification in the samples. The underlined compounds were identified in this study selected samples. Table S2. Results of determination of glucosinolates and isothiocyantes in CPR, CPR-2, CPR-3, CPR-4, HPR-1, HPR-2 and HPR-3. Table S3. Determination of goitrin determined at different stages of pilot-scale protein extraction from cold-pressed rapeseed cake (CPR). Figure S1. Calibration curve for determination of gluconasturtiin. Figure S2. Calibration curve for determination of sinalbin. Figure S3. Calibration curve for determination of guconapin. Figure S4. Calibration curve for determination of progoitrin. Figure S5. Calibration curve for determination of sinigrin and other glucosinolates.

Author Contributions

Conceptualization, A.M.V., M.S., A.C.S.H., N.M.L.H.; methodology, A.M.V., M.S., A.T.T.; software, A.M.V.; validation, A.M.V., K.P.; investigation, A.M.V., A.T.T.; resources, M.S., K.P.; data curation, A.M.V., A.T.T.; writing—original draft preparation, A.M.V.; writing—review and editing, A.T.T., A.C.S.H., N.M.L.H., K.P.; visualization, A.M.V.; supervision, M.S., A.M.V. All authors have read and agreed to the published version of the manuscript.

Funding

The authors would like to thank the Bio Based Industries Joint Undertaking for providing funding for the Pro-Enrich project (Grant Agreement No. 792050), under the European Union’s Horizon 2020 research and innovation programme. The authors also acknowledge and thank the European Commission for funding InnoRenew CoE (grant agreement #739574), under the H2020 Widespread-Teaming programme, the Republic of Slovenia (investment funding of the Republic of Slovenia and the European Union’s European Regional 451 Development Fund), and the ARRS infrastructure program IO-0035.

Institutional Review Board Statement

Not applicable.

Informed Consent Statement

Not applicable.

Data Availability Statement

Not applicable.

