Next Article in Journal
DRSNFuse: Deep Residual Shrinkage Network for Infrared and Visible Image Fusion
Previous Article in Journal
Spherical-Cap Approximation of Vector Quantization for Quantization-Based Combining in MIMO Broadcast Channels with Limited Feedback
Previous Article in Special Issue
A Comparative Study of the Electrical and Electromechanical Responses of Carbon Nanotube/Polypropylene Composites in Alternating and Direct Current
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Easy-Scalable Flexible Sensors Made of Carbon Nanotube-Doped Polydimethylsiloxane: Analysis of Manufacturing Conditions and Proof of Concept

by
Antonio del Bosque
*,
Xoan F. Sánchez-Romate
,
María Sánchez
and
Alejandro Ureña
Materials Science and Engineering Area, Escuela Superior de Ciencias Experimentales y Tecnología, Universidad Rey Juan Carlos, C/Tulipán s/n, Móstoles, 28933 Madrid, Spain
*
Author to whom correspondence should be addressed.
Sensors 2022, 22(14), 5147; https://doi.org/10.3390/s22145147
Submission received: 14 June 2022 / Revised: 1 July 2022 / Accepted: 7 July 2022 / Published: 8 July 2022
(This article belongs to the Special Issue Sensing Technologies with Carbon Nanotube-Based Materials)

Abstract

:
Carbon nanotube (CNT) reinforced polydimethylsiloxane (PDMS) easy-scalable sensors for human motion monitoring are proposed. First, the analysis of the dispersion procedure of nanoparticles into the polymer matrix shows that the ultrasonication (US) technique provides a higher electrical sensitivity in comparison to three-roll milling (3RM) due to the higher homogeneity of the CNT distribution induced by the cavitation forces. Furthermore, the gauge factor (GF) calculated from tensile tests decreases with increasing the CNT content, as the interparticle distance between CNTs is reduced and, thus, the contribution of the tunnelling mechanisms diminishes. Therefore, the optimum conditions were set at 0.4 CNT wt.% dispersed by US procedure, providing a GF of approximately 37 for large strains. The electrical response under cycling load was tested at 2%, 5%, and 10% strain level, indicating a high robustness of the developed sensors. Thus, this strain sensor is in a privileged position with respect to the state-of-the-art, considering all the characteristics that this type of sensor must accomplish: high GF, high flexibility, high reproducibility, easy manufacturing, and friendly operation. Finally, a proof-of-concept of human motion monitoring by placing a sensor for elbow and finger movements is carried out. The electrical resistance was found to increase, as expected, with the bending angle and it is totally recovered after stretching, indicating that there is no prevalent damage and highlighting the huge robustness and applicability of the proposed materials as wearable sensors.

1. Introduction

Nowadays, there is an increasing interest in the development of proper techniques for Structural Health Monitoring (SHM) applications, as it allows a continuous inspection of service structures, reducing the preventive maintenance and the costs that are associated to it. In this regard, there are a lot SHM techniques such as Fibre Bragg Grating (FBG) sensors, guided ultrasonic waves, or acoustic emission. In most of these cases, complex analytical and numerical tools are required and sometimes do not offer accurate information on the overall performance of the material [1,2]. For these reasons, it is necessary to explore other options.
Carbon nanoparticles and, most specifically, carbon nanotubes (CNTs) are an interesting alternative option for SHM purposes. The basis for SHM purposes lies in the fact that these conductive nanoparticles, when added into an insulating material such as a polymer to constitute a nanocomposite, promote the creation of an electrical percolation network, leading to a drastic enhancement of the electrical conductivity of the material. This electrical network will be affected by the presence of cracks or strain, which will be reflected in changes in the overall electrical conductivity due to the creation or breakage of conductive pathways [3,4,5,6]. Therefore, the application of carbon nanoparticles is now of great interest for damage detection in structural components. In this regard, some techniques such as Electrical Impedance Tomography (EIT) have gained much impact since they allow the damage to be easily detected, located, and quantified [7,8].
Apart from the use of carbon nanoparticles for SHM of structural components, their application for the development of strain sensors is now being extensively investigated [9,10,11,12]. This application is based on taking advantage of the alteration of the electrical percolation networks that occurs when the material is subjected to a deformation field that generates changes in the distances between neighboring nanoparticles. These changes have a very sensitive effect on tunnel conduction mechanisms, causing changes in the overall electrical performance of the whole material. More specifically, it is widely known that the electrical resistance associated to the tunnelling effect, also called tunnelling resistance, follows a linear-exponential correlation with the applied strain. This makes this type of sensor based on conductive nanoparticles very sensitive to mechanical deformation.
Within this group of materials, there is great interest in researching and developing wearable sensors based on CNT-reinforced silicon elastomers. These sensors must accomplish the following requirements: high values of failure strain, high sensitivity, high reproducibility, easy to manufacture, and user-friendly operation. Thereby, different silicone elastomers such as homemade silicone [13], Ecoflex [14,15,16,17], or PDMS [18,19,20,21,22,23,24,25,26,27] are being investigated to developed strain sensors. Here, it is essential to determine the adequate CNT content and reach the proper nanoparticle dispersion into the elastomer, as the CNT distribution plays a crucial role in the formation of a sensile electric percolation network which defines the final electromechanical properties of the sensor [28]. However, difficulties related to electrode placement on the surface of silicone nanocomposites remain to be investigated, due to the hydrophobic nature. In view of the state of the art, a strain sensor that achieves all the requirements has not yet been developed, since either they do not have a high sensitivity or flexibility, or a complex and expensive manufacturing method must be followed (for example CVD or laser ablation), or they are not user-friendly.
Thus, this study aims to develop a CNT-PDMS wearable sensor for human motion monitoring that meets the main requirements discussed above. Here, a study of the influence of dispersion procedure on the electrical and electromechanical properties was carried out to select the optimum manufacturing conditions to achieve the maximum sensitivity. In this regard, two simple dispersion techniques were evaluated: three-roll milling and ultrasonication. Finally, a proof-of-concept of human motion monitoring was conducted, proving the applicability of the proposed materials as wearable skin-mounted sensors.

