Search Results (41)

The aim of this study was to evaluate the effect of marinade type and marinating time on the physicochemical and sensory properties of pork tenderloin cooked using low-temperature, vacuum-sealed cooking. The study included marinades based on pineapple juice, red wine, kefir and a mixture of dried herbs. The assessment of the effect of marinades was based on the analysis of the color, texture, chemical composition and organoleptic properties of the meat after cooking using the sous vide method. In the experimental part, instrumental determinations of color and texture, analysis of the chemical composition and sensory assessment of the meat were carried out. Marinating for 12 h in red wine and dry marinating causes darkening of the meat. The hardness of meat marinated after 2 h increased compared to the control group; similar relationships were observed for gumminess and chewiness. However, after 12 h of marinating, the hardness of cycle 1 and hardness of cycle 2, as well as chewiness and gumminess, were significantly reduced below the level of the characteristics for the control group, except for the meat marinated in wine. Meat marinated in red wine and using the dry method received higher scores, while longer marinating resulted in more favorable scores. Full article

The rapid growth and high nutrient density in modern broiler production have led to issues like woody breast myopathy (WBM), footpad dermatitis, and fat accumulation, affecting welfare and profitability. This study evaluated the effects of amino acid (AA) and apparent metabolizable energy (AME) reductions on organ development, carcass yield, WBM incidence, and economic returns in Cobb 700 and Ross 708 broilers. Two trials were conducted, one per strain, using a factorial design with 12 treatments (four AA × three AME). Each trial included 864 broilers, randomly assigned to six replicate blocks, with 12 pens per block (six males and six females per pen). Diets contained 70%, 80%, 90%, or 100% of digestible AA and 84%, 92%, or 100% AME based on breeder recommendations. A 30% AA reduction increased fat pad weight, promoted proventriculus and jejunum development (day 58), reduced carcass and tenderloin weights, lowered moderate/severe WBM incidence (day 47), and shortened footpad dermatitis. A 16% AME reduction decreased fat pad weight, improved muscle production and returns, but reduced normal breast percentage (days 40 and 47). The recommended protein–energy ratio (g/MJ) for optimal economic returns was as follows: 19.78 (0–10 d), 17.51 (11–24 d), 16.03 (25–39 d), and 15.25 (40–63 d). Full article

In this study, the effects of crust formation were investigated on the quality properties of pork meat, including texture, colour, cooking loss, pH, water-holding capacity (WHC), and sensory attributes. Two cuts of pork, (1) tenderloin (lean) and (2) collar (fatty), were subjected to three treatments as follows: (1) crusting before cooking, (2) crusting after cooking, and (3) cooking without crusting. Texture was analyzed measuring hardness, cohesiveness, springiness, and chewiness. Colour was analyzed measuring lightness, redness–greenness, yellowness–blueness, and hue angle. Cooking loss and pH and WHC were measured using standard methods and a pressing test. Results showed that meat type and treatment significantly impacted texture, with tenderloin exhibiting greater hardness and chewiness than collar (p = 0.05). Crusting after cooking produced the highest values for hardness and chewiness, while cohesiveness and springiness were unaffected by treatment (p = 0.05). Colour measurements revealed significant treatment-induced differences, with samples crusted after cooking being darker and redder, on average 14% and 33%, respectively. Cooking loss varied considerably, with no significant treatment differences, although a trend suggested lower loss in samples crusted before cooking. pH values were slightly higher in crusted samples, while WHC was notably higher for samples crusted after cooking, likely due to oil retention. Full article

This study aimed to investigate the flavor formation and meat quality differences among different beef cuts in Chinese Wagyu cattle. The metabolites and gene expression profiles of chuck, neck, rump, tenderloin, and longissimus lumborum cuts were analyzed. The results revealed that a total of 240 volatile organic compounds and 779 lipid molecules were detected among the beef cuts, with hydrocarbons (accounting for 29.71%) and triglycerides (representing 41.21%) emerging as the most prominent compounds, respectively. The sensory-directed analysis highlighted the significance of sweet and fruity aroma compounds, which contributed to the distinct aroma profiles among different beef cuts. Additionally, a total of 60 key lipid molecular markers, including FA(18:1), PC(40:5), TG(18:0_16:1_18:1), and TG(36:0_18:1), etc., were identified as playing crucial roles in the generation of essential lipid compounds across five different beef cuts. Integrative analysis of multi-omics data pinpointed a cluster of differentially expressed genes (e.g., DLD, ACADM, PCCA, SCD), which were involved in the regulation of valine, leucine, and isoleucine degradation pathways and lipid metabolism. Taken together, this study has identified key metabolites and candidate genes influencing meat quality across different beef cuts, providing a valuable resource for the molecular breeding of high-quality traits in beef cattle. Full article

Near-infrared spectroscopy (NIRS) was evaluated to trace the high hydrostatic pressure (HHP) processing and preservation temperature (4 °C vs. 20 °C) over the course of a long term in vacuum-packaged Iberian dry-cured tenderloin (Iliopsoas et psoas minor). Spectra were obtained from a total of 298 samples, without opening the package, using a handheld MicroNIR^TM 1700 OnSite-W microspectrophotometer (908.1 nm–1676.2 nm) (VIAVI Solutions Inc., United States). The discriminant models were developed by means of partial least squares-discriminant analysis (PLS-DA). The models obtained were capable of correctly classifying more than 60% of the samples according to their HHP processing, while almost 100% of the samples were correctly classified according to the temperature at which the samples were preserved. Thus, NIRS could help to support the traceability of treatments that represent a high added value to the product, such as HHP in premium Iberian dry-cured products. Full article

This study analyzed the nutritional composition, physicochemical properties, and volatile profiles of three major bovine head muscles—medial pterygoid, masseter, and buccinator—to reduce byproduct resource waste and increase the utilization rate of bovine head to establish a foundation for its industrial use. Compared to tenderloin, which is popular among consumers, these head muscles were found to be rich in collagen (4.90–13.1 mg/g), low in fat (0.39–1.61%), and abundant in free amino acids (143.93–223.00 mg/100 g). Their compact fiber structures, with minimal gaps between myocytes, resulted in lower cooking and press losses, making them suitable for various production processes. Notably, the medial pterygoid and masseter muscles contained high levels of polyunsaturated fatty acids (PUFAs) and lower saturated fatty acids (SFAs), with a PUFA/SFA ratio exceeding 0.45. The buccinator muscle, while containing more volatile organic compounds associated with undesirable odors and bitter amino acids, was not indicative of spoilage. Overall, this study confirmed that bovine head muscles possess high collagen, low fat, and diverse nutritional qualities, making them suitable as premium raw materials for value-added meat products, and their returns will be most economically equal to the meat derived from cattle. Full article

The objective of this study is to develop a universally applicable approach for establishing the optimal dose range for the irradiation of plant and animal products. The approach involves the use of the optimization function for establishing the optimal irradiation dose range for each category of plant and animal product to maximize the suppression of targeted pathogens while preserving the surrounding molecules and biological structures. The proposed function implies that pathogens found in the product can be efficiently suppressed provided that irradiation is performed with the following criteria in mind: a high irradiation dose uniformity, a high probability of irradiation hitting pathogens and controlled heterogeneity of radiobiological sensitivity of pathogens. This study compares the optimal dose ranges for animal and plant products using beef tenderloin and seed potato tubers as examples. In a series of experiments, our team traced the dose dependencies of myoglobin oxidation in beef and the amount of potential damage to albumin’s native structure. The behavior patterns of myoglobin derivatives and the amount of potential damage to albumin found in this study determined the optimal dose range, which appeared to be wider for beef irradiation compared to that for seed potato tubers, as they do not require uniform irradiation of the entire volume since targeted phytopathogens are predominantly found within the surface layers of the tubers. The use of proprietary methods involving spectrophotometry and high-performance liquid chromatography–mass spectrometry provides a novel perspective on the quantitative assessment of the myoglobin oxidation level and the potential damage to albumin’s native structure. Full article

The aim of this research was to determine the feasibility of sustainable chicken meat production, using good- and low-quality raw material and two different devices (own construction—OC, and a Dutch company’s—DC) for electrical stunning at the slaughter stage. A statistical analysis was also performed to indicate which of the analyzed courses of action is the most important for the company to maintain a balance between the quality of produced meat (pH, number of hemorrhages—small and large, defectiveness, and color on the external and internal surfaces of the fillet and tenderloin), and environmental and economic aspects. It has been shown that the use of device OC for stunning poultry compared to the device DC has a positive effect on: (1) reducing the number of hemorrhages on the outer surface and inside of the fillet—mainly large hemorrhages, (2) increasing by ~50% the share of production of fillets without hemorrhages, and (3) brightening and unifying the color of the external and internal surfaces of the fillet and tenderloin. Taking the above into account, it was concluded that the goals of sustainable chicken meat production depend mainly on the type of stunning device used; therefore, it is recommended to replace the Dutch device (DC) currently used in the plant with an innovative device (OC). It is also recommended to use financial tools when concluding contracts with poultry breeders so that meat producers can implement the goals of the sustainable management policy already at the raw material stage. Full article

In order to investigate the nutritional processing quality of sika deer (Cervus nippon) venison at different sites, the pH_{24 h}, tenderness, pressurized water loss rate, meat color, intramuscular fat, moisture, protein, amino acid, fatty acid and squalene contents of sika deer venison were determined in twelve sites: foreleg, hind leg, outer tenderloin, rump, neck meat, chest meat, deer flank, abdominal rib, high rib, tenderloin, anterior tendon and posterior tendon. The results showed that the pH_{24 h} of sika deer venison at different sites was 5.49~5.78; the tenderness of outer tenderloin (31.71 N) was the lowest, and the neck meat (68.53 N) was the highest; the squeezing moisture of tenderloin (28.12%) was the largest, and the foreleg (12.34%) was the smallest; the brightness of outer tenderloin L* (29.68) was the lowest, and the redness a* and yellowness b* of deer flank were the highest; the intramuscular fat and moisture were 0.66~4.97% and 71.00~73.78%, respectively; and the protein content of outer tenderloin (23.44%) and rump (24.02%) was high. The venison meat contained 17 kinds of amino acids, and the total amount was 63.87~79.33 g/100 g. It was rich in essential amino acids, mainly lysine and leucine, accounting for 64.29~65.39% of non-essential amino acids, which was close to the ideal protein composition. Palmitoleic acid and oleic acid were the main monounsaturated fatty acids in venison, and the contents of abdominal ribs were the highest, 16,875.33 mg/kg and 31,772.73 mg/kg, respectively. The contents of essential fatty acids were also the highest in abdominal ribs (11,225.37 mg/kg); forelegs, hind legs, outer tenderloins, rumps, neck meat, chest meat, high rib, tenderloins, anterior tendons and posterior tendons were all good sources of polyunsaturated fatty acids. Squalene content was highest in the abdominal rib (100.85 mg/kg). The nutritional processing quality of sika deer venison in different muscles is significantly different, and this study can provide a data basis for the evaluation and processing of sika deer venison quality. Full article

Grilling has become a widespread method of thermal food processing. However, food prepared in this way may be a source of carcinogenic organic compounds, such as polycyclic aromatic hydrocarbons (PAHs). The present study aimed to evaluate the impact of different marinades and grilling tools on PAH contamination of chicken breast tenderloins. Together with the determination of PAHs carried out using the QuEChERS–HPLC–FLD/DAD method, the meat’s weight loss after the thermal process and the color of raw and grilled samples were analyzed. Statistically, the highest levels of PAH contamination were found in samples prepared on a charcoal grill without a tray, whereas the lowest were seen using the ceramic contact grill. Meat marination showed that universal and chicken marinades can be barriers against PAHs. Following requirements set in Commission Regulation (EU) No. 915/2023, none of the analyzed samples exceeded the maximum allowable level for B[a]P (5.0 µg/kg) and the sum of four marker-heavy PAHs (30.0 µg/kg). Thus, preparing meat before the thermal process, including marinades rich in phenolic compounds, and selecting a grilling method with appropriate grilling tools can ensure food safety and effectively reduce PAH contamination in grilled poultry meat. Full article

Nutrient composition data that accurately represent available beef products are critical to understanding beef’s role in healthy dietary patterns. The quality of beef products has changed over the past several decades, and updated nutrient data are warranted as USDA Prime beef cuts become more available. In an effort to provide a complete nutrient profile for frequently purchased USDA Prime beef cuts, five USDA Prime cuts; strip loin steak, tenderloin steak, ribeye steak, top sirloin steak, and rib roast were collected from retail stores in six geographical locations over three collections for macro- and micronutrient analysis in both the raw and cooked state. The separable lean portion of all analyzed USDA Prime cuts qualified as a good or excellent source, providing 10–19% or at least 20% of the daily value, respectively, for protein, niacin, vitamin B12, selenium, phosphorus, and zinc per FDA labeling claim standards. There was not a significant difference in cholesterol content between any of the cuts, raw or cooked (p ≥ 0.44 and 0.34, respectively). The percent lipid in raw, separable lean portions of the rib roast and strip loin steak was significantly greater than the lipid portion in tenderloin and top sirloin steaks (p ≤ 0.01). Per USDA standards, the separable lean portions of tenderloin steak and top sirloin steak qualify as lean beef, containing less than 10 g total fat, less than 4.5 g saturated fat, and less than or equal to 95 mg cholesterol. The current study provides the most up-to-date nutrient analysis for USDA Prime beef cuts, helping consumers and health professionals better identify the role of high-quality beef cuts in healthy dietary patterns. Full article

The objective of this study was to prepare zein–gum Arabic nanocapsules with rosehip oil (NC-RH), apply them to pork tenderloin, and analyze the changes in collagen structure under different conditions (pH 6.5 and 4.0) and temperatures (25 °C and 4 °C). NC-RHs were prepared using the nanoprecipitation method. Nanocapsules had a particle size of 423 ± 4.1 nm, a polydispersity index of 0.125 ± 3.1, a zeta potential value of −20.1 ± 0.41 mV, an encapsulation efficiency of 75.84 ± 3.1%, and backscattering (ΔBS = 10%); the antioxidant capacity of DPPH was 1052 ± 4.2 µM Eq Trolox and the radical scavenging capacity was 84 ± 0.4%. The dispersions exhibited Newtonian behavior at 25 °C and 4 °C. Incorporating NC-RH into acid marination benefited the tenderness, water-holding capacity, and collagen swelling, and favored changes in myofibrillar proteins corroborated with histological tests. The conditions with the best changes in pork tenderloin were a pH of 4.0 at 4 °C with an NC-RH-administered 11.47 ± 2.2% collagen area. Incorporating rosehip nanocapsules modifies collagen fibers and can be applied in pork marinades to increase the shelf life of a functional product. Full article

Fresh pork tenderloin was stored at −3 °C under different static magnetic fields (SMF) of 0, 4, and 10 mT (control, MF-4, and MF-10) to investigate their physicochemical properties changes during storage of 8 days. The initial equilibrium temperature of the samples stored with 4 mT MF was found to be −2.3 °C, which was slightly lower (0.3 °C) than that the control value. The super-chilling phenomenon on the pork was then observed, as the samples stored under the magnetic field did not freeze throughout storage period, but the control experienced a sudden change in temperature after 138 h and then froze. The preservation effect of MF-4 on meat quality was the best in all treatment groups. MF-4 achieved a higher water-retention rate, with drip and cook losses of 6.5% and 29.0% lower than the control, respectively. Meanwhile, the MF-4 effectively delayed the color change in the meat during the storage and the texture hardening after cooking, and effectively controlled the growth of the total volatile saline nitrogen content on the samples. In addition, MF-4 delayed the reduction in myofibrillar protein solubility, sulfhydryl content, and emulsification capacity, indicating that this field inhibited the denaturation of myofibrillar protein. This study can be considered as an application reference of magnetic fields during meat storage at a super-chilled temperature. Full article

Volatile compounds and physicochemical properties of meat are significantly changed by cooking processes. This study explored the influence of different stir-frying temperatures and times on the dynamic changes of the physicochemical characteristics and volatiles of pork tenderloin and determined the correlation between them. Results showed that time played more of a role than temperature. At the same temperature, the water content decreased (p < 0.05) and the cooking loss increased (p < 0.05) with stir-frying time extending. The L* value and the b* value showed first an increasing and then decreasing trend (p < 0.05), while the a* value significantly increased (p < 0.05). The higher the cooking temperature of sample, the faster the indexes changed. In stir-fried samples, 50 volatiles were identified. Correlation analysis showed that among the quality attributes, b* value and water content had the strongest impact on volatiles. The water content was negatively correlated with most of the compounds attributed to the desired aroma of stir-fried samples, while the correlation between the b* value and these volatiles was positive. Hence, changes in the types and contents of volatiles in stir-fried pork tenderloin could be predicted by detection of b* value and water content. Full article

Sous-vide is a process comprising vacuum-sealing food, heating it to the desired temperature, and circulating it in a water bath in a sous vide machine. This cooking technique is increasingly common in homes and catering establishments due to its simplicity and affordability. However, manufacturers and chef’s recommendations for low-temperature and long-term sous-vide cooking in media raise food safety concerns, particularly when preparing beef tenderloin. In this study, Salmonella enterica was found to be inactivated by heat and sage essential oil (EO) in beef samples from musculus psoas major that had been sous vide processed. To determine whether heat treatment was likely to increase the sous vide efficiency, S. enterica and sage EO were mixed. After being vacuum-packed and injected with S. enterica, the samples were cooked at 50–65 °C through the sous vide technique for the prescribed time. On days 1, 3, and 6, the amounts of S. enterica, total bacteria, and coliform bacteria were measured in the control and treated groups of beef processed sous vide. Mass spectrometry was used to identify bacterial isolates on different days. On each day that was measured, a higher number of all the microbiota was found in the samples exposed to 50 °C for 5 min. The most frequently isolated microorganisms from both groups of samples were Pseudomonas fragi (17%), Pseudomonas cedrina (8%), and Proteus vulgaris (8%); in the treated group, also S. enterica (21%), Pseudomonas fragi (13%), and Pseudomonas veronii (6%). After the heat treatment of samples at 65 °C for 20 min, the total count of bacteria and coliform bacteria was zero. It has been shown that adding sage essential oil (EO) in combination with sous vide processing technique leads to the stabilization and safety of beef tenderloin. Full article