Acknowledgments

The authors are grateful to Tanita Kupčič who helped with sample preparation.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. European Food Safety Authority (EFSA). Glucosinolates as undesirable substances in animal feed-Scientific Opinion of the Panel on Contaminants in the Food Chain. EFSA J. 2008, 6, 1–76. [Google Scholar]
  2. Wallsgrove, R.; Benett, R.; Kiddle, G.; Bartlet, E.; Ludwig-Mueller, J. Glucosinolate biosynthesis and pest/disease interactions. Young 1999, 1, 49. Available online: http://www.regional.org.au/au/gcirc/3/393.htm/ (accessed on 12 June 2021).
  3. Tolrà, R.P.; Alonso, R.; Poschenrieder, C.; Barceló, D.; Barceló, J. Determination of glucosinolates in rapeseed and Thlaspi caerulescens plants by liquid chromatography–atmospheric pressure chemical ionization mass spectrometry. J. Chromatogr. A 2000, 889, 75–81. [Google Scholar] [CrossRef]
  4. Song, L.; Morrison, J.J.; Botting, N.P.; Thornalley, P.J. Analysis of glucosinolates, isothiocyanates, and amine degradation products in vegetable extracts and blood plasma by LC–MS/MS. Anal. Biochem. 2005, 347, 234–243. [Google Scholar] [CrossRef] [PubMed]
  5. Kelly, A.; Bones, J.; Rossiter, T. Sub-cellular immunolocalization of the glucosinolate sinigrin in seedlings of Brassica juncea. Planta 1998, 206, 370–377. [Google Scholar] [CrossRef] [PubMed]
  6. Shapiro, T.A.; Fahey, J.W.; Wade, K.L.; Stephenson, K.K.; Talalay, P. Chemoprotective glucosinolates and isothiocyanates of broccoli sprouts: Metabolism and excretion in humans. Cancer Epidemiol. Prev. Biomark. 2001, 10, 501–508. Available online: https://cebp.aacrjournals.org/content/10/5/501/ (accessed on 18 March 2021).
  7. Rodrigues, E.A.S.; Rosa, E. Effect of post-harvest treatments on the level of glucosinolates in broccoli. J. Sci. Food Agric. 1999, 79, 1028–1032. [Google Scholar] [CrossRef]
  8. Verkerk, R.; Dekker, M.; Jongen, W.M.F. Post-harvest increase of indolyl glucosinolates in response to chopping and storage of Brassica vegetables. J. Sci. Food Agric. 2001, 81, 953–958. [Google Scholar] [CrossRef]
  9. Quinsac, A.; Charrier, D.; Ribaillier, D.; Péron, J.Y. Glucosinolates in etiolated sprouts of sea-kale (Crambe maritima L.). J. Sci. Food Agric. 1994, 65, 201–207. [Google Scholar] [CrossRef]
  10. Dinkova-Kostova, A.T.; Kostov, R.V. Glucosinolates and isothiocyanates in health and disease. Trends Mol. Med. 2012, 18, 337–347. [Google Scholar] [CrossRef] [PubMed]
  11. Geng, F.; Tang, L.; Li, Y.; Yang, L.; Choi, K.-S.; Kazim, A.L.; Zhang, Y. Allyl isothiocyanate arrests cancer cells in mitosis, and mitotic arrest in turn leads to apoptosis via Bcl-2 protein phosphorylation. J. Biol. Chem. 2011, 286, 32259–32267. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  12. Smith, T.K.; Lund, E.K.; Parker, M.L.; Clarke, R.G.; Johnson, I.T. Allyl-isothiocyanate causes mitotic block, loss of cell adhesion and disrupted cytoskeletal structure in HT29 cells. Carcinogenesis 2004, 25, 1409–1415. [Google Scholar] [CrossRef] [Green Version]
  13. Pham, N.-A.; Jacobberger, J.W.; Schimmer, A.D.; Cao, P.; Gronda, M.; Hedley, D.W. The dietary isothiocyanate sulforaphane targets pathways of apoptosis, cell cycle arrest, and oxidative stress in human pancreatic cancer cells and inhibits tumor growth in severe combined immunodeficient mice. Mol. Cancer Ther. 2004, 3, 1239–1248. [Google Scholar] [PubMed]
