Search Results (12)

The growing demand for biofuels, especially ethanol produced from corn, has driven the production of co-products such as dried distillers grains with solubles (DDGS). With a high protein content (around 30%), fiber, and minerals, DDGS presents an economical alternative for animal nutrition, replacing traditional sources like soybean meal while maintaining productive performance and reducing costs. This study evaluated the total replacement of soybean meal with DDGS in the diet of confined Holstein cattle, focusing on weight gain, feed intake, digestibility, feed efficiency, animal health, meat quality, and economic viability. The 24 animals received diets with 80% concentrate, containing either DDGS or soybean meal, and no significant differences were observed in terms of body weight (p = 0.92), feed intake (p = 0.98), or feed efficiency (p = 0.97) between the two treatments. The average daily gain was 1.25 and 1.28 kg for cattle in the DDGS and soybean meal groups, respectively (p = 0.92). Regarding metabolic and digestive parameters, no relevant changes were found in blood levels, except for higher serum cholesterol (p = 0.03) levels in animals fed DDGS. The digestibility of neutral detergent fiber (NDF) (p = 0.03) and acid detergent fiber (ADF) (p = 0.05) was lower in the DDGS group, while the digestibility of ether extract was higher (p = 0.02). Rumen fluid analysis revealed an increase in the production of short-chain fatty acids (p = 0.01), such as acetic and butyric acids (p = 0.01), in the DDG-fed animals. In terms of meat quality, animals fed DDGS produced meat with lower levels of saturated fatty acids (SFA) (p = 0.05) and higher levels of unsaturated fatty acids (UFA) (p = 0.02), especially oleic acid (p = 0.05). This resulted in a healthier lipid profile, with a higher UFA/SFA ratio (p = 0.01). In terms of economic viability, DDGS-based diets were 10.5% cheaper, reducing the cost of production per animal by 7.67%. Profitability increased by 110% with DDGS compared to soybean meal, despite the high transportation costs. Therefore, replacing soybean meal with DDGS is an efficient and economical alternative for feeding confined cattle, maintaining zootechnical performance, increasing meat lipid content and improving fatty acid profile, and promoting higher profitability. This alternative is particularly advantageous in regions with easy access to the product. Full article

Phytosterols in vegetable oils have gained attention for their nutritional benefits in foods and food supplements. However, the use of vegetable oils in emulsions for infant formulas and parenteral nutrition has raised some concerns, as phytosterols may contribute to phytosterolemia in the case of infant formulas and, in a second scenario, to parenteral nutrition-associated liver disease. The present study proposes removing phytosterols from soybean oil using a synthetic amorphous silica Trisyl^® (E551) as an adsorbent material. The process is simple and involves stirring the oil at a high temperature under vacuum conditions followed by filtration to remove the adsorbent. A rotational factorial design of experiments, considering the adsorbent/oil ratio, temperature, and time was carried out to determine the optimal conditions. Additionally, the effects on tocopherols levels and formation of trans fatty acids were explored. The total sterol content in the initial refined soybean oil was 2540 mg/kg, with 32% in ester form (813 mg/kg). The treatments effectively reduced the sterol concentration, achieving a reduction of nearly 70% when 10% Trisyl^®, 140 °C, and a 90-min treatment were applied. Under these conditions, nearly 80% of the oil was recovered. Campesterol and stigmasterol levels were almost halved. Tocopherol losses were found to be below 20%. Thermal degradation, as analyzed by triacylglycerol polymers and trans fatty acids, was not observed in the treatments. Full article

This study aimed to analyse changes in the profile of long-chain fatty acids in the ruminal fluid of cows during in vitro fermentation, using different proportions of maize DDGS (distillers dried grains with solubles) as a substrate. The serum bottles were filled with 1 g of concentrate feed (C), which consisted of cereal middlings, postextraction rapeseed meal, and soybean meal. Substrates I, II, and III contained the same ingredients as substrate C, but also included DDGS at increasing proportions, while substrate IV contained only DDGS. Ruminal fluid with a buffer was then added to the bottles and incubated for 4, 8, and 24 h. After incubation, the fatty acid profile was analysed using a gas chromatograph. The use of DDGS as a substrate resulted in a decrease in SFA, and an increase in the proportion of UFA, including oleic acid (C18:1n9c) and linoleic acid (C18:2n6c). The fermentation profile with 15% and 20% DDGS in TMR proved to be the most beneficial. These findings suggest that the byproduct of bioethanol production could potentially improve the fatty acid profile in the ruminal fluid, resulting in higher-quality animal products. Full article

Separation of free fatty acids and triglycerides is important in the edible oil industry. In this study, both experimental and simulation approaches were conducted using falling film molecular distillation. A binary mixture of oleic acid as free fatty acid with refined soybean oil as triglyceride was used. Evaporation temperature range tested was from 110 to 160 °C, while other parameters such as condensation temperature, feeding rate, and vacuum pressure were fixed. The free fatty acid content of retentate was gradually decreased as evaporation temperature increased, while the free fatty acid content of distillate was approximately 100 wt.%, regardless of temperature. Triglycerides had an extremely low vapor pressure compared to oleic acid; therefore, their fraction in distillate was negligible. The mass conservation and transport equations were selected to explain the evaporation mechanism, and analytical solutions were simply introduced under the conditions of low mass fraction of volatile compound in the feeding mixture. Some experimental data are re-quired to determine the coefficient of molecular distillation in the governing equation. Using this obtained parameter, the proposed model could simulate all mass amounts and fractions of each component in retentate and distillate with a good agreement between experimental and simulation data, indicating the reasonable accuracy of the model proposed. Full article

In this study, soybean oil deodorizer distillate (SODD), a mixture of free fatty acids and acylglycerides, and isoamyl alcohol were evaluated as substrates in the synthesis of fatty acid isoamyl monoesters catalyzed by Eversa (a liquid formulation of Thermomyces lanuginosus lipase). SODD and the products were characterized by the chemical and physical properties of lubricant base stocks. The optimal conditions to produce isoamyl fatty acid esters were determined by response surface methodology (RSM) using rotational central composite design (RCCD, 2³ factorial + 6 axial points + 5 replications at the central point); they were 1 mol of fatty acids (based on the SODD saponifiable index) to 2.5 mol isoamyl alcohol, 45 °C, and 6 wt.% enzymes (enzyme mass/SODD mass). The effect of the water content of the reactional medium was also studied, with two conditions of molecular sieve ratio (molecular sieve mass/SODD mass) selected as 39 wt.% (almost anhydrous reaction medium) and 9 wt.%. Ester yields of around 50 wt.% and 70 wt.% were reached after 50 h reaction, respectively. The reaction products containing 43.7 wt.% and 55.2 wt.% FAIE exhibited viscosity indices of 175 and 163.8, pour points of −6 °C and −9 °C, flash points of 178 and 104 °C, and low oxidative stability, respectively. Their properties (mainly very high viscosity indices) make them suitable to be used as base stocks in lubricant formulation industries. Full article

Liquid Eversa was evaluated in hydrolysis of acylglycerols from soybean oil deodorizer distillate (SODD), as well as simultaneous esterification/transesterification of SODD with low-to-high free fatty acids (FFAs) content using ethanol as acyl acceptor. Hydrolysis of SODD at mild temperature (37 °C) and without pH control (water:SODD mass ratio of 4:1) increased its FFAs content from 17.2 wt.% to 72.5 wt.% after 48 h reaction. A cold saponification of SODD allowed a saponification phase (SODD-SP) to be recovered with 93 wt.% saponification index and 2.25 wt.% FFAs content, which was used to find the experimental conditions for simultaneous esterification/transesterification reactions by experimental design. Temperature of 35 °C, enzyme concentration of 8.36 wt.%, and molar ratio of 3.64:1 (ethanol:SODD-SP) were found as the best conditions for fatty acid ethyl esters (FAEEs) production from SODD-SP (86.56 wt.% ester yield after 23 h reaction). Under the same reaction conditions, crude SODD (17.2 wt.% FFAs) and hydrolyzed SODD (72.5 wt.% FFAs) yielded products containing around 80 wt.% FAEEs. Caustic treatment could increase the ester content to around 90 wt.% and reduce the FFAs content to less than 1 wt.%. Our results show the good performance of liquid Eversa in aqueous (hydrolysis reactions) and organic (esterification/transesterification reactions) media. Full article

The aim of the study was to investigate mixtures comprising corn distillers dried grain with solubles as a partial replacer for soybean meal (SBM) and different dietary fat sources, in order to determine their effect on the meat quality and fatty acid profile. Thirty-two crossbred fatteners were divided into four groups: I–SBM + rapeseed oil, II–cDDGS + rapeseed oil, III–cDDGS + beef tallow, IV–cDDGS + coconut oil. The experiment took place from 60 to 118 kg. At the end of fattening, all pigs were slaughtered and samples of meat (musculuslongissimus lumborum) were taken. The fatty acid profile, texture, and quality traits were analyzed. Corn DDGS affected drip loss. Beef tallow and coconut oil improved water holding capacity and drip loss and increased fat content, compared to the control group. The dietary fat type affected the fatty acid composition, iodine value, and consequently some quality traits of meat. However, these relationships varied. Fat content in the meat was inversely correlated with shear force and texture parameters, but positively with tenderness and juiciness. The fatty acid profile significantly influenced cohesiveness, chewiness, resilience and sensory traits, which were the most beneficial in meat with higher fat content and higher fat saturation index. Full article

Palm fatty acid distillate (PFAD) is a by-product of palm oil (P) refining. Its use in chicken diets is a way to reduce the cost of feed and the environmental impact. Its low unsaturated:saturated fatty acid ratio (UFA:SFA) and its high free fatty acid (FFA) level could be partially counteracted by its blending with soybean oil (S). The objective was to assess the effect of replacing S with different levels of PFAD on lipid-class content and fatty acid (FA) digestibility along the intestinal tract and in the excreta of 11 and 35-day-old broiler chickens. Five experimental diets were prepared by supplementing a basal diet with S (S6), PFAD (PA6), two blends of them (S4-PA2 and S2-PA4), or P (P6) at 6%. Replacing S with PFAD did not affect performance parameters (p > 0.05) but negatively affected feed AME, FA digestibility, and FFA intestinal content (p < 0.05), especially in starter chicks. Including PFAD delayed total FA (TFA) absorption (p < 0.05) at 11 days, but at 35 days it did not affect the TFA absorption rate. The use of PFAD blended with S, when FFA ≤ 30% and UFA:SFA ≥ 2.6, led to adequate energy utilization in broiler grower-finisher diets. Full article

Behavioural and genetic evidence shows that the taste system is intimately related to the sensing of nutrients with consequences for poultry nutrition practices. A better understanding of how chickens may sense fat could provide the background for selecting feedstuffs used in poultry feeds. Acid oils have the potential to be economical and sustainable feedstuffs. These fat by-products from the edible oil refining industry possess a similar fatty acid composition to the crude oils but are richer in free fatty acids (FFA). An experiment was conducted to study the effect of FFA content and the unsaturated:saturated ratio (U:S) on dietary preferences in hens. Four fat sources were added to a basal diet at an inclusion rate of 6%, determining the experimental diets: soybean oil (SO; high U:S, 5% FFA); soybean acid oil (SA; high U:S, 50% FFA); palm oil (PO; low U:S, 5% FFA); and palm fatty acid distillate (PFAD; low U:S, 50% FFA). The experimental diets were offered in a series of double-choice tests to forty-eight Lohmann Brown laying hens housed individually in cages. Each hen was offered the ten potential binary combinations of the four diets including each diet compared to itself (referred to as four control double-choices). Feed intake was measured for two hours twice a day after one hour of fasting. Consumption was analysed as a standard preference index (% of test diet intake in comparison with the total intake). Preference values were compared to the random choice value of 50% using the Student’s t-test. None of the four control comparisons differ significantly from 50% (p > 0.05), indicating that the changes in preference values observed in the other binary comparisons were related to the dietary changes associated to fat ingredients. Hens showed a feed preference for palm oil added diets over soybean oil diets (p < 0.05), with PO and PFAD being equally preferred (p < 0.05). However, in this trial the hens demonstrated a preference for SO (low %FFA) when offered in choice with SA (high %FFA) (p < 0.05). These results suggest that the degree of saturation plays an important role in dietary fat preferences: hens prefer predominantly saturated oils even when these are rich in FFA. Furthermore, when presented with a choice between predominantly unsaturated oils, hens prefer feed with a low %FFA. In conclusion, %FFA and the U:S ratio affected feed preferences in hens. The use of oils with greater preference values may give rise to greater feed palatability, enhancing feed intake at critical stages. Full article

Oleogelation is an emerging technology to structure oils, which can be widely used to substitute saturated and trans fats. Extra virgin olive oil is widely recognized for its high nutritional value, but its utilization in oleogel production is currently limited. In this study, extra virgin olive oil was utilized for the production of a novel oleogel using wax esters derived from soybean fatty acid distillate (SFAD), a byproduct of industrial soybean oil refining. Different concentrations (7%, 10%, 20%, w/w) of SFAD-wax esters were used to evaluate the minimum concentration requirement to achieve oleogelation. Analyses of the mechanical properties of oleogel showed a firmness of 3.8 N, which was then reduced to around 2.1–2.5 N during a storage period of 30 days at 4 °C. Rheological analysis demonstrated that G′ is higher than G″ at 20–27 °C, which confirms the solid properties of the oleogel at this temperature range. Results showed that SFAD was successfully utilized for the oleogelation of olive oil, resulting in a novel oleogel with desirable properties for food applications. This study showed that industrial fatty side streams could be reused for the production of value-added oleogels with novel food applications. Full article

Soybean oil isolated by enzyme-assisted aqueous extraction (EAE) was subjected to molecular distillation-induced deacidification, and the effects of evaporator temperature, scraper speed, and feed flow rate on oil quality (acid value, color, peroxide value, p-anisidine value, tocopherol content, and fatty acid content) were evaluated to determine the suitable deacidification conditions. Fatty acid content was largely unaffected by evaporator temperature and scraper speed, while an increase of these parameters decreased tocopherol content as well as acid, peroxide, and p-anisidine values and resulted in Lovibond color deepening. The increase of feed flow rate had an opposite effect on the above quality indices. As a result, molecular distillation of EAE-produced soybean oil under suitable conditions (evaporator temperature = 180 °C, scraper speed = 220 rpm, feed flow rate = 4 mL/min) was found to afford a high-quality deacidified product in an environmentally friendly way. Full article

A supercritical methanol transesterification method was applied to produce biodiesel from the high-acid oil of soybean soapstock. The fuel properties of biodiesel produced with various molar ratios of methanol to raw oil were analyzed and compared in this experimental study. Oleic acid (C18:1), linoleic acid (C18:2), and palmitic acid (C16:0) were the three main compounds in the high-acid oil-biodiesel. The saturated fatty acid content of the high-acid oil increased significantly due to the supercritical-methanol transesterification reaction. The fuel characteristics of the resulting high-acid oil, including the specific gravity and kinematic viscosity, were also greatly improved. The saturated fatty acid content of the biodiesel produced from the high-acid oil was higher than that of biodiesel from waste cooking oil produced by the subcritical transesterification using a strongly alkaline catalyst. The high-acid oil-biodiesel that was produced with a molar ratio of methanol to raw oil of 42 had the best fuel properties, including a higher distillation temperature and cetane index and a lower kinematic viscosity and water content, among the biodiesels with different molar ratios. Full article