2. Materials and Methods

2.1. Materials

Nanocomposites were manufactured with CNTs embedded in a silicone elastomeric matrix. The silicone elastomer was based on polydimethylsiloxane (PDMS) with the commercial denomination of SYLGARD 184TM, purchased from Dow®. The base monomer, with a viscosity of 5100 mPa·s, and the curing agent, with a viscosity of 3500 mPa·s, of PDMS were mixed in a 10:1 mass ratio. Multi-Wall Carbon Nanotubes (MWCNTs) used for this investigation were NC7000, purchased from Nanocyl®. They have an average diameter of 9.5 nm, a surface area of 250–300 m2/g, an average length of 1.5 μm, and a bulk density (EN DIN 60) of 66 kg/m3 with a 90% carbon purity.

2.2. Manufacturing of CNT-Doped PDMS Sensors

PDMS-based nanocomposites reinforced with CNTs were manufactured with a combination of two typical nanoparticle dispersion procedures in polymer matrices: three roll milling (3RM) and ultrasonication (US). CNT contents (0.25, 0.3, 0.4, 0.5, 0.75, and 1 wt.%) were selected to determine the percolation threshold of the CNT-PDMS system, that is, the critical CNT content in which it becomes electrically conductive; as well as, to explore the influence of the dispersion procedure on the electromechanical properties of the final nanocomposite.
On one hand, CNTs were dispersed by 3RM process using an EXAKT 80E three roll milling machine. This technique consists of a progressive reduction of the gaps between consecutive rolls rotating at different speed ratios of 9:3:1 at room temperature, being 250 rpm the rotating speed of the fastest roll. The high shear forces induced by the rolls on the mixture promote a disaggregation of CNTs agglomerates. The 3RM process parameters were optimized in a previous study [29], and they are shown in Table 1.
On the other hand, CNTs were dispersed by US process using a HIELSCHER ULTRASONIC PROCESSOR UP400ST machine at 0.5 pulse cycles and 50 % amplitude. This technique induces the breakage of CNT agglomerates due to the cavitation forces induced by the ultrasonic pulses. A study of the influence of sonication time on dispersion state was carried out, taking samples at initial state, 30 min, 1 h, 1.5 h, 2 h, and 2.5 h of sonication (Figure S1, Supplementary Materials). As indicated in the Supplementary Information, 2 h of this process was enough to guarantee a good CNT dispersion.
After the dispersion procedures, for both routes (3RM and US), a degassing step was carried out to evacuate the air trapped in the mixture during dispersion. For this, the mixture was heated to 80 °C to decrease its viscosity and then degassing was carried out in a rotatory pump under vacuum conditions (around 10−5 Pa) for 20 min on a magnetic stirrer. Then, PDMS curing agent was added in 10:1 proportion and manually mixed. Finally, the mixture was placed in the metallic mold previously smeared with a layer of release agent based on polyvinyl alcohol (CASTRO COMPOSITES®) and they were cured in an oven at 125 °C during 20 min, following the indications provided in the commercial PDMS data sheet.

2.3. Nanocomposite Characterization

2.3.1. Microstructural Characterization

The CNT dispersion in the CNT-PDMS mixtures was analyzed by Light Transmitted Optical Microscopy (TOM), prior to the addition of the hardener and, therefore, before the curing step, to analyze the distribution of CNT immediately after the dispersion procedure. The microscope used was a Leica DMR equipped with a camera Nikon Coolpix 990.
Moreover, manufactured nanocomposites were cut with a microtomy blade, and their surfaces were coated with 3 nm of platinum using a sputtering Leica EM ACE200 machine. Surface samples were morphologically analyzed using Field-Emission Gun Scanning Electron Microscopy (FEG-SEM) Nova NanoSEM 230.

2.3.2. Electrical Conductivity

The electrical volume conductivity was measured using a Source Meter Unit (Keithley Instrument Inc. mod. 2410). It was determined by calculating the slope of the current–voltage curve at 0–100 V for 0.25, 0.3, 0.4, and 0.5 wt.% CNTs and at 0–20 V for 0.75 and 1 wt.% CNTs, because of the higher electrical conductivity expected in the last ones. For these experiments, three specimens (60 × 20 × 6 mm3) were tested for each condition. Four electrodes made of copper wire were attached to the nanocomposite specimen using a conductive silver ink to make a four-probe measurement, with the aim of minimizing the contact resistance, as summarized in Figure 1a,b.

2.3.3. Electromechanical Tests of CNT/PDMS Nanocomposites

The strain monitoring capabilities of nanocomposites were evaluated under tensile conditions using a ZWICK universal tensile machine equipped with a load cell of 500 N. At least three tensile specimens of each condition were tested according to ISO 527-1:2019, precisely, at a test rate of 10 mm/min.
Synchronously to this mechanical test, the electrical resistance was measured using an Agilent 34410A module at an acquisition frequency of 10 Hz. For this purpose, two electrodes made of copper wire were placed around the nanocomposite surface near grips, approximately at 80 mm from the central region of the tensile specimen. These electrodes were attached to the nanocomposite using conductive silver ink to minimize the contact resistance, as shown in Figure 1c,d. Due to the hydrophobic nature of PDMS, it is important to note the difficulties related to electrode placement on the surface of nanocomposites. In addition, samples were isolated from the testing machine by applying an adhesive layer at the grips.
A crucial parameter for characterizing the electromechanical capabilities of the proposed sensors is their Gauge Factor (GF), that can be defined as the electrical sensitivity to strain and can be calculated as the variation in the normalized electrical resistance (∆R/R0), divided by the applied strain (ε), as indicated in Equation (1):
G F = Δ R / R 0 ε
Additionally, to study the repeatability of the electrical response of the nanocomposite with the higher GF, which was the sample that contained 0.4 wt.% CNTs dispersed by the US procedure, three tensile specimens were subjected to continuous loading and releasing for 300 cycles up to 2%, 5%, and 10% strain level, at a fixed rate of 30 mm/min.

2.4. Proof of Concept

Finger and elbow movements were monitored as a proof of concept of the developed sensors, with the aim of proving their viability for human motion monitoring applications. For this reason, the nanocomposite with the higher GF (0.4 wt.% CNTs dispersed by US) was cut into strips of 20 × 8 × 1.5 and 60 × 20 × 1.5 mm3 dimensions and fixed on an index finger and on an elbow, respectively, using an adhesive layer. In addition, two copper wire electrodes were attached with silver ink to the ends of the samples to record the electrical response during the proof-of-concept test.

3. Results and Discussion

The electrical and electromechanical capabilities of CNT-PDMS were analyzed, exploring the influence of the dispersion procedure. Then, the applicability of the optimum sensor was proved under consecutive load cycling and with a human monitoring proof-of-concept such as the movements of elbows and fingers to characterize the sensitivity of the developed sensors.

3.1. Electrical Conductivity Measurements

Figure 2 shows the values of electrical conductivity measured for the different CNT contents tested for nanocomposites manufactured using the 3RM and US dispersion procedures.
First, it can be observed, as expected, that the electrical conductivity increases with the increasing CNT content due to the creation of more electrical pathways within the material, ranging from 10−4 at 0.25 wt.% to 3 S/m at 1 wt.%. Here, when comparing the effects of 3RM and US procedures on electrical properties, the following facts can be established.
At lower CNT contents, the electrical conductivity achieved by both dispersion routes is quite similar, reaching a percolation threshold below 0.25 wt.% in both cases. However, when the CNT content is increased above 0.4 wt.% the 3RM technique leads to significantly higher values of electrical conductivity than US. This behavior can be easily explained according to the higher efficacy of the first dispersion route.
In this regard, US is an effective dispersion procedure at low contents since the viscosity of the mixture is also low enough to make the cavitation forces induced during the sonication process more effective [30]. On the other hand, the 3RM procedure promotes the disaggregation of CNTs by the shear forces induced during milling. These shear forces are more prevalent when increasing the viscosity of the mixture [31], leading to a higher dispersion efficiency for higher CNT contents and, thus, promoting a significant increase in the electrical conductivity.
These statements about the influence of the dispersion procedure on the electrical properties of the nanocomposites were also confirmed by analyzing the CNT distribution achieved using Transmission Optical Microscopy (TOM) and Field-Emission Gun Scanning Electron Microscopy (FEG-SEM).
In this regard, Figure 3 summarizes a representative TOM image for each condition. It can be observed that, at lower contents (0.4 wt.%), the US dispersion process promotes a very homogeneous distribution due to the effectiveness discussed above of the cavitation forces in these low viscosity conditions. By increasing the CNT content (above 0.5 wt.%), the 3RM technique leads to much more homogeneous CNT distribution, and decreases, leading to the formation of larger aggregates (highlighted in red in Figure 3). Finally, it can be also stated that, at very high CNT contents (1 wt.%) there is no electrical conductivity in the nanocomposites processed by the 3RM route (there is even a slight decrease compared to the samples of 0.75 wt.% CNT). This can be explained because, although the higher viscosity of this more loaded mixture increases the shear forces, it also induces a breakage of CNTs themselves, leading to a detriment in the electrical properties. In fact, this effect has been widely reported in other studies, where this reduction in the aspect ratio of the nanoparticles has been observed, with the consequent loss of conductivity [32]. The influence of CNT breakdown mechanisms, however, is not as high for the US procedure as the effectiveness of this mechanism is reduced due to increased viscosity, as discussed above.
Figure 4 present FEG-SEM surface images at different magnifications. Here, the trend observed in TOM is corroborated, following the same arguments. On the one hand, nanocomposites with lower contents (0.4 wt.% shown in Figure 4a,b) promote a very homogeneous distribution with US and 3RM, with the absence of larger aggregates, and it is manifested in similar conductivity values with both techniques. On the other hand, nanocomposites with higher contents (0.5 and 0.75 wt.% shown in Figure 4c–f) present a better CNT dispersion with 3RM than US, because larger aggregates can be seen in US samples (especially at low magnifications). Therefore, higher conductivity values are achieved with this technique, as there are more efficient electrical pathways. It is important to highlight that no pull-out phenomena of the CNTs are observed at high magnifications in any of the samples, so there is a good interface between the PDMS and the CNTs.

3.2. Electromechanical Analysis

Therefore, once the electrical properties of the CNT-PDMS nanocomposites have been analyzed following two different dispersion procedures, it is necessary to explore how they affect the strain sensing response of the developed sensors. In this context, Figure 5 summarizes some representative curves of the electromechanical behavior of the CNT-PDMS nanocomposites under tensile load.
First, it can be observed that only the conditions above 0.4 wt.% were successfully tested. This is explained because, although at lower contents the nanocomposites are electrically conductive, as observed in the graph of Figure 2, their conductivity was not high enough to be monitored since the electrical resistance was above the limits of the Agilent device.
When observing the electromechanical curves of Figure 5, it can be realized that the electrical resistance follows a linear-exponential behavior with the applied strain. This fact has been widely reported and it is correlated to the prevalence of tunnelling mechanisms in the electrical network formed in the nanocomposites that, according to the well-known Simmons formula [33], follows a linear-exponential trend with the distance between neighboring nanoparticles.
From these electromechanical curves, it is possible to estimate the nanocomposite’s GF, which is a key factor for strain sensing purposes. In this regard, Figure 6 shows the GF obtained as a function of CNT content for both 3RM and US following dispersion procedures.
Here, it can be observed that the GF increases with decreasing CNT content. It has been also widely reported and it is correlated to the previously mentioned prevalence of tunnelling mechanisms. In this regard, by increasing the CNT content and, thus, the number of nanoparticles, the average distance between particles decreases and, therefore, the exponential variation in the electrical resistance due to tunnelling mechanisms is less prevalent, leading, thus, to lower electrical sensitivities.
On the other hand, when comparing the dispersion procedures, it can be elucidated that the sensitivity is generally higher in nanocomposites processed following the US route, especially for lower CNT contents. This can be explained according to the dispersion state reached in the final nanocomposite.
In this regard, the US technique, as explained above, seems to be a very efficient dispersion method for lower CNT contents, due to the higher prevalence of cavitation forces during the dispersion stage. For this reason, the electrical network reached in the final nanocomposite is much more homogeneous and, thus, much more efficient, leading to a greater prevalence of tunnelling mechanisms, which present a very high sensitivity over the contact and intrinsic ones.
At higher contents, the 3RM process seems to be more efficient as a dispersion procedure so, at a first sight, the electrical sensitivity should be also higher than that obtained by ultrasonication technique. However, the significant differences between the electrical conductivity between the two dispersion routes suggests that the mean interparticle distance is much higher in the CNT network after the US procedure. Therefore, although there is also prevalence of conduction mechanisms through the CNT aggregates, this higher interparticle distance leads to an increase in the electrical resistance due to tunnelling mechanisms and, thus, to the electrical sensitivity of the samples.
The GF values, in every case, are much higher than those found in conventional metallic gauges for strain sensing purposes, which is around 2, especially when monitoring large strains. More specifically, the samples with 0.4 wt.% CNT processed following the US route have a GF of 3 and up to 37, at low and high strain levels, respectively. For this reason, this condition was selected as the optimal one for the development of wearable sensors since it also presents a very high failure strain (~50%).
In this regard, Figure 7 shows the electromechanical response under cycling load. The aim is to prove the repeatability of the electrical response and, thus, the robustness of the proposed sensors. As the sensors will be used for the monitoring of medium and large strains, such as elbow or finger movements, they were tested at a cycling strain of 2%, 5%, and 10% strain. Here, two significant facts can be stated: on the one hand, the sensitivity under cyclic load at medium-high levels is very high, reaching resistance changes up to 50% for 10% strain level, and increases with decreasing CNT content, as expected; on the other hand, the sensitivity of the reported sensors is constant over the entire range of cycles because the change in the electrical resistance (distance between the peak and baseline) remains almost constant for each consecutive cycle. However, the peak and baseline of the electrical resistance decrease with increasing numbers of cycles due to the viscoelastic behavior of PDMS that promotes a delayed mechanical response, as shown in Figure 7c, as well as some irreversibility in the electrical network that may be manifested, especially, in the first stages of the cyclic test. It denotes that the electrical network is fully recovered after applying the load, with the absence of microcracks or plastic deformation and proving, thus, demonstrating that the sensors can be used to reliably detect relatively small strains in a reliable way, without inducing any prevalent damage.
According to the state of the art on strain sensors, there are numerous research works focused on the development of wearable sensors based on CNT-reinforced silicon elastomers, especially with homemade silicone, Ecoflex, or PDMS. Table 2 summarizes the most prominent strain sensors developed in these investigations.
In this regard, in comparison with the sensitivity of the strain sensors in the reported studies, the results obtained in the present work provided significantly higher GF values than sensors manufactured with the similar CNT dispersion methods. It proves the importance of optimizing these dispersion procedures that was analyzed in the first sections of this work. On the other hand, although there are three developed sensors [14,20,23] that clearly exceed the GF values obtained in the present work, they were performed using much more complex and expensive manufacturing methods, such as CVD or laser ablation, than the one used in this study, which is the dispersion by ultrasonication.
The previous results show that the CNT-PDMS strain sensor developed in this research is in a privileged position with respect to the state of the art, considering all the characteristics that these types of sensors must meet, as was demonstrated in this study: high GF, high flexibility, high reproducibility, easy manufacturing, and friendly operation.

3.3. Proof of Concept: Human Motion Monitoring

The potential applications of the developed CNT-PDMS strain sensor for the detection of human body motions were investigated, as shown in Figure 8.
On the one hand, Figure 8a,b shows the monitoring of movement associated with flexion and extension of the index finger. In this regard, when the finger is flexed in the hand, a sudden increase in electrical resistance is detected due to the induced strain field in the attached sensor. This behavior can be explained by the extension of the CNT network, which is mainly subjected to tensile stresses. Subsequently, when the index finger is extended back to the initial position, the electrical resistance decreases to the initial value, due to the recovery of the initial configuration of the nanoparticle electrical network in the sensor PDMS matrix, as shown in Figure 8a. The recovery of the initial resistance denotes that the CNT sensor has not been severely damaged by the stresses generated by the movement of the finger, despite the great elongation associated with its bending. It denotes an adequate flexibility and resistance of the doped resin, responsible for ensuring the stability of the CNT electrical network. Furthermore, the CNT-PDMS sensor shows a response proportional between the level of flexion to which the finger is subjected and the increase in electrical resistance measured, showing great reproducibility and high sensitivity in detecting small movements of the monitored finger.
On the other hand, Figure 8c,d summarizes the electrical response under the bending and stretching movements of the arm. In a similar way as with the movements of the fingers, the greater the level of flexion of the arm, the greater the extension suffered by the network of nanotubes, increasing the tunnel distance between neighboring CNTs. The response to this extension of the network is the proportional increase in electrical resistance measured by the sensor. In every case, the electrical resistance recovers the initial value, indicating, again, that the sensors are not damaged during the elbow motion, even under the most demanding conditions (bending angle of 135°). In addition, Figure 8d shows the electrical response of the sensors when the arm is gradually bent, from an extended position to the maximum bending angle at 135°, ending with the arm being stretched. It can be observed that the electrical resistance increases with the bending angle, as shown previously, and the value remains stable as the bending angle is maintained. Finally, when the arm is stretched again, the electrical resistance returns to its initial value.
Consequently, the results of the proof-of-concept prove an outstanding robustness of the sensors for human motion monitoring and could open a number of applications of CNT-PDMS materials, manufactured in an easy and scalable way for these kinds of applications.

4. Conclusions

An easy-scalable flexible strain sensor based on CNT-reinforced PDMS was proposed for human motion monitoring.
The analysis of the dispersion procedure shows that the samples manufactured by the US technique show a higher electrical sensitivity than those manufactured by 3RM. This is explained by the homogeneous distribution achieved by US due to the prevalence of aggressive cavitation forces for the disaggregation of larger agglomerates, leading to a prevalence of tunnelling mechanisms. In addition, by increasing the CNT content there is a significant decrease in the sensitivity, as the interparticle distance is decreased due to the larger number of nanoparticles. In every case, the values of the gauge factor (3–37) clearly exceeded those found for metallic conventional gauges.
The analysis of the dispersion procedure shows that the samples manufactured by the US technique show a higher electrical sensitivity than those manufactured by 3RM. This is explained by the homogeneous distribution achieved by US due to the prevalence of aggressive cavitation forces for the disaggregation of larger agglomerates, leading to a prevalence of tunnelling mechanisms.
Based on this analysis, the optimum conditions for the manufacturing of the wearable sensors were selected as 0.4 wt.% CNT by means of an ultrasonication process. In this regard, an analysis of the electrical response under consecutive load cycles showed a high robustness of the developed sensors, without any presence of damage at 2, 5, and 10% strain, which make these sensors reliable for monitoring medium strain.
For these reasons, the optimized strain sensor is in a privileged position with respect to the state-of-the-art, considering all the characteristics that this type of sensor must meet: high GF, high flexibility, high reproducibility, easy manufacturing, and friendly operation
Finally, a proof-of-concept of human motion monitoring was carried out by placing a sensor on a finger and elbow. The electrical response during the bending and stretching of both the finger and elbow shows a reliable response with an increase in the electrical resistance with bending angle and a total recovery after stretching.
Therefore, these preliminary results show the huge potential of the proposed materials as wearable skin-mounted sensors for human motion monitoring as they are manufactured in an easy-scalable way and report a robust electrical behavior.

Supplementary Materials

The following supporting information can be downloaded at: https://www.mdpi.com/article/10.3390/s22145147/s1, Figure S1: Dispersion state of CNT/PDMS at different sonication times.

Author Contributions

Conceptualization, A.d.B. and X.F.S.-R.; data curation, A.d.B.; formal analysis, A.d.B. and X.F.S.-R.; funding acquisition, M.S. and A.U.; investigation, A.d.B. and X.F.S.-R.; methodology, A.d.B. and X.F.S.-R.; writing—original draft, A.d.B. and X.F.S.-R.; writing—review and editing, M.S. and A.U. All authors have read and agreed to the published version of the manuscript.

Funding

This work was supported by the Agencia Estatal de Investigación of Spanish Government (Project MULTIFUNC-EVs PID2019-107874RB-I00) and Comunidad de Madrid Government (Project ADITIMAT-CM (S2018/NMT-4411)).

Institutional Review Board Statement

Not applicable.

Informed Consent Statement

Informed consent was obtained from all subjects involved in the study.

Data Availability Statement

The data presented in this study are available on request from the corresponding authors.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Irfan, M.; Khan, T.; Hussain, T.; Liao, K.; Umer, R. Carbon coated piezoresistive fiber sensors: From process monitoring to structural health monitoring of composites—A review. Compos. Part A Appl. Sci. Manuf. 2021, 141, 106236. [Google Scholar] [CrossRef]
  2. Tuloup, C.; Harizi, W.; Aboura, Z.; Meyer, Y.; Khellil, K.; Lachat, R. On the use of in-situ piezoelectric sensors for the manufacturing and structural health monitoring of polymer-matrix composites: A literature review. Compos. Struct. 2019, 215, 127–149. [Google Scholar] [CrossRef]
  3. Sánchez-Romate, X.F.; García, C.; Rams, J.; Sánchez, M.; Ureña, A. Structural health monitoring of a CFRP structural bonded repair by using a carbon nanotube modified adhesive film. Compos. Struct. 2021, 270, 114091. [Google Scholar] [CrossRef]
  4. Sánchez-Romate, X.F.; Coca, Á.; Jiménez-Suárez, A.; Sánchez, M.; Ureña, A. Crack sensing mechanisms of Mode-II and skin-stringer joints between dissimilar materials by using carbon nanotubes. Compos. Sci. Technol. 2021, 201, 108553. [Google Scholar] [CrossRef]
  5. Esmaeili, A.; Sbarufatti, C.; Ma, D.; Manes, A.; Jiménez-Suárez, A.; Ureña, A.; Dellasega, D.; Hamouda, A. Strain and crack growth sensing capability of SWCNT reinforced epoxy in tensile and mode I fracture tests. Compos. Sci. Technol. 2020, 186, 107918. [Google Scholar] [CrossRef]
  6. Del Bosque, A.; Sánchez-Romate, X.F.; Sánchez, M.; Ureña, A. Wearable Sensors Based on Graphene Nanoplatelets Reinforced Polydimethylsiloxane for Human Motion Monitoring: Analysis of Crack Propagation and Cycling Load Monitoring. Chemosensors 2022, 10, 75. [Google Scholar] [CrossRef]
  7. Nonn, S.; Schagerl, M.; Zhao, Y.; Gschossmann, S.; Kralovec, C. Application of electrical impedance tomography to an anisotropic carbon fiber-reinforced polymer composite laminate for damage localization. Compos. Sci. Technol. 2018, 160, 231–236. [Google Scholar] [CrossRef]
  8. Hao, F.; Wang, S.; Xing, F.; Li, M.; Li, T.; Gu, Y.; Zhang, W.; Zhang, J. Carbon-Nanotube-Film-Based Electrical Impedance Tomography for Structural Damage Detection of Carbon-Fiber-Reinforced Composites. ACS Appl. Nano Mater. 2021, 4, 5590–5597. [Google Scholar] [CrossRef]
  9. Li, J.; Fang, L.; Sun, B.; Li, X.; Kang, S.H. Review—Recent Progress in Flexible and Stretchable Piezoresistive Sensors and Their Applications. J. Electrochem. Soc. 2020, 167, 037561. [Google Scholar] [CrossRef]
  10. Nguyen, T.; Dinh, T.; Phan, H.-P.; Pham, T.A.; Dau, V.T.; Nguyen, N.-T.; Dao, D.V. Advances in ultrasensitive piezoresistive sensors: From conventional to flexible and stretchable applications. Mater. Horizons 2021, 8, 2123–2150. [Google Scholar] [CrossRef]
  11. Del Bosque, A.; Sánchez-Romate, X.; Sánchez, M.; Ureña, A. Flexible Wearable Sensors Based in Carbon Nanotubes Reinforced Poly(Ethylene Glycol) Diglycidyl Ether (PEGDGE): Analysis of Strain Sensitivity and Proof of Concept. Chemosensors 2021, 9, 158. [Google Scholar] [CrossRef]
  12. Homayounfar, S.Z.; Andrew, T.L. Wearable Sensors for Monitoring Human Motion: A Review on Mechanisms, Materials, and Challenges. SLAS Technol. Transl. Life Sci. Innov. 2019, 25, 9–24. [Google Scholar] [CrossRef]
  13. Cohen, D.J.; Mitra, D.; Peterson, K.; Maharbiz, M.M. A Highly Elastic, Capacitive Strain Gauge Based on Percolating Nanotube Networks. Nano Lett. 2012, 12, 1821–1825. [Google Scholar] [CrossRef]
  14. Lee, J.; Pyo, S.; Kwon, D.-S.; Jo, E.; Kim, W.; Kim, J. Ultrasensitive Strain Sensor Based on Separation of Overlapped Carbon Nanotubes. Small 2019, 15, 1805120. [Google Scholar] [CrossRef]
  15. Lipomi, D.J.; Vosgueritchian, M.; Tee, B.C.K.; Hellstrom, S.L.; Lee, J.A.; Fox, C.H.; Bao, Z. Skin-like pressure and strain sensors based on transparent elastic films of carbon nanotubes. Nat. Nanotechnol. 2011, 6, 788–792. [Google Scholar] [CrossRef]
  16. Amjadi, M.; Yoon, Y.J.; Park, I. Ultra-stretchable and skin-mountable strain sensors using carbon nanotubes–Ecoflex nanocomposites. Nanotechnology 2015, 26, 375501. [Google Scholar] [CrossRef]
  17. Mai, H.; Mutlu, R.; Tawk, C.; Alici, G.; Sencadas, V. Ultra-stretchable MWCNT–Ecoflex piezoresistive sensors for human motion detection applications. Compos. Sci. Technol. 2019, 173, 118–124. [Google Scholar] [CrossRef]
  18. Cai, L.; Song, L.; Luan, P.; Zhang, Q.; Zhang, N.; Gao, Q.; Zhao, D.; Zhang, X.; Tu, M.; Yang, F.; et al. Super-stretchable, Transparent Carbon Nanotube-Based Capacitive Strain Sensors for Human Motion Detection. Sci. Rep. 2013, 3, 3048. [Google Scholar] [CrossRef] [Green Version]
  19. Yamada, T.; Hayamizu, Y.; Yamamoto, Y.; Yomogida, Y.; Izadi-Najafabadi, A.; Futaba, D.N.; Hata, K. A stretchable carbon nanotube strain sensor for human-motion detection. Nat. Nanotechnol. 2011, 6, 296–301. [Google Scholar] [CrossRef]
  20. Tas, M.O.; Baker, M.A.; Masteghin, M.G.; Bentz, J.; Boxshall, K.; Stolojan, V. Highly Stretchable, Directionally Oriented Carbon Nanotube/PDMS Conductive Films with Enhanced Sensitivity as Wearable Strain Sensors. ACS Appl. Mater. Interfaces 2019, 11, 39560–39573. [Google Scholar] [CrossRef]
  21. Lee, J.; Lim, M.; Yoon, J.; Kim, M.S.; Choi, B.; Kim, D.M.; Kim, D.H.; Park, I.; Choi, S.-J. Transparent, Flexible Strain Sensor Based on a Solution-Processed Carbon Nanotube Network. ACS Appl. Mater. Interfaces 2017, 9, 26279–26285. [Google Scholar] [CrossRef]
  22. Zhang, R.; Ying, C.; Gao, H.; Liu, Q.; Fu, X.; Hu, S. Highly flexible strain sensors based on polydimethylsiloxane/carbon nanotubes (CNTs) prepared by a swelling/permeating method and enhanced sensitivity by CNTs surface modification. Compos. Sci. Technol. 2019, 171, 218–225. [Google Scholar] [CrossRef]
  23. Huang, K.; Ning, H.; Hu, N.; Liu, F.; Wu, X.; Wang, S.; Liu, Y.; Zou, R.; Yuan, W.; Alamusi; et al. Ultrasensitive MWCNT/PDMS composite strain sensor fabricated by laser ablation process. Compos. Sci. Technol. 2020, 192, 108105. [Google Scholar] [CrossRef]
  24. Kumar, V.; Lee, G.; Choi, J.; Lee, D.-J. Studies on composites based on HTV and RTV silicone rubber and carbon nanotubes for sensors and actuators. Polymer 2020, 190, 122221. [Google Scholar] [CrossRef]
  25. Wang, X.; Li, J.; Song, H.; Huang, H.; Gou, J. Highly Stretchable and Wearable Strain Sensor Based on Printable Carbon Nanotube Layers/Polydimethylsiloxane Composites with Adjustable Sensitivity. ACS Appl. Mater. Interfaces 2018, 10, 7371–7380. [Google Scholar] [CrossRef]
  26. Gao, Y.; Fang, X.; Tan, J.; Lu, T.; Pan, L.; Xuan, F.-Z. Highly sensitive strain sensors based on fragmentized carbon nanotube/polydimethylsiloxane composites. Nanotechnology 2018, 29, 235501. [Google Scholar] [CrossRef]
  27. Del Bosque, A.; Sánchez-Romate, X.F.; Sánchez, M.; Ureña, A. Ultrasensitive and highly stretchable sensors for human motion monitoring made of graphene reinforced polydimethylsiloxane: Electromechanical and complex impedance sensing performance. Carbon 2022, 192, 234–248. [Google Scholar] [CrossRef]
  28. Sánchez-Romate, X.F.; Artigas, J.; Jiménez-Suárez, A.; Sánchez, M.; Güemes, A.; Ureña, A. Critical parameters of carbon nanotube reinforced composites for structural health monitoring applications: Empirical results versus theoretical predictions. Compos. Sci. Technol. 2018, 171, 44–53. [Google Scholar] [CrossRef]
  29. Jiménez-Suárez, A.; Campo, M.; Sánchez, M.; Romón, C.; Ureña, A. Influence of the functionalization of carbon nanotubes on calendering dispersion effectiveness in a low viscosity resin for VARIM processes. Compos. Part B Eng. 2012, 43, 3482–3490. [Google Scholar] [CrossRef]
  30. Sánchez-Romate, X.F.; Sans, A.; Jiménez-Suárez, A.; Campo, M.; Ureña, A.; Prolongo, S.G. Highly Multifunctional GNP/Epoxy Nanocomposites: From Strain-Sensing to Joule Heating Applications. Nanomaterials 2020, 10, 2431. [Google Scholar] [CrossRef] [PubMed]
  31. Sánchez-Romate, X.F.; Jiménez-Suárez, A.; Sánchez, M.; Güemes, A.; Ureña, A. Novel approach to percolation threshold on electrical conductivity of carbon nanotube reinforced nanocomposites. RSC Adv. 2016, 6, 43418–43428. [Google Scholar] [CrossRef]
  32. Hennrich, F.; Krupke, R.; Arnold, K.; Stütz, J.A.R.; Lebsedkin, S.; Koch, T.; Schimmel, T.; Kappes, M.M. The Mechanism of Cavitation-Induced Scission of Single-Walled Carbon Nanotubes. J. Phys. Chem. B 2007, 111, 1932–1937. [Google Scholar] [CrossRef] [PubMed]
  33. Simmons, J.G. Generalized Formula for the Electric Tunnel Effect between Similar Electrodes Separated by a Thin Insulating Film. J. Appl. Phys. 1963, 34, 1793. [Google Scholar] [CrossRef] [Green Version]
Figure 1. Scheme and real specimens for (a,b) electrical conductivity and (c,d) electromechanical tests.
Figure 1. Scheme and real specimens for (a,b) electrical conductivity and (c,d) electromechanical tests.
Sensors 22 05147 g001
Figure 2. Electrical conductivity measurements for 3RM and US techniques as a function of CNT content.
Figure 2. Electrical conductivity measurements for 3RM and US techniques as a function of CNT content.
Sensors 22 05147 g002
Figure 3. TOM images of the CNT-PDMS mixtures as a function of nanoparticle content and dispersion procedure. The areas highlighted in red denote the presence of larger CNT aggregates.
Figure 3. TOM images of the CNT-PDMS mixtures as a function of nanoparticle content and dispersion procedure. The areas highlighted in red denote the presence of larger CNT aggregates.
Sensors 22 05147 g003
Figure 4. FEG-SEM images of the CNT-PDMS nanocomposites at (a,b) 0.4, (c,d) 0.5, and (e,f) 0.75 wt.% CNT as a function of dispersion procedure (US and 3RM). The left, center, and right images are at 70, 1000, and 40,000 magnifications, respectively. The areas highlighted in red denote the presence of larger CNT aggregates.
Figure 4. FEG-SEM images of the CNT-PDMS nanocomposites at (a,b) 0.4, (c,d) 0.5, and (e,f) 0.75 wt.% CNT as a function of dispersion procedure (US and 3RM). The left, center, and right images are at 70, 1000, and 40,000 magnifications, respectively. The areas highlighted in red denote the presence of larger CNT aggregates.
Sensors 22 05147 g004aSensors 22 05147 g004b
Figure 5. Strain monitoring curves of the CNT-PDMS sensors for the different manufacturing conditions and CNT contents: (a) 0.4 (b) 0.5, (c) 0.75, and (d) 1.0 wt.%.
Figure 5. Strain monitoring curves of the CNT-PDMS sensors for the different manufacturing conditions and CNT contents: (a) 0.4 (b) 0.5, (c) 0.75, and (d) 1.0 wt.%.
Sensors 22 05147 g005
Figure 6. GF values obtained for (a) US and (b) 3RM CNT dispersion routes as a function of CNT content.
Figure 6. GF values obtained for (a) US and (b) 3RM CNT dispersion routes as a function of CNT content.
Sensors 22 05147 g006
Figure 7. Cycling response of the 0.4 wt.% CNTs sensor by ultrasonication at 10%, 5%, and 2% strain levels. (a) Electrical response under 300 cycles; (b) detail of the first 5 cycles of the electrical response; and (c) mechanical response under 300 cycles.
Figure 7. Cycling response of the 0.4 wt.% CNTs sensor by ultrasonication at 10%, 5%, and 2% strain levels. (a) Electrical response under 300 cycles; (b) detail of the first 5 cycles of the electrical response; and (c) mechanical response under 300 cycles.
Sensors 22 05147 g007
Figure 8. Electrical response to human motion monitoring when (a,b) finger and (c,d) elbow bending–holding.
Figure 8. Electrical response to human motion monitoring when (a,b) finger and (c,d) elbow bending–holding.
Sensors 22 05147 g008aSensors 22 05147 g008b
Table 1. Process conditions for three roll milling dispersion at room temperature.
Table 1. Process conditions for three roll milling dispersion at room temperature.
CycleFirst Roll Gap (μm)Last Roll Gap (μm)
112040
27525
34515
4–7155
Table 2. The sensitivity and CNT dispersion/deposition method of strain sensors.
Table 2. The sensitivity and CNT dispersion/deposition method of strain sensors.
Silicone MatrixCNT Dispersion or Deposition MethodSensitivity
(Gauge Factor)
Ref.
SiliconeUS0.99[13]
EcoflexCVD42,300[14]
EcoflexSpray coating3.5[15]
EcoflexSpray coating2[16]
EcoflexUltrasound bath0.1–0.4[17]
PDMSCVD0.97[18]
PDMSCVD1.5[19]
PDMSCVD100[20]
PDMSSpray coating6.7[21]
PDMSSwelling/permeating2–12[22]
PDMSLaser ablation512.2[23]
PDMSStirring manually2.5[24]
PDMSUltrasound bath35.75[25]
PDMSUS0.98[26]
PDMSUS3–37This work
Publisher’s Note: MDPI stays neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Share and Cite

MDPI and ACS Style

del Bosque, A.; Sánchez-Romate, X.F.; Sánchez, M.; Ureña, A. Easy-Scalable Flexible Sensors Made of Carbon Nanotube-Doped Polydimethylsiloxane: Analysis of Manufacturing Conditions and Proof of Concept. Sensors 2022, 22, 5147. https://doi.org/10.3390/s22145147

AMA Style

del Bosque A, Sánchez-Romate XF, Sánchez M, Ureña A. Easy-Scalable Flexible Sensors Made of Carbon Nanotube-Doped Polydimethylsiloxane: Analysis of Manufacturing Conditions and Proof of Concept. Sensors. 2022; 22(14):5147. https://doi.org/10.3390/s22145147

Chicago/Turabian Style

del Bosque, Antonio, Xoan F. Sánchez-Romate, María Sánchez, and Alejandro Ureña. 2022. "Easy-Scalable Flexible Sensors Made of Carbon Nanotube-Doped Polydimethylsiloxane: Analysis of Manufacturing Conditions and Proof of Concept" Sensors 22, no. 14: 5147. https://doi.org/10.3390/s22145147

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop