Enhancement of Alkali Resistance of Glass Fibers via In Situ Modification of Manganese-Based Nanomaterials
Abstract
:1. Introduction
2. Experimental Programmer
2.1. Materials
2.2. Surface Modification of Glass Fibers
2.3. Alkali Resistance Measurement
2.3.1. Mass Loss Test
2.3.2. Strength Retention Test
2.4. Characterization of Glass Fibers
3. Results and Discussion
3.1. Surface Modification of Glass Fibers
3.1.1. Morphology of Fibers by SEM
3.1.2. Synthetic Products by XPS
3.2. Alkali-Resistant Performance of Glass Fibers
3.2.1. Mass Loss Ratio
3.2.2. Strength Retention
4. Conclusions
Author Contributions
Funding
Institutional Review Board Statement
Informed Consent Statement
Data Availability Statement
Acknowledgments
Conflicts of Interest
References
- Chen, H.; Wang, P.; Pan, J.; Lawi, A.; Zhu, Y. Effect of alkali-resistant glass fiber and silica fume on mechanical and shrinkage properties of cement-based mortars. Constr. Build. Mater. 2021, 307, 125054. [Google Scholar] [CrossRef]
- Ma, S.; Hou, D.; Bao, P.; Wang, D. Influence of alkali-resistant glass fiber on seismic performance of precast ceramsite concrete sandwich wall panels. Structures 2022, 38, 94–107. [Google Scholar] [CrossRef]
- Wang, Q.; Ding, Y.; Randl, N. Investigation on the alkali resistance of basalt fiber and its textile in different alkaline environments. Constr. Build. Mater. 2021, 272, 121670. [Google Scholar] [CrossRef]
- Rezakhani, R.; Alnaggar, M.; Cusatis, G. Multiscale Homogenization Analysis of Alkali-Silica Reaction (ASR) Effect in Concrete. Engineering 2019, 5, 1139–1154. [Google Scholar] [CrossRef]
- Wusirika, R. Alkali Durability of Oxynitride Glass Fibers. J. Am. Ceram. Soc. 1991, 74, 454–456. [Google Scholar] [CrossRef]
- Yue, Y.; Wang, Y. Effect of mental oxide on the structure and property of rare earth doped glass. IOP Conf. Ser. Earth Environ. Sci. 2020, 565, 12061. [Google Scholar] [CrossRef]
- Gao, S.; Mäder, E.; Plonka, R. Nanostructured coatings of glass fibers: Improvement of alkali resistance and mechanical properties. Acta Mater. 2007, 55, 1043–1052. [Google Scholar] [CrossRef]
- Gao, S.; Mäder, E.; Abdkader, A.; Offermann, P. Environmental resistance and mechanical performance of alkali-resistant glass fibers with surface sizings. J. Non-Cryst. Solids 2003, 325, 230–241. [Google Scholar] [CrossRef]
- Dou, H.; Bai, J.; Lu, H.; Zhang, T.; Kong, L.; Bai, Z.; Li, W. Effect of TiO2 on preparation condition, mechanical properties and alkali resistance of continuous basalt fibers. Cem. Concr. Compos. 2023, 136, 104861. [Google Scholar] [CrossRef]
- Lee, J.-S.; Lee, M.; Lim, T.-Y.; Lee, Y.; Jeon, D.-W.; Hyun, S.-K.; Kim, J.-H. Performance of Alkali-Resistant Glass Fibers Modified with Refused Coal Ore. Mater. Trans. 2017, 58, 705–710. [Google Scholar] [CrossRef]
- Lipatov, Y.V.; Gutnikov, S.I.; Lazoryak, B.I. Zr-rich basalt continuous fibers with increased alkali resistant properties. Constr. Build. Mater. 2021, 288, 123089. [Google Scholar] [CrossRef]
- Sayyar, M.; Soroushian, P.; Sadiq, M.M.; Balachandra, A.; Lu, J. Low-cost glass fiber composites with enhanced alkali resistance tailored towards concrete reinforcement. Constr. Build. Mater. 2013, 44, 458–463. [Google Scholar] [CrossRef]
- Benmokrane, B.; Hassan, M.; Robert, M.; Vijay, P.V.; Manalo, A. Effect of Different Constituent Fiber, Resin, and Sizing Combinations on Alkaline Resistance of Basalt, Carbon, and Glass FRP Bars. J. Compos. Constr. 2020, 24, 1009. [Google Scholar] [CrossRef]
- Kimm, M.; Pico, D.; Gries, T. Investigation of surface modification and volume content of glass and carbon fibres from fibre reinforced polymer waste for reinforcing concrete. J. Hazard. Mater. 2020, 390, 121797. [Google Scholar] [CrossRef] [PubMed]
- Pan, Y.; Yan, D. Study on the durability of GFRP bars and carbon/glass hybrid fiber reinforced polymer (HFRP) bars aged in alkaline solution. Compos. Struct. 2020, 261, 113285. [Google Scholar] [CrossRef]
- Gao, S.-L.; Mäder, E.; Plonka, R. Nanocomposite coatings for healing surface defects of glass fibers and improving interfacial adhesion. Compos. Sci. Technol. 2008, 68, 2892–2901. [Google Scholar] [CrossRef]
- Kim, J.-K.; Hu, C.; Woo, R.S.; Sham, M.-L. Moisture barrier characteristics of organoclay-epoxy nanocomposites. Compos. Sci. Technol. 2005, 65, 805–813. [Google Scholar] [CrossRef]
- Shah, A.P.; Gupta, R.K.; Gangarao, H.V.S.; Powell, C.E. Moisture diffusion through vinyl ester nanocomposites made with montmorillonite clay. Polym. Eng. Sci. 2002, 42, 1852–1863. [Google Scholar] [CrossRef]
- Signorini, C.; Nobili, A.; González, E.C.; Siligardi, C. Silica coating for interphase bond enhancement of carbon and AR-glass Textile Reinforced Mortar (TRM). Compos. Part B Eng. 2018, 141, 191–202. [Google Scholar] [CrossRef]
- Zabihi, O.; Ahmadi, M.; Li, Q.; Shafei, S.; Huson, M.G.; Naebe, M. Carbon fibre surface modification using functionalized nanoclay: A hierarchical interphase for fibre-reinforced polymer composites. Compos. Sci. Technol. 2017, 148, 49–58. [Google Scholar] [CrossRef]
- Signorini, C.; Sola, A.; Malchiodi, B.; Nobili, A.; Gatto, A. Failure mechanism of silica coated polypropylene fibres for Fibre Reinforced Concrete (FRC). Constr. Build. Mater. 2021, 236, 117549. [Google Scholar] [CrossRef]
- Ahmed, M.K.; Bagheri Behboud, A.; Kurucu, A.; Kurt Çömlekçi, G.; Ordu, M. Improved mechanical properties of the E-glass fibres through TiO2 nanoparticle coating. Mater. Sci. Technol. 2023, 39, 1304–1312. [Google Scholar] [CrossRef]
- Nadiv, R.; Peled, A.; Mechtcherine, V.; Hempel, S.; Schroefl, C. Micro- and nanoparticle mineral coating for enhanced properties of carbon multifilament yarn cement-based composites. Compos. Part B Eng. 2017, 111, 179–189. [Google Scholar] [CrossRef]
- Signorini, C.; Sola, A.; Nobili, A.; Siligardi, C. Lime-cement textile reinforced mortar (TRM) with modified interphase. J. Appl. Biomater. Funct. Mater. 2019, 17, 1–9. [Google Scholar] [CrossRef] [PubMed]
- Measurement Services Division of the National Institute of Standards and Technology of America. Available online: https://srdata.nist.gov/xps/selEnergyType.aspx (accessed on 15 September 2012).
- Takashima, T.; Hashimoto, K.; Nakamura, R. Inhibition of Charge Disproportionation of MnO2 Electrocatalysts for Efficient Water Oxidation under Neutral Conditions. J. Am. Chem. Soc. 2012, 134, 18153–18156. [Google Scholar] [CrossRef]
- Dhir, R.K.; Dyer, T.D.; Tang, M.C. Alkali-silica reaction in concrete containing glass. Mater. Struct. Constr. 2009, 42, 1451–1462. [Google Scholar] [CrossRef]
Fiber Type | Elemental Percentage (%) | |||||
---|---|---|---|---|---|---|
Si2p | C1s | N1s | O1s | Mn2p3 | Na1s | |
ARGF | 1.33 | 72.37 | 1.94 | 23.31 | 0 | 0.96 |
ARGF-Mn | 5.33 | 58.86 | 4.76 | 26.26 | 2.22 | 2.01 |
Binding energy (eV) | 640.9 | 642.2 | 642.4 | 652.5 | 653.3 | 654.3 | 642.2 |
Peak area (a.u.) | 1876.86 | 846.42 | 9500.52 | 1289.53 | 1218.18 | 3049.04 | 846.42 |
Disclaimer/Publisher’s Note: The statements, opinions and data contained in all publications are solely those of the individual author(s) and contributor(s) and not of MDPI and/or the editor(s). MDPI and/or the editor(s) disclaim responsibility for any injury to people or property resulting from any ideas, methods, instructions or products referred to in the content. |
© 2023 by the authors. Licensee MDPI, Basel, Switzerland. This article is an open access article distributed under the terms and conditions of the Creative Commons Attribution (CC BY) license (https://creativecommons.org/licenses/by/4.0/).
Share and Cite
Wang, G.; Zhang, J.; Li, F.; Li, K.; Xin, M.; Zhu, J.; Lu, X.; Cheng, X.; Zhang, L. Enhancement of Alkali Resistance of Glass Fibers via In Situ Modification of Manganese-Based Nanomaterials. Materials 2023, 16, 5663. https://doi.org/10.3390/ma16165663
Wang G, Zhang J, Li F, Li K, Xin M, Zhu J, Lu X, Cheng X, Zhang L. Enhancement of Alkali Resistance of Glass Fibers via In Situ Modification of Manganese-Based Nanomaterials. Materials. 2023; 16(16):5663. https://doi.org/10.3390/ma16165663
Chicago/Turabian StyleWang, Guangzhou, Jinzhuo Zhang, Fuxin Li, Kangli Li, Minglian Xin, Jiang Zhu, Xiaolei Lu, Xin Cheng, and Lina Zhang. 2023. "Enhancement of Alkali Resistance of Glass Fibers via In Situ Modification of Manganese-Based Nanomaterials" Materials 16, no. 16: 5663. https://doi.org/10.3390/ma16165663