  14. Mellon, F.A.; Bennett, R.N.; Holst, B.; Williamson, G. Intact glucosinolate analysis in plant extracts by programmed cone voltage electrospray LC/MS: Performance and comparison with LC/MS/MS methods. Anal. Biochem. 2002, 306, 83–91. [Google Scholar] [CrossRef]
  15. Singh, H.; Mehta, P.; Vig, A.P. Removal of Glucosinolates from Rapeseed Meal Using Bowl-Shaped Tetrameric Molecules in Apolar Solvent. J. Agric. Food Chem. 1997, 45, 4522–4524. [Google Scholar] [CrossRef]
  16. Serraino, M.R.; Thompson, L.U. Removal of phytic acid and protein-phytic acid interactions in rapeseed. J. Agric. Food Chem. 1984, 32, 38–40. [Google Scholar] [CrossRef]
  17. Heaney, R.K.; Fenwick, G.R. The analysis of glucosinolates in Brassica species using gas chromatography. Direct determination of the thiocyanate ion precursors, glucobrassicin and neoglucobrassicin. J. Sci. Food Agric. 1980, 31, 593–599. [Google Scholar] [CrossRef]
  18. Velasco, P.; Soengas, P.; Vilar, M.; Cartea, M.E.; Del Rio, M. Comparison of glucosinolate profiles in leaf and seed tissues of different Brassica napus crops. J. Am. Soc. Hortic. Sci. 2008, 133, 551–558. [Google Scholar] [CrossRef] [Green Version]
  19. Sosulski, F.W.; Dabrowski, K.J. Determination of glucosinolates in canola meal and protein products by desulfation and capillary gas-liquid chromatography. J. Agric. Food Chem. 1984, 32, 1172–1175. [Google Scholar] [CrossRef]
  20. Millán, S.; Sampedro, M.C.; Gallejones, P.; Castellón, A.; Ibargoitia, M.L.; Goicolea, M.A.; Barrio, R.J. Identification and quantification of glucosinolates in rapeseed using liquid chromatography–ion trap mass spectrometry. Anal. Bioanal. Chem. 2009, 394, 1661–1669. [Google Scholar] [CrossRef] [PubMed]
  21. van Poppel, G.; Verhoeven, D.T.; Verhagen, H.; Goldbohm, R.A. Brassica vegetables and cancer prevention. Epidemiology and mechanisms. Adv. Exp. Med. Biol. 1999, 472, 159–313. [Google Scholar] [CrossRef] [PubMed]
  22. Seow, A.; Yuan, J.M.; Sun, C.L.; van den Berg, D.; Lee, H.; Yu, M.C. Dietary isothiocyanates, glutathione S-transferase polymorphisms and colorectal cancer risk in the Singapore Chinese health study. Carcinogenesis 2002, 23, 2055–2061. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  23. Bhattacharya, A.; Tang, L.; Li, Y.; Geng, F.; Paonessa, J.D.; Chen, S.C.; Wong, M.K.; Zhang, Y. Inhibition of bladder cancer development by allyl isothiocyanate. Carcinogenesis 2010, 31, 281–286. [Google Scholar] [CrossRef]
  24. London, S.J.; Yuan, J.-M.; Chung, F.L.; Gao, Y.-T.; Coetzee, G.A.; Ross, R.K.; Yu, M.C. Isothiocyanates, glutathione S-transferase M1 and T1 polymorphisms, and lung-cancer risk: A prospective study of men in Shanghai, China. Lancet 2000, 356, 724–729. [Google Scholar] [CrossRef]
  25. Fowke, J.H.; Chung, F.L.; Jin, F.; Qi, D.; Cai, Q.Y.; Conaway, C.; Cheng, J.R.; Shu, X.O.; Gao, Y.T.; Zheng, W. Urinary isothiocyanate levels, brassica, and human breast cancer. Cancer Res. 2003, 63, 3980–3986. [Google Scholar] [PubMed]
  26. Kirsh, V.A.; Peters, U.; Mayne, S.T.; Subar, A.F.; Chatterjee, N.; Johnson, C.C.; Hayes, R.B. Prospective study of fruit and vegetable intake and risk of prostate cancer. J. Natl. Cancer Inst. 2007, 99, 1200–1209. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  27. Vig, A.P.; Rampal, G.; Singh, T.S.; Arora, S. Bioprotective effects of glucosinolates—A review. LWT Food Sci. Technol. 2009, 42, 1561–1572. [Google Scholar] [CrossRef]
  28. Holst, B.; Williamson, G. A critical review of the bioavailability of glucosinolates and related compounds. Nat. Prod. Rep. 2004, 21, 425–447. [Google Scholar] [CrossRef]
  29. Andersen, K.E.; Frandsen, H.B.; Jensen, S.K.; Bellostas, N.M.; Sørensen, A.D.; Sørensen, J.C.; Sørensen, H. Glucosinolates in Brassica–Health risks, but also benefits. Nor. Acad. Sci. Lett. 2010, 1, 104–124. [Google Scholar]
  30. Mawson, R.; Heaney, R.K.; Zdunczyk, Z.; Kozłowska, H. Rapeseed meal-glucosinolates and their antinutritional effects, Part 3: Animal growth and performance. Nahrung 1994, 38, 167–177. [Google Scholar] [CrossRef]
  31. Mawson, R.; Heaney, R.K.; Piskuła, M.; Kozłowska, H. Rapeseed meal-glucosinolates and their antinutritional effects. Part 1. Rapeseed production and chemistry of glucosinolates. Nahrung 1993, 37, 131–140. [Google Scholar] [CrossRef]
  32. Burel, C.; Boujard, T.; Kaushik, S.J.; Boeuf, G.; Mol, K.A.; Van der, G.S.; Darras, V.M.; Kuhn, E.R.; Prade Balade, B.; Querat, B.; et al. Effects of rapeseed meal-glucosinolates on thyroid metabolism and feed utilization in rainbow trout. GenComp. Endocrinol. 2001, 124, 343–358. [Google Scholar] [CrossRef] [Green Version]
  33. Conaway, C.C.; Yang, Y.M.; Chung, F.L. Isothiocyanates as cancer chemopreventive agents: Their biological activities and metabolism in rodents and humans. Curr. Drug Metab. 2002, 3, 233–255. [Google Scholar] [CrossRef] [PubMed]
  34. Szydłowska-Czerniak, A.; Bartkowiak-Broda, I.; Karlović, I.; Karlovits, G.; Szłyk, E. Antioxidant capacity, total phenolics, glucosinolates and colour parameters of rapeseed cultivars. Food Chem. 2011, 127, 556–563. [Google Scholar] [CrossRef] [PubMed]
  35. Rosa, E.A.S.; Heaney, R.K.; Fenwick, G.R.; Portaz, C.A.M. Glucosinolates in crop plants. Hort. Rev. 1997, 19, 99–215. [Google Scholar] [CrossRef]
  36. El-Beltagi, H.E.D.S.; Mohamed, A.A. Variations in fatty acid composition, glucosinolate profile and some phytochemical contents in selected oil seed rape (Brassica napus L.) cultivars. Grasas Aceites 2010, 61, 143–150. [Google Scholar] [CrossRef]
  37. Travers-Martin, N.; Kuhlmann, F.; Müller, C. Revised determination of free and complexed myrosinase activities in plant extracts. Plant Physiol. Biochem. 2008, 46, 506–516. [Google Scholar] [CrossRef]
  38. Verkerk, R.; Schreiner, M.; Krumbein, A.; Ciska, E.; Holst, B.; Rowland, I.; De Schrjiver, R.; Hansen, M.; Gerhauser, C.; Mithen, R.; et al. Glucosinolates in Brassica vegetables: The influence of the food supply chain on intake, bioavailability and human health. Mol. Nutr. Food Res. 2008, 53, 219–256. [Google Scholar] [CrossRef] [PubMed]
  39. Li, X.; Kushad, M.M. Purification and characterization of myrosinase from horseradish (Armoracia rusticana) roots. Plant Physiol. Biochem. 2005, 43, 503–511. [Google Scholar] [CrossRef]
  40. Jing, P.; Zhao, S.J.; Ruan, S.Y.; Xie, Z.H.; Dong, Y.; Yu, L.L. Anthocyanin and glucosinolate occurrences in the roots of Chinese red radish (Raphanus sativus L.), and their stability to heat and pH. Food Chem. 2012, 133, 1569–1576. [Google Scholar] [CrossRef]
  41. Gevers, E.; Andrade, I.; Hallikainen, A. Information on inherent food plant toxicants: A resource generated by the EU-AIR NETTOX project (1995–1997). In Nettox Compilation of Consumption Data; Report No. 4; Danish Veterinary and Food Administration: Søborg, Denmark, 1998; p. 144. [Google Scholar]
  42. Deng, Q.; Zinoviadou, K.G.; Galanakis, C.M.; Orlien, V.; Grimi, N.; Vorobiev, E.; Lobovka, N.; Barba, F.J. The effects of conventional and non-conventional processing on glucosinolates and its derived forms, isothiocyanates: Extraction, degradation, and applications. Food Eng. Rev. 2015, 7, 357–381. [Google Scholar] [CrossRef]
  43. Kozlowska, H.J.; Nowak, H.; Nowak, J. Characterisation of myrosinase in polish varieties of rapeseed. J. Sci. Food Agric. 1983, 34, 1171–1178. [Google Scholar] [CrossRef]
  44. Morra, M.J.; Kirkegaard, J.A. Isothiocyanate release from soil-incorporated Brassica tissues. Soil Biol. Biochem. 2002, 34, 1683–1690. [Google Scholar] [CrossRef]
  45. Mithen, R. Glucosinolates and their degradation products. Adv. Bot. Res. 2001, 35, 213–262. [Google Scholar] [CrossRef]
  46. Lüthy, B.; Matile, P. The mustard oil bomb: Rectified analysis of the subcellular organisation of the myrosinase system. Biochem. Physiol. Pflanzen 1984, 179, 5–12. [Google Scholar] [CrossRef]
  47. Langer, P.; Michajlovskij, N.; Sedlak, J.; Kutka, M. Studies on the antithyroid activity of naturally occurring L-5-vinyl-2-thiooxazolidone in man. Endokrinologie 1971, 57, 225–229. [Google Scholar] [PubMed]
  48. Jie, C.; Luo, Z.; Chen, H.; Wang, M.; Yan, C.; Mao, Z.F.; Xiao, G.K.; Kurihara, H.; Li, Y.F.; He, R.R. Indirubin, a bisindole alkaloid from Isatis indigotica, reduces H1N1 susceptibility in stressed mice by regulating MAVS signaling. Oncotarget 2017, 8, 105615–105629. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  49. Xu, Y.; Li, J.; Shi, Y.; Yang, L.; Wang, Z.; Han, H.; Wang, R. Stereoselective pharmacokinetic study of epiprogoitrin and progoitrin in rats with UHPLC–MS/MS method. J. Pharm. Biomed. Anal. 2020, 187, 113356. [Google Scholar] [CrossRef] [PubMed]
  50. Cakaloglu, B.; Vasfiye, H.O.; Semih, O. Cold press in oil extraction. A review. Ukr. Food J. 2018, 7, 640–654. [Google Scholar] [CrossRef]
  51. EEC. Rapessed—Determination of glucosinolates content—Part 1: Method using highperformance liquid chromatography. ISO 9167–1, 1–9. Available online: https://www.iso.org/standard/16763.html/ (accessed on 1 July 2019).
  52. Szűcs, Z.; Plaszkó, T.; Cziáky, Z.; Kiss-Szikszai, A.; Emri, T.; Bertóti, R.; Sinka, L.T.; Vasas, G.; Gonda, S. Endophytic fungi from the roots of horseradish (Armoracia rusticana) and their interactions with the defensive metabolites of the glucosinolate-myrosinase-isothiocyanate system. BMC Plant Biol. 2018, 18, 85. [Google Scholar] [CrossRef] [Green Version]
Plants 10 02548 g001 550
Figure 1. Glucosinolates and goitrin determined at different stages of pilot-scale protein extraction from cold-pressed rapeseed cake (CPR) during trial CPR-1. n.d.—not detected.
Figure 1. Glucosinolates and goitrin determined at different stages of pilot-scale protein extraction from cold-pressed rapeseed cake (CPR) during trial CPR-1. n.d.—not detected.
Plants 10 02548 g001
Table
Table 1. Results of glucosinolates in cold-pressed rapeseed cake (CPR).
Table 1. Results of glucosinolates in cold-pressed rapeseed cake (CPR).
Name of the CompoundFormulaM[M − H]−Characteristic FragmentsFragment 96/97 RatioRTConc.
(min)
2-Hydroxy-3-butenyl glucosinolate (progoitrin)C11H19NO10S2389.0460388.038996.95951: 22.261014 ± 56 mg/kg
259.0183(2.6 mmol/kg)
2-Propenyl glucosinolate (sinigrin)C10H17NO9S2359.0287358.028796.95861: 22.923.6 ± 0.09
mg/kg
259.0012(0.01 mmol/kg)
p-Hydroxybenzyl glucosinolate (sinalbin)C14H19NO10S2425.0460424.038796.95951: 44.3921.7 ± 2.2
259.0106mg/kg
(0.05 mmol/kg)
2-Hydroxy-4-pentenyl glucosinolate (gluconapoliferin)C12H21NO10S2403.0620402.054996.96021: 34.98114.8 * ± 8.0
259.0130mg/kg
(0.28 mmol/kg)
GlucoalyssinC13H25NO10S3451.0660450.058696.96021: 25.5152.1 * ± 0.04
259.0079mg/kg
(0.12 mmol/kg)
3-Butenyl glucosinolate (gluconapin)C11H19NO9S2373.0510372.043996.96011: 35.932413 ± 27
259.0146mg/kg
(6.5 mmol/kg)
2-Methylpropyl glucosinolate/butyl glucosinolateC11H21NO9S2375.0670374.059896.95231: 310.216.3 * ± 1.1
259.0247mg/kg
(0.04 mmol/kg)
4-Pentenyl glucosinolateC12H21NO9S2387.0670386.059896.96011: 312.323.7 * ± 1.7
(glucobrassicanapin)259.0124mg/kg
(0.06 mmol/kg)
4-Methyltiobutyl glucosinolateC12H23NO9S3421.0540420.047296.96021: 315.0<LOQ
259.0137
2-Phenylethyl glucosinolate (gluconasturtiin)C15H21NO9S2423.0670422.059796.96081: 320.222.0 ± 0.8
259.0075mg/kg
(0.05 mmol/kg)
Methylpentyl glucosinolateC13H25NO9S2403.0990402.091596.96041: 224.231.7 * ± 2.2
259.0098mg/kg
(0.08 mmol/kg)
Methylpentyl glucosinolateC13H25NO9S2403,098402.091196.95911: 224.719.5 * ± 1.4
259.0118mg/kg
(0.05 mmol/kg)
Methylpentyl glucosinolateC13H25NO9S2403,099402.091396.96271: 225.711.5 *± 0.8
mg/kg
(0.03 mmol/kg)
Neoglucobrassicin C17H22N2O10S2478.073477.065796.96051: 326.6<LOQ
259.0131
446.0503
Total determined glucosinolates 3740 ± 261 mg/kg
(9.9 ± 0.7 mmol/kg)
* The results were expressed as sinigrin equivalents.
Table
Table 2. Results of determined glucosinolates in different protein products from hot-pressed rapeseed cake (HPR) The concentrationsare shown with different colours. The more solid the red colour, the higher the concentration of glucosinolates; the more solid the green colour, the lower is the concentration of glucosinolates.
Table 2. Results of determined glucosinolates in different protein products from hot-pressed rapeseed cake (HPR) The concentrationsare shown with different colours. The more solid the red colour, the higher the concentration of glucosinolates; the more solid the green colour, the lower is the concentration of glucosinolates.
HPR-1HPR-2HPR-3
Progoitrin1600 ± 160 mg/kg1720 ± 10 mg/kg2565 ± 3.0 mg/kg
Gluconapoliferin28.3 * ± 0.1 mg/kg54 * ± 5 mg/kg3.0 * ± 0.3 mg/kg
Glucoalyssin<LOD35.4*± 0.3 mg/kg52 * ± 0.3 mg/kg
Gluconapin1479 ± 5.8 mg/kg2024 ± 2.7 mg/kg2209 ± 29 mg/kg
Butyl glucosinolate5.3 * ± 0.05 mg/kg4.8 * ± 0.03 mg/kg5.3 * ± 0.1 mg/kg
4-Pentenyl glucosinolate16.5 * ± 0.08 mg/kg64.0 *± 1.0 mg/kg60.9 * ± 0.2 mg/kg
Gluconasturtiin<LOD11.3 ± 0.3 mg/kg28.9 ± 0.4 mg/kg
Neoglucobrassicin<LOD1.9 * ± 0.1 mg/kg10.3 * ± 0.2 mg/kg
3-Methylpentyl glucosinolate<LOD1.5 *± 0.05 mg/kg4.1 *± 0.3 mg/kg
4-Methyltiobutyl glucosinolate<LOD<LOD4.7 * ± 0.3 mg/kg
* The results were expressed as sinigrin equivalents.
Table
Table 3. Results of determined isothiocyanate and goitrin in different protein products from cold-pressed rapeseed cake (CPR). Limit of detection (LOD) varied from 0.07 mg/kg sample to 0.42 mg/kg sample, whereas the limit of quantification (LOQ) varied from 0.7 mg/kg sample to 4.2 mg/kg sample.
Table 3. Results of determined isothiocyanate and goitrin in different protein products from cold-pressed rapeseed cake (CPR). Limit of detection (LOD) varied from 0.07 mg/kg sample to 0.42 mg/kg sample, whereas the limit of quantification (LOQ) varied from 0.7 mg/kg sample to 4.2 mg/kg sample.
Name of the Isothiocyanate IdentifiedSpray-Dried Protein ExtractOven-Dried Protein Extract (Trial CPR-3) Spray-Dried Product Extract (Trial CPR-4)
(Trial CPR-2)
Goitrin95 ± 7 mg/kg7 ± 0.5 mg/kg22 ± 1.5 mg/kg
2-Phenylethyl isothiocyanate<LOD<LOQ<LOD
(from Gluconasturtiin)
4-Methylthiobutyl isothiocyanate<LOQ<LOD<LOD
3-Butenyl isothiocyanate<LOD<LOD<LOQ
(from Gluconapin)
Table
Table 4. The description of different processing parameters that were tested.
Table 4. The description of different processing parameters that were tested.
Raw MaterialTrial No.Brief Process Description
CPR1Soaking overnight, manual liquid–liquid separation and 5 kDa ultrafiltration for concentration, spray drying. 5-day process
CPR2Soaking overnight, 0.2 µ microfiltration for liquid–liquid separation and 5 kDa ultrafiltration for concentration, spray drying. 4-day process
CPR3Soaking overnight, 0.2 µ microfiltration for liquid–liquid separation and 10 kDa ultrafiltration for concentration, oven drying. 5-day process
CPR4Soaking overnight, 0.2 µ microfiltration for liquid–liquid separation and 10 kDa ultrafiltration for concentration, final product in liquid form. 5-day process
HPR1Soaking/hydrolysis overnight at 55 °C, enzymatic extraction at pH 8, 0.2 µ microfiltration for liquid–liquid separation and 10 kDa ultrafiltration for concentration, spray drying.
HPR2Soaking/hydrolysis overnight at 58 °C, enzymatic extraction at pH 6.7, 0.2 µ microfiltration for liquid–liquid separation and 300 Da nanofiltration for concentration, spray drying.
HPR3Soaking/hydrolysis for ca. 4 h at 50 °C, enzymatic extraction at pH 5.0 for 1 h followed by pH adjustment to pH 7.0 a subsequent 30 min reaction time, 0.2 µ microfiltration for liquid–liquid separation and 300 Da nanofiltration for concentration, final product in liquid form.
Table
Table 5. Dry powder yield of the protein end products CPR-1 to CPR-4 and HPR-1 to HPR-3.
Table 5. Dry powder yield of the protein end products CPR-1 to CPR-4 and HPR-1 to HPR-3.
Raw MaterialTrial No.Dry Product Yield
(g/100 g Dry Raw Material)
CPR14.3
CPR23.6
CPR312.3
CPR46.1
HPR118.1
HPR223.1
HPR314.7
Publisher’s Note: MDPI stays neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Share and Cite

MDPI and ACS Style

Miklavčič Višnjevec, A.; Tamayo Tenorio, A.; Steenkjær Hastrup, A.C.; Hansen, N.M.L.; Peeters, K.; Schwarzkopf, M. Glucosinolates and Isothiocyantes in Processed Rapeseed Determined by HPLC-DAD-qTOF. Plants 2021, 10, 2548. https://doi.org/10.3390/plants10112548

AMA Style

Miklavčič Višnjevec A, Tamayo Tenorio A, Steenkjær Hastrup AC, Hansen NML, Peeters K, Schwarzkopf M. Glucosinolates and Isothiocyantes in Processed Rapeseed Determined by HPLC-DAD-qTOF. Plants. 2021; 10(11):2548. https://doi.org/10.3390/plants10112548

Chicago/Turabian Style

Miklavčič Višnjevec, Ana, Angelica Tamayo Tenorio, Anne Christine Steenkjær Hastrup, Natanya Majbritt Louie Hansen, Kelly Peeters, and Matthew Schwarzkopf. 2021. "Glucosinolates and Isothiocyantes in Processed Rapeseed Determined by HPLC-DAD-qTOF" Plants 10, no. 11: 2548. https://doi.org/10.3390/plants10112548

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop