Search Results (10)

In this study, extracts of Robusta-roasted coffee were obtained using various extraction techniques, including subcritical fluid extractions using HFC-134a and HCFC-22 under room-temperature batch extraction, frozen-temperature batch extraction, and continuous extraction conditions. Additionally, supercritical carbon dioxide (SCCO₂) extraction was performed using ethanol and tetrahydrofuran as co-solvents. These extractions were performed due to the presence of potent antioxidants and antibacterial substances in the extracts. Extraction machines were built to process the extraction. The antioxidant potential of the extracts was evaluated using total phenolic content and DPPH and FRAP assays, while antibacterial potential was identified using the disk diffusion method. The results showed that HCFC-22 extraction produced the highest yield compared to other extraction methods, but HFC-134a extraction had the highest antioxidant potential values. The yield and antioxidant potential of the extracts obtained using room-temperature batch extraction were slightly higher than those obtained using frozen-temperature batch extraction and continuous extraction. The yield and antioxidant potential of the extracts obtained using SCCO₂ extraction were similar to those obtained using HFC-134a and HCFC-22 extractions, and co-solvents slightly improved the extraction performance. The extracts were found to be more effective as inhibitors of Gram-positive bacteria than Gram-negative bacteria. Caffeine was the most prominent tentative chemical compound in all coffee extracts. This research study provides a better understanding of various extraction techniques using HFC-134a, HCFC-22, and SCCO₂ when applied to roasted Robusta coffee beans, with a focus on yield, antioxidant potential, antimicrobial potential, and tentative chemical profiles. Full article

More than 58 million metric tonnes of oranges were produced in 2021, and the peels, which account for around one-fifth of the fruit weight, are often discarded as waste in the orange juice industry. Orange pomace and peels as wastes are used as a sustainable raw material to make valuable products for nutraceuticals. The orange peels and pomace contain pectin, phenolics, and limonene, which have been linked to various health benefits. Various green extraction methods, including supercritical carbon dioxide (ScCO₂) extraction, subcritical water extraction (SWE), ultrasound-assisted extraction (UAE), and microwave-assisted extraction (MAE), are applied to valorize the orange peels and pomace. Therefore, this short review will give insight into the valorization of orange peels/pomace extraction using different extraction methods for health and wellness. This review extracts information from articles written in English and published from 2004 to 2022. The review also discusses orange production, bioactive compounds in orange peels/pomaces, green extractions, and potential uses in the food industry. Based on this review, the valorization of orange peels and pomaces can be carried out using green extraction methods with high quantities and qualities of extracts. Therefore, the extract can be used for health and wellness products. Full article

Anthocyanins are one of the bioactive compounds in roselle that has many medicinal proposes. Anthocyanins are placed in the inner part of the roselle; therefore, combinations of two methods were applied to extract the anthocyanins. The first stage is employing supercritical carbon dioxide (ScCO₂) to break the particle surface or outer layer of the roselle based on the total phenolic compounds (TPC) recovery, and the second step was to apply subcritical water extraction (SWE) for the extraction of anthocyanins. The objective is to determine the best conditions to obtain high yields of total anthocyanins compounds (TAC) from the roselle (Hibiscus sabdariffa) by employing a combination of ScCO₂ and SWE. The optimal conditions of ScCO₂ (first stage) were 19.13 MPa, 60 °C, and 4.31 mL/min, yielding 18.20%, and 80.34 mg/100 g TPC, respectively. The optimum conditions of SWE (second stage) were 9.48 MPa, 137 °C, and 6.14 mL/min, yielding 86.11% and 1224.61 mg/100 g TAC, respectively. The application of integrated ScCO₂ and SWE proved successful in achieving high anthocyanins production and yield as compared to previous extraction methods. This approach may be used to extract the roselle with a greater anthocyanin’s concentration than the prior method. Full article

The fruit of Phaleria macrocarpa have been traditionally used as an antidiabetic remedy in Malaysia and neighbouring countries. Despite its potential for diabetes treatment, no scientific study has ever been conducted to predict the inhibitor interaction of the protein α-glucosidase identified in an extract prepared with a non-conventional extraction technique. Hence, the major aim of this research was to evaluate the in vitro antioxidant, the α-glucosidase inhibitors, and the molecular dynamic simulations of the α-glucosidase inhibitors identified by Quadrupole Time-of-Flight Liquid Chromatography Mass Spectrometry (Q-ToF-LCMS) analysis. Initially, dry fruit were processed using non-conventional and conventional extraction methods to obtain subcritical carbon dioxide extracts (SCE-1 and SCE-2) and heating under reflux extract (HRE), respectively. Subsequently, all extracts were evaluated for their in vitro antioxidative and α-glucosidase inhibitory potentials. Subsequently, the most bioactive extract (SCE-2) was subjected to Q-ToF-LCMS analysis to confirm the presence of α-glucosidase inhibitors, which were then analysed through molecular dynamic simulations and network pharmacology approaches to confirm their possible mechanism of action. The highest inhibitory effects of the 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical and α-glucosidase on SCE-2 was found as 75.36 ± 0.82% and 81.79 ± 0.82%, respectively, compared to the SCE-1 and HRE samples. The Q-ToF-LCMS analysis tentatively identified 14 potent α-glucosidase inhibitors. Finally, five identified compounds, viz., lupenone, swertianolin, m-coumaric acid, pantothenic acid, and 8-C-glucopyranosyleriodictylol displayed significant stability, compactness, stronger protein-ligand interaction up to 100 ns further confirming their potential as α-glucosidase inhibitors. Consequently, it was concluded that the SCE-2 possesses a strong α-glucosidase inhibitory effect due to the presence of these compounds. The findings of this study might prove useful to develop these compounds as alternative safe α-glucosidase inhibitors to manage diabetes more effectively. Full article

The purpose of the study was to select an environmentally friendly plant biopesticide to protect seed potatoes against phytopathogens. The scope included the evaluation of the antimicrobial activities of 22 plant water extracts, 22 water-glycol extracts, and 3 subcritical carbon dioxide extracts using the agar diffusion method against 10 potato phytopathogens. For the most effective extracts, minimal inhibitory concentration (MIC), chemical composition analysis by gas chromatography–mass spectrometry and in situ assays on seed potatoes were performed. Garlic water extract was finally selected as the most effective in phytopathogen growth inhibition, both in vitro and in situ, with MIC values ranging between 6.3–25 mg/mL. 5-Hydroxymethylfurfural was determined to be the main component of this extract (33.24%). Garlic water extract was proposed as a potential biopesticide against potato phytopathogens. Full article

Polyunsaturated fatty acids are well known for their protective properties in relation to different skin diseases. Although seaweeds possess a low lipid fraction, they could act as an alternative renewable source of polyunsaturated fatty acids whenever other valuable seaweed components are also valorized. In this study, a biorefinery process using Mastocarpus stellatus as a model seaweed was proposed. The process started with the supercritical carbon dioxide extraction of the lipid and phenolic fractions. The influence of pressure during extraction with pure supercritical CO₂ was studied while operating at a selected temperature and solvent flow rate. Kinetic data obtained during the ethanol-modified supercritical CO₂ extraction were fitted to the spline model. Sequential processing was proposed with (i) pure CO₂ to obtain a product with 30% PUFA content and ω-3:ω-6 ratio 1:1, (ii) ethanol-modified CO₂ to extract phenolics, and (iii) microwave-assisted subcritical water extraction operating under previously optimized conditions for the extraction of phenolics, carrageenan and protein fractions. The composition of the supercritical extracts showed potential for use in both dietary and topical applications in skin care products. The remaining solids are suitable for the extraction of other valuable fractions. Full article

The oil industry generates great quantities of oilseed cakes that remain after oil extraction. New technologies are required for their valorization, owing to their high nutritional value. Pumpkin, flax and hemp seed cakes were extracted by subcritical water under different conditions that included different gas atmospheres and homogenous catalysis, and for the first time their properties were directly compared. Extracts obtained in a nitrogen atmosphere, nitrogen atmosphere with the addition of a catalyst, and carbon dioxide atmosphere were chemically and nutritionally characterised. In the aqueous extracts obtained under different extraction conditions, the content of lipids, proteins and selected minerals (calcium, potassium, sodium and phosphorus) were determined. A detailed amino acid profile was determined by chromatographic analysis. The highest relative content of essential amino acids was observed in pumpkin seed extracts (51.49 ± 0.47 to 58.58 ± 0.45 mg/100 g dry extract), whereas hemp seed extracts were the richest in flavour amino acids aspartic acid, glutamic acid and alanine. Extraction in a carbon dioxide atmosphere or in nitrogen atmosphere with a HCl modifier released generally more minerals into the aqueous phase. Aqueous oilseed cake extracts demonstrated a favorable chemical composition and great nutritional value, opening new possibilities for exploitation of this biowaste. Based on the obtained results, oilseed cake extracts obtained by subcritical water have great potential to be used for the fortification of different food products, as well as in cosmetics. Full article

Hydrothermal depolymerization of lignin-rich streams (LRS) from lignocellulosic ethanol was successfully carried out in a lab-scale batch reactors unit. A partial depolymerization into oligomers and monomers was achieved using subcritical water as reaction medium. The influence of temperature (300–350–370 °C) and time (5–10 minutes) was investigated to identify the optimal condition on the monomers yields in the lighter biocrude (BC1) and aqueous phase (AP) fractions, focusing on specific phenolic classes as well as carboxylic acids and alcohols. The effect of base catalyzed reactions (2–4 wt. % of KOH) was compared to the control tests as well as to acid-catalyzed reactions obtained with a biphasic medium of supercritical carbon dioxide (sCO₂) and subcritical water. KOH addition resulted in enhanced overall depolymerization without showing a strong influence on the phenolic generation, whereas sCO₂ demonstrated higher phenolic selectivity even though no effect was observed on the overall products mass yields. In conclusion, a comparison between two different biocrude collection procedures was carried out in order to understand how the selected chemical extraction mode influences the distribution of compounds between BC1 and AP. Full article

Hot, subcritical and supercritical water, methanol, ethanol and their binary mixtures have been employed to treat fuels (desulfurize coal and recover liquid fuels from coal and oil shales) and to extract valuable solutes from biomass. The properties of these solvents that are relevant to their extraction abilities are presented. Various extraction methods: accelerated solvent extraction (ASE), pressurized liquid extraction (PLE), supercritical fluid extraction (SFE, but excluding supercritical carbon dioxide) with these solvents, including microwave- and ultrasound-assisted extraction, are dealt with. The extraction systems are extensively illustrated and discussed. Full article

Extraction and deacidification are important stages for wheat germ oil (WGO) production. Crude WGO was extracted using subcritical butane extraction (SBE) and compared with traditional solvent extraction (SE) and supercritical carbon dioxide extraction (SCE) based on the yield, chemical index and fatty acid profile. Furthermore, the effects of the molecular distillation temperature on the quality of WGO were also investigated in this study. Results indicated that WGO extracted by SBE has a higher yield of 9.10% and better quality; at the same time, its fatty acid composition has no significant difference compared with that of SE and SCE. The molecular distillation experiment showed that the acid value, peroxide value and p-anisidine value of WGO were reduced with the increase of the evaporation temperatures, and the contents of the active constituents of tocopherol, polyphenols and phytosterols are simultaneously decreased. Generally, the distillation temperature of 150 °C is an appropriate condition for WGO deacidification with the higher deacidification efficiency of 77.78% and the higher retention rate of active constituents. Full article