Next Article in Journal
Investigating the Impact of Indemnity Waivers on the Length of Stay of Cats at an Australian Shelter
Previous Article in Journal
Readily Available Water Access is Associated with Greater Milk Production in Grazing Dairy Herds
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Housing and Management Practices on 33 Pullet Farms in Canada

1
Department of Animal Biosciences, Ontario Agricultural College, University of Guelph, Guelph, ON N1G 2W1, Canada
2
Department of Population Medicine, Ontario Veterinary College, University of Guelph, Guelph, ON N1G 2W1, Canada
*
Author to whom correspondence should be addressed.
Animals 2019, 9(2), 49; https://doi.org/10.3390/ani9020049
Submission received: 4 November 2018 / Revised: 17 November 2018 / Accepted: 24 November 2018 / Published: 6 February 2019
(This article belongs to the Section Cattle)

Abstract

:

Simple Summary

The rearing period of pullets plays an important role in the successful transition to furnished cages or non-cage housing systems for laying hens. Changes in the laying hen sector often occur without accompanying changes in the pullet rearing sector, which could pose a risk to the success of the housing system transition. However, little is known about the housing and management practices of pullets worldwide. Recently, a new Code of Practice was released (March 2017) in Canada which provides one of the first guidelines on pullet rearing. This study aimed to describe current housing and management practices applied on pullet farms in Canada, where farmers are in the process of transitioning to this new Code of Practice. Thirty-three pullet farmers were surveyed to understand commonly used management practices in cage (14), single-tier (11) and multi-tier (8) flocks. In general, non-cage farmers met the new requirements set out in the Code of Practice for space, perches and litter provision during pullet rearing. Flocks in conventional cages did not have opportunities for perching and foraging. Further research is needed to develop methods to provide pullets with opportunities to perch and forage in these systems. Additionally, clear litter management recommendations for farmers to ensure good litter quality are needed for non-cage housing systems.

Abstract

Although Canada is one of the first to provide guidelines on pullet rearing in a new Code of Practice which came into effect in March 2017, little information is available about the housing and management of pullets on Canadian farms. We surveyed 99 pullet farmers and received useable responses from 33 pullet farmers (33.3% response rate) who took part in the Start Clean-Stay Clean™ program through their provincial egg boards across Canada during October–December 2017 as part of a larger study. Most flocks were housed in conventional cage systems (42.4%), followed by single-tier (33.3%) and multi-tier systems (24.2%). Flocks ranged from 1–19 weeks of age (average: 10.5 weeks of age) and were white- (58.1%) or brown-feathered (41.9%). In general, non-cage farmers met the new requirements set out in the Code of Practice for space, perches and litter provision during pullet rearing during this transitional period. Conventional caged flocks did not have opportunities for perching and foraging, but developing new methods to provide pullets with opportunities to perch and forage will become more important as the laying hen housing system transition from conventional cages to furnished cage and non-cage housing systems in Canada progresses. Additionally, clear litter management recommendations for farmers to ensure good litter quality are needed for non-cage housing systems.

1. Introduction

Early life experiences have long-lasting effects on the brain and body, impacting brain function, behaviour and physical health throughout the life-span of an animal [1]. Domestic chickens are hatched with well-developed brains, and during the first few weeks of life they learn and develop behaviours important for social hierarchy formation, thermoregulation, fear responses, feed searching and spatial navigation [2]. At the same time neuromuscular function and skeletal frame are also developing, contributing to physical fitness, bone health and locomotory abilities [2]. Therefore, the rearing period is a critical phase of life for the overall well-being of the laying hen.
Rearing management can influence bird development and differences in physical and social environments between rearing and laying hen facilities can have large consequences for bird adaptability and productivity in the layer phase [3,4]. Rearing pullets in environments similar to where they will be kept during lay is thought to ease the transition between these phases. This is particularly important for non-cage, and especially aviary systems, when the provision of a generally more complex environment (e.g., perches, foraging- or dustbathing material) helps birds develop skills to navigate and reduces behavioural problems [3,5,6,7,8]. Despite its key role, research into the rearing housing and management of pullets and its effects over a bird’s lifetime has been a relatively neglected field until recently [4]. Additionally, information on the environment and management of pullets is not always known to the laying hen farmer [9], which can be problematic considering the complexity of rearing and egg laying hen housing systems available (ranging from cage systems to multi-tier aviary systems).
European legislation which provides minimum standards for laying hens does not provide recommendations for pullet rearing [10]. Private and organic standards have been increasingly implemented in different countries [11,12], but guidelines for pullet rearing are still limited [13,14]. The Canadian Code of Practice for the Care and Handling of Pullets and Layers provides one of the first guidelines with detailed requirements for space, perches and litter provision during pullet rearing [15]. These requirements were based on available scientific evidence, expert views and industry input through a committee comprised of farmers, animal welfare experts, transporters, processors, veterinarians, and retail and government representatives [16]. That said, there are few recent published reports about the housing and management practices commonly used for pullets worldwide e.g., [17,18,19] and none for Canadian farms.
Recently, van Staaveren et al. [20] surveyed Canadian laying hen farmers and we now present results of a similar survey among 33 pullet farmers throughout Canada. The goal of this study was to describe housing and management practices on pullet farms in light of the upcoming transition from conventional cages to furnished cages and non-cage housing systems in Canada’s laying hen sector [21].

2. Materials and Methods

A questionnaire was designed to identify housing, management practices and flock characteristics used on pullet rearing farms similar to that in van Staaveren et al. [20]. In brief, the questionnaire covered topics of housing conditions, litter management, nutrition and feeding, environmental control, flock characteristics, flock rearing and placement, and flock health adapted from [22,23]. Questions were modified to reflect the rearing stage based on the experience of the research team with the Canadian egg production sector. Feedback from the federal and provincial egg boards in Canada and staff from the Arkell Poultry Research Station (Ontario Ministry of Agriculture, Food and Rural Affairs [OMAFRA]—University of Guelph Agreement) as well as local farms was incorporated. This study was approved by the University of Guelph Research Ethics Board (REB17-06-010).
Commercial farmers were invited to participate in the context of a larger cross-sectional study to identify factors associated with feather damage in laying hens [24]. Questionnaires were sent to pullet rearers that were on the Start Clean-Stay Clean™ program through their provincial egg boards across Canada in October 2017. This is a comprehensive food safety and quality program assessed by the Canadian Food Inspection Agency [25]. Farmers were asked to complete the questionnaire for their current flock. Additionally, farmers were provided the opportunity to fill in the questionnaire online via Qualtrics (Qualtrics, Provo, UT, USA). Reminders were sent through provincial egg boards 2–4 weeks after distribution, and two weeks before the end of data collection in December 2017.
Data were entered into Microsoft Office Excel (Professional Plus 2016) using manual double entry. Data were screened for entry errors and invalid responses were considered as missing values. Space allowance was provided by farmers or calculated by the research team based on dimensions of cage or barn/housing section and the number of birds housed within the space as per van Staaveren et al. [20]. Useable vertical space in multi-tier systems could not be calculated, and so values for space allowance should be interpreted with caution. Within the different housing systems, the frequency of different management practices used was determined (SAS v9.3, SAS Inst. Inc., Cary, NC, USA). Results are presented as the number and percentage of flocks for categorical variables and mean ± SD (range: min–max) for continuous variables.

3. Results

A total of 99 pullet farmers were invited to participate and 33 useable questionnaires providing housing and management information on pullet flocks were returned (33.3% response rate). Over half of the farmers had more than 10 years of experience in pullet rearing (57.6%). The frequency of housing design, flock characteristics and management reported by farmers, representing data of the 33 pullet flocks in Canada as collected during October–December 2017, is described below. Flocks were placed between May and November 2017 shortly after the new Code of Practice was released in March 2017 and as such data were collected during a transitional period.

3.1. Housing

3.1.1. Housing Design

Pullet flocks were sampled from various provinces throughout Canada, mainly Alberta (30.3%), British Columbia (21.2%), Ontario (12.1%), Manitoba (12.1%) and Saskatchewan (9.1%). Fourteen flocks were housed in conventional cage systems (42.4%), while 11 flocks (33.3%) and 8 flocks (24.2%) were housed in single-tier floor systems and multi-tier aviary systems, respectively. Multi-tier systems had 2 (12.5%), 3 (62.5%), or more than 3 tiers (25.0%). Four flocks came from certified organic multi-tier farms. All farms had more than 5000 birds on site and over a third of farms had more than 25,000 birds (Table 1).

3.1.2. Group Size and Space Allowance

Group size was 20 ± 7 birds (range: 11–30) in caged systems, while in single- and multi-tier systems birds were housed in groups of 11,250 ± 7038 birds (range: 5300–27,821) and 11,392 ± 4083 birds (range: 6850–19,910), respectively. Average space allowance in cages was 292.6 ± 75.44 cm2/bird (range: 192.6–439.9 cm2/bird). For flocks in single-tier systems, this was 875.4 ± 219.53 cm2/bird (range: 696.8–1430.9 cm2/bird) and in multi-tier systems 715.5 ± 230.42 cm2/bird (range: 474.3–1035.8 cm2/bird).

3.1.3. Provision of Furnishings and Litter

All flocks in multi-tier systems and nearly all single-tier flocks had access to perches, while no perches were provided for caged pullets (Table 2). In non-cage housing systems, these perches were also provided at different heights (78.5%) and allowed birds to perch at the same time (64.3%). Enrichment was only provided in non-cage housing systems (e.g., bales of hay/straw or mineral blocks/pecking stones) but this was not a common practice (Table 2).
None of the flocks in the cage systems had access to scratch areas which could provide foraging/dustbathing opportunities. On the other hand, litter was provided in all non-cage systems with single-tier systems most often being an all litter barn, while multi-tier systems consisted of a combination of wire, slats and litter (Table 3). In these barns, different proportions of the floor were covered with litter. Sawdust or wood shavings (66.7%) were most commonly used as bedding for litter provision, while others allowed litter to build up over time from manure, feathers and dust in the system (16.7%). Birds received access to the litter at an average of 3.5 weeks of age (range: 1.0–12.0 weeks of age). Litter depth was 9.8 ± 6.87 cm (range: 0.0–25.4 cm) in single-tier and 6.0 ± 5.07 cm (range: 0.0–15.2 cm) in multi-tier systems. Litter was not replaced after first access, and only a few farmers indicated they raked the litter in order to break up the substrate (Table 3).

3.1.4. Nutrition and Feeding

All flocks used nipple drinkers (100%) and the most common feeders were chain (72.7%) or pan feeders (18.2%). Feed was often given as mash and was equally bought from external sources or home-milled (Table 4). Changes in the diet occurred as birds became older and were often gradually introduced (62.1%). Typically, birds had changed diets 0–2 times within 7 weeks of age while >3 changes had occurred by the time birds reached approximately 12 weeks. Feeders were operated an average of 4.3 ± 1.68 times per day (range 2–10 times). Practices such as midnight feeding (3.0%) or providing animal by-products in the diet (25.0%) only occurred in a small proportion of flocks. Nearly two-thirds of the flocks (62.1%) were provided with supplements such as insoluble grit (6.9%), insoluble fibre (24.1%), oyster shell (13.8%) and vitamins (44.8%).

3.1.5. Environmental Control

Pullets received on average 10.9 ± 2.09 h of light per day (range: 9.0–18.0 h), mostly from LED sources. Light intensity as measured at bird height on the lowest level was between 5 to 15 lux on most farms (66.7%), though not all farmers were able to answer this question (18%). Two-thirds of farmers provided a dawn/dusk period (66.7%), and this was most common on farms with multi-tier systems. Dawn/dusk was simulated by the gradual dimming of lights in different areas in multi-tier systems, while all lights were dimmed automatically in cages and single-tier systems.
Barn climate was controlled through mechanical ventilation on most farms (90.9%). Average temperature and humidity were 22.1 ± 2.83 °C (range: 19.0–34.0 °C) and 54.4 ± 14.98% relative humidity (RH; range: 22.0–75.0% RH), respectively. The removal of manure occurred at least once per week in cage or multi-tier systems via manure belt, while in single-tier systems manure was removed at the end of the flock on most farms (Table 5).

3.2. Flock Characteristics

3.2.1. General Characteristics

Pullet flocks were 10.5 ± 5.22 weeks old (range: 1–19 weeks) at the time of the study. All flocks were beak trimmed (approx. ¼ of the length of the beak) at day 1 in the hatchery using infrared beak treatment. Flocks were either white- (58.1%) or brown-feathered (41.9%) and mostly of the Lohmann, Dekalb, H&N and Hy-line breed (Table 6). In cages, most flocks were white-feathered, while in single-tier systems most were brown-feathered, and an equal number of white- and brown-feathered flocks were housed in multi-tier systems.

3.2.2. Flock Rearing and Transfer to Laying Farms

Most flocks were to be transferred to laying facilities on the same farm and never mixed during rear (Table 7). Farmers discussed the rearing conditions in the barn with the laying farmers (87.1%), and over 90% indicated they attempted to match conditions between rearing and laying facilities (Table 7).

3.2.3. Flock Health

Flock inspections occurred 2–3 times per day (78.8%) and were performed by 1–2 workers (97%) (Table 8). Nearly all farmers reported to always inspect the bottom and top tier (97%) and 69% indicated they sometimes handled birds during inspection. Daily inspections took relatively more time in multi-tier and cage systems compared to single-tier systems. Route taken during inspection varied according to approximately two-thirds of the farmers. Health (100%) and behaviour (90.9%) of the birds, functioning of equipment (93.9%) and litter quality (78.8%) were the main aspects checked during inspection. Barns were disinfected before arrival of the birds (100%) and dedicated clothing and/or clean boot dips were used (97%). A smaller proportion of farmers (43.8%) had developed and implemented a flock health plan with their veterinarian. All flocks were vaccinated though there were differences between the flocks against which diseases they were vaccinated (Table 8). The main diseases flocks were vaccinated against included Marek’s disease, infectious bursal disease, Newcastle disease, infectious bronchitis, avian encephalomyelitis, E. coli, and coccidiosis, while only a few flocks vaccinated against fowl pox, infectious laryngotracheitis and salmonella. No diseases had been observed since placement in the majority of flocks (87.1%). Average cumulative mortality was 1.8 ± 1.67% (range 0.005–8.33%), and reasons for mortality included birds getting trapped in housing equipment (28.2%), leg injuries (24.4%), disease (21.8%), and smothering (15.4%).

4. Discussion

4.1. Housing

This study is the first to present results on housing and management practices applied on 33 pullet farms in Canada and addresses the urgent need for up-to-date information on these aspects of pullet rearing worldwide e.g., [17,18,19]. It should be kept in mind that this sample was recruited through the provincial egg boards and pullet farmers who were on their Start Clean-Stay Clean™ program under the Egg Farmers of Canada were included. This is a comprehensive food safety and quality program assessed by the Canadian Food Inspection Agency [25]. Additionally, as this study was part of a larger project aimed at identifying management factors associated with feather damage in laying hens kept in furnished cage and non-cage housing systems [24], nearly all pullet farmers provided birds for their own laying farms and not all pullet farmers on the Start Clean-Stay Clean™ program were contacted to participate in the study. Therefore, these findings should not be generalized to the pullet sector as a whole in Canada. Surveyed pullet farmers represented the major egg production provinces across Canada and it should be noted that large differences in climate across the country [26] could have implications for management practices. Flocks were placed after the National Farm Animal Care Council published the new Code of Practice that came into effect in March 2017, which provides some of the first guidelines for pullet housing and management [15]. While this new Code of Practice should be followed in management of these flocks it is important to be aware of the short timeframe between release of the Code of Practice and the survey in the current study and that a transitional period is needed to make structural modifications.
The majority of study flocks were housed in conventional cage systems, while around a third were housed in single-tier rearing systems and nearly a quarter of the flocks were reared in multi-tier rearing systems. This is not surprising, as there are currently few furnished cages for rearing pullets available on the market, and multi-tier pullet rearing systems are only recently being used in Canada with many now on their first few flocks. With the upcoming transition to furnished cage and non-cage housing systems within the Canadian egg production sector [21], it should be noted that there do not appear to be accompanying changes within the pullet sector in terms of housing system changes or financial compensation. However, it is likely that these systems will gain more use as changes in the laying hen sector trickle down to the pullet sector.
On average, farmers meet the requirements for space allowance of pullets in cages, single-tier and multi-tier systems [15], with the range in space allowance observed being explained by the large range of bird ages. Space allowance should increase as birds get older, but few recommendations have been made previously for pullet space allowance [3]. The new Code of Practice requires that pullets of 8 weeks of age should receive 283.9 cm2/bird in cages and multi-tier systems (plus litter space 58.1 cm2/bird in multi-tier systems), and 696.8 cm2/bird in single-tier systems [15].
Physical, sensory and stimulatory additions to the environment of the birds can help maximize the birds’ developmental potential [27]. The importance of providing perching and foraging opportunities early in life have been well documented [3,28,29]. As such, caged pullet flocks are not allowed to transition to non-cage housing systems under the Code of Practice [15]. Currently, perching and foraging opportunities are not available in pullet rearing cage systems, which limits the ability to match rearing to layer housing for hens destined for housing in furnished cages during the laying period [4]. However, the vast majority of non-cage flocks surveyed in this study provided perches and all provided pullets with access to litter. Only a few of the flocks housed in single-tier systems did not have access to perches, which will likely be addressed following a transitional period while farmers make these structural changes to their housing system. Providing perches is a recommended practice for pullets destined for single-tier housing and required practice for pullets destined for multi-tier housing in the new Code of Practice [15]. Huber-Eicher [17] reported that approx. half of 66 surveyed pullet farms in Switzerland (single-tier and multi-tier systems) provided non-elevated perches, while 6% did not provide perches at all. More recent data are not available. In our study, access to litter was provided when pullets were on average 3.5 weeks of age. Final requirements in the Code of Practice state that about 17% of the space allowance available per bird should be litter space (58.1 cm2 in addition to 283.9 cm2 per pullet at 8 weeks of age or older) [15]. While specific litter space allowance per bird could not be determined, we asked farmers to estimate the proportion of barn surface that was covered with litter. The majority of single-tier systems had all litter barns, while in multi-tier systems a varied proportion of the barn surface was covered with litter. A total of 75 percent of multi-tier systems had ≥1/3 of the barn floor covered with litter. In comparison, previous surveys on rearing flocks in Switzerland conducted over 20 years ago found that more than 70% of floor space was littered in single-tier systems (670 cm2 per bird), while in aviary systems 326 cm2 per bird in litter space was available [17]. While there are no clear recommendations on litter space provision, it is important to consider the quality and maintenance of the litter substrate which is a buildup of bedding material and manure, feathers and dust in the systems. Often bedding is provided in the form of sawdust and shavings, while around 16% of farmers indicated that they let manure, feathers and dust build up in the system. Manure was more frequently removed in cage and multi-tier systems due to the structural differences, with these systems allowing farmers the use of manure belts. However, manure in the single-tier and the littered area of multi-tier systems builds up which can have implications for ammonia control, enhance litter deterioration and be aversive to the birds [30,31,32]. Finally, litter is typically not replaced or broken up over the rearing period which could affect the quality of the litter substrate. However this is also dependent on other factors such as barn climate and water spillage which play a role in litter friability [33,34,35]. If litter is no longer loose or friable, birds do not use it for its intended purpose of foraging or dustbathing [32].
Feed was mostly provided in mashed form, though crumbs were also given similarly as reported by Huber-Eicher [17] depending on the age of the flock. Diet changes were more frequently reported in the current study than in the Swiss study [17], however, diet changes reported in the current study were in line with breed guidelines [36,37]. The number of times feeders ran per day was similar to reported frequencies of 5.5 times per day [17]. Environmental control was largely dependent on the different ages of the flocks and was in line with common breed guidelines for the duration of light, temperature and humidity levels [36,37]. Both diet changes and environmental factors have previously been implicated in the development of feather pecking at rear and at lay [38].

4.2. Flock Characteristics

Flocks in the study covered a large range of ages (1–19 weeks of age) with an average age of 10 weeks. Pullet development occurs rapidly within the first weeks of life and can explain the variation in management practices observed in this study. There was an equal representation of white- and brown-feathered flocks with the most common breeds being Dekalb White, H&N Nick Chick, Lohmann Brown and Lohmann LSL. Most pullet flocks were being reared for egg production in the farmers own laying facilities, however, a proportion of flocks was intended for egg production on external laying farms. The high proportion of farmers raising pullets for their own laying hen flocks is likely a consequence of the recruitment of pullet farmers on the Start Clean-Stay Clean™ program by the provincial egg boards.
In general, the surveyed flocks showed little disease and relatively low mortality rates. This can be attributed to the hygiene measures (e.g., disinfection of barns, dedicated clothing and/or clean boot dips, frequent inspections of flocks) and a rigorous vaccination scheme [39]. There is some variation amongst farmers with respect to the type of diseases they vaccinated their flocks against, as also seen in other organic pullet farmers in the UK [19]. Mostly, this variation is observed in those vaccinations which are considered optional in breed guidelines and are only recommended when the disease is present in the area [40]. Veterinarians were included in the development and implementation of flock health plans in around 44% of the flocks which is similarly reported by others [19]. This involvement seems higher compared to that in laying hen flocks [20]. However, similar to laying hen flocks, visits by veterinarians to farms were limited [19,20]. While disease was mentioned as a reason for mortality, other reasons not related to disease were more frequently reported. This highlights the importance of adequate housing design and good human-animal relationships to avoid issues such as pullets getting trapped in housing equipment, leg injuries and smothering [3].

5. Conclusions

Housing and management practices applied on 33 Canadian pullet rearing farms are reported here for the first time. This study addresses the limited information available on commercial pullet rearing and shows an uptake of requirements regarding space, perches and litter provision during pullet rearing set out in the new Code of Practice, with the exception of perching and foraging opportunities in conventional caged flocks. Development of new methods to provide pullets with opportunities to perch and forage in these systems will become more important as the laying hen housing system transition from conventional cages to furnished cage and non-cage housing systems in Canada progresses. Additionally, clear litter management recommendations for farmers to ensure good litter quality are needed for non-cage housing systems.

Author Contributions

Formal analysis, N.v.S. and C.D.; Funding acquisition, A.H.-M.; Investigation, N.v.S. and C.D.; Methodology, N.v.S., C.D., C.F.B., T.M.W., O.B. and A.H.-M.; Project administration, N.v.S. and A.H.-M.; Supervision, O.B. and A.H.-M.; Writing—original draft, N.v.S.; Writing—review and editing, C.D., C.F.B., T.M.W., O.B. and A.H.-M.

Funding

This study was part of the ‘Toward an Understanding of Beautiful Feather Cover in Laying Hens’ project funded by the Egg Farmers of Canada (052917, recipient: Harlander). We acknowledge the Mitacs Elevate Fellowship for funding van Staaveren (460687).

Acknowledgments

The authors would like to extend their gratitude to the managers and personnel of the laying hen farms for participating in this study. We gratefully acknowledge Prof. Christine Nicol for kindly providing us with a copy of farmer questionnaires as used in Lambton et al., 2013 (Vet Record). Additionally, we would like to thank the Egg Farmers of Canada and the provincial egg boards for their assistance in farm recruitment.

Conflicts of Interest

The authors declare no conflict of interest. The funders had no role in the design of the study; in the collection, analyses, or interpretation of data; in the writing of the manuscript, and in the decision to publish the results.

References

  1. McEwen, B.S. Understanding the potency of stressful early life experiences on brain and body function. Metabolism 2008, 57, S11–S15. [Google Scholar] [CrossRef] [PubMed]
  2. Rogers, L.J. The Development of Brain and Behaviour in the Chicken; CAB International: Wallingford, UK, 1995. [Google Scholar]
  3. Janczak, A.M.; Riber, A.B. Review of rearing-related factors affecting the welfare of laying hens. Poult. Sci. 2015, 94, 1454–1469. [Google Scholar] [CrossRef] [PubMed]
  4. Widowski, T.M.; Torrey, S. Rearing young birds for adaptability. In Advances in Poultry Welfare; Mench, J.A., Ed.; Woodhead Publishing Group: Duxford, UK, 2018; pp. 49–77. ISBN 978-0-08-100915-4. [Google Scholar]
  5. Huber-Eicher, B.; Wechsler, B. The effect of quality and availability of foraging materials on feather pecking in laying hen chicks. Anim. Behav. 1998, 55, 861–873. [Google Scholar] [CrossRef] [PubMed]
  6. Kozak, M.; Tobalske, B.; Springthorpe, D.; Szkotnicki, B.; Harlander-Matauschek, A. Development of physical activity levels in laying hens in three-dimensional aviaries. Appl. Anim. Behav. Sci. 2016, 185, 66–72. [Google Scholar] [CrossRef]
  7. Rodenburg, T.B.; Komen, H.; Ellen, E.D.; Uitdehaag, K.A.; van Arendonk, J.A.M. Selection method and early-life history affect behavioural development, feather pecking and cannibalism in laying hens: A review. Appl. Anim. Behav. Sci. 2008, 110, 217–228. [Google Scholar] [CrossRef]
  8. Tahamtani, F.M.; Brantsaeter, M.; Nordgreen, J.; Sandberg, E.; Hansen, T.B.; Nodtvedt, A.; Rodenburg, T.B.; Moe, R.O.; Janczak, A.M. Effects of litter provision during early rearing and environmental enrichment during the production phase on feather pecking and feather damage in laying hens. Poult. Sci. 2016, 95, 2747–2756. [Google Scholar] [CrossRef] [PubMed]
  9. Berg, C. Health and Welfare in Organic Poultry Production. Acta Vet. Scand. 2002, 43, S37. [Google Scholar] [CrossRef]
  10. European Commission Council. Directive 1999/74/EC of 19 July 1999 laying down minimum standards for the protection of laying hens. Off. J. Eur. Communities 1999, L203, 53–57. [Google Scholar]
  11. Toschi Maciel, C.; Bock, B.B. Modern Politics in Animal Welfare: The Changing Character of Governance of Animal Welfare and the Role of Private Standards. Int. J. Sociol. Agric. Food 2013, 20, 219–235. [Google Scholar]
  12. Mench, J.A. Assessing animal welfare at the farm and group level: A United States perspective. Anim. Welf. 2003, 12, 493–503. [Google Scholar]
  13. Royal Society for the Prevention of Cruelty to Animals (RSPCA). RSPCA Welfare Standards for Laying Hens and Pullets. Available online: https://science.rspca.org.uk/sciencegroup/farmanimals/standards/pullets (accessed on 20 August 2018).
  14. Humane Farm Animal Care (HFAC). HFAC Standards for Production of Egg Laying Hens. Available online: http://certifiedhumane.org/wp-content/uploads/Std18.Layers.3A-5.pdf (accessed on 20 August 2018).
  15. National Farm Animal Care Council (NFACC). Code of Practice for the Care and Handling of Pullets and Laying Hens; NFACC: Ottawa, ON, Canada, 2017; ISBN 9780993618925. [Google Scholar]
  16. Egg Farmers of Canada (EFC). Annual Report 2017; EFC: Ottawa, ON, Canada, 2018. [Google Scholar]
  17. Huber-Eicher, B. A survey of layer-type pullet rearing in Switzerland. Worlds. Poult. Sci. J. 1999, 55, 83–91. [Google Scholar] [CrossRef]
  18. Bestman, M.; Wagenaar, J.-P. Health and Welfare in Dutch Organic Laying Hens. Animals 2014, 4, 374–390. [Google Scholar] [CrossRef] [PubMed]
  19. Sparks, N.H.C.; Conroy, M.A.; Sandilands, V. Socio-economic drivers for UK organic pullet rearers and the implications for poultry health. Br. Poult. Sci. 2008, 49, 525–532. [Google Scholar] [CrossRef] [PubMed]
  20. Van Staaveren, N.; Decina, C.; Baes, C.F.; Widowski, T.M.; Berke, O.; Harlander-Matauschek, A. A Description of Laying Hen Husbandry and Management Practices in Canada. Animals 2018, 8, 114. [Google Scholar] [CrossRef] [PubMed]
  21. Egg Farmers of Canada (EFC). Egg Farmers of Canada Announces Industry-Wide Transition Away from Conventional Housing. Available online: http://www.eggfarmers.ca/press/egg-farmers-of-canada-announces-industry-wide-transition-away-from-conventional-housing/ (accessed on 13 January 2017).
  22. Lambton, S.L.; Knowles, T.G.; Yorke, C.; Nicol, C.J. The risk factors affecting the development of gentle and severe feather pecking in loose housed laying hens. Appl. Anim. Behav. Sci. 2010, 123, 32–42. [Google Scholar] [CrossRef]
  23. Lambton, S.L.; Nicol, C.J.; Friel, M.; Main, D.C.J.; McKinstry, J.L.; Sherwin, C.M.; Walton, J.; Weeks, C.A. A bespoke management package can reduce levels of injurious pecking in loose-housed laying hen flocks. Vet. Rec. 2013, 172, 423. [Google Scholar] [CrossRef] [PubMed]
  24. Decina, C.; Berke, O.; van Staaveren, N.; Baes, C.F.; Widowski, T.M.; Harlander-Matauschek, A. Feather damage in Canadian laying hens and its associations with alternative housing and management factors—A cross-sectional study. Unpublished work. 2018. [Google Scholar]
  25. Egg Farmers of Canada (EFC). Start Clean-Stay Clean; Egg Farmers of Canada: Ottawa, Canada, 2016. [Google Scholar]
  26. Environment and Climate Change Canada. Climate Trends and Variation Bulletin—Annual 2016; Environment and Climate Change Canada: Ottawa, ON, Canada, 2017.
  27. Campbell, D.L.M.; de Haas, E.N.; Lee, C. A review of environmental enrichment for laying hens during rearing in relation to their behavioral and physiological development. Poult. Sci. 2018. [Google Scholar] [CrossRef]
  28. Widowski, T.M.; Classen, H.; Newberry, R.C.; Petrik, M.; Schwean-Lardner, K.; Cottee, S.Y.; Cox, B. Code of Practice for the Care and Handling of Pullets, Layers, and Spent Fowl: Poultry (Layers): Review of Scientific Research on Priority Issues. Ph.D. Thesis, University of Saskatchewan, Saskatoon, SK, Canada, 2013. [Google Scholar]
  29. Appleby, M.C.; Duncan, I.J.H.; McRae, H.E. Perching and floor laying by domestic hens: Experimental results and their commercial application. Br. Poult. Sci. 1988, 29, 351–357. [Google Scholar] [CrossRef]
  30. Pokharel, B.B.; dos Santos, V.M.; Wood, D.; van Heyst, B.; Harlander-Matauschek, A. Laying hens behave differently in artificially and naturally sourced ammoniated environments. Poult. Sci. 2017, 96, 4151–4157. [Google Scholar] [CrossRef]
  31. Von Waldburg-Zeil, C.G.; van Staaveren, N.; Harlander-Matauschek, A. Do laying hens eat and forage in excreta from other hens? Animal 2018. [Google Scholar] [CrossRef]
  32. Oden, K.; Keeling, L.J.; Algers, B. Behaviour of laying hens in two types of aviary systems on 25 commercial farms in Sweden. Br. Poult. Sci. 2002, 43, 169–181. [Google Scholar] [CrossRef] [PubMed]
  33. Green, L.E.; Lewis, K.; Kimpton, A.; Nicol, C.J. Cross-sectional study of the prevalence of feather pecking in laying hens in alternative systems and its associations with management and disease. Vet. Rec. 2000, 147, 233–238. [Google Scholar] [CrossRef] [PubMed]
  34. Groot Koerkamp, P.W.G. Review on Emissions of Ammonia from Housing Systems for Laying Hens in Relation to Sources, Processes, Building Design and Manure Handling. J. Agric. Eng. Res. 1994, 59, 73–87. [Google Scholar] [CrossRef]
  35. Tauson, R. Management and housing systems for layers—Effects on welfare and production. Worlds. Poult. Sci. J. 2005, 61, 477–490. [Google Scholar] [CrossRef]
  36. Lohmann Tierzucht. Lohmann LSL-Lite—Layers Management Guide. North American Edition—Cage Housing. Available online: http://www.hylinena.com/UserDocs/products/Lohmann_LSL-Lite.pdf (accessed on 1 March 2017).
  37. Hendrix Genetics. Dekalb White Product Guide Alternative Production Systems. Available online: https://www.dekalb-poultry.com/documents/18/DW_cs_c_leaflet_L7150.pdf (accessed on 1 March 2017).
  38. Gilani, A.-M.; Knowles, T.G.; Nicol, C.J. The effect of rearing environment on feather pecking in young and adult laying hens. Appl. Anim. Behav. Sci. 2013, 148, 54–63. [Google Scholar] [CrossRef]
  39. Kaufmann-Bart, M.; Hoop, R.K. Diseases in chicks and laying hens during the first 12 years after battery cages were banned in Switzerland. Vet. Rec. 2009, 164, 203–207. [Google Scholar] [CrossRef] [PubMed]
  40. Hy-Line. Hy-Line Management Guide Brown Commercial Layers. Available online: https://www.hyline.com/userdocs/pages/BRN_COM_ENG.pdf (accessed on 10 August 2018).
Table 1. A description of general farm characteristics for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 1. A description of general farm characteristics for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
No. of hens
Less than 100000.000.000.0
1000–500000.000.000.0
5000–10,000535.7654.6225.0
10,000–15,00017.119.1225.0
15,000–20,00000.0218.2112.5
20,000–25,00017.100.000.0
More than 25,000750.0218.2337.5
Age of system
Less than 1 yr00.000.000.0
1–4 years214.3666.7571.4
5–10 years214.3111.1114.3
More than 10 years1071.4222.2114.3
Table 2. Distribution of perches and enrichment provision for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 2. Distribution of perches and enrichment provision for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
Perches
Yes00.0981.88100.0
No14100.0218.200.0
Perches at different heights 1
YesNANA675.08100.0
NoNANA225.000.0
Space to perch at the same time 1
YesNANA666.7360.0
NoNANA333.3240.0
Enrichment provided
Yes00.0220.0112.5
No14100.0880.0787.5
1 Only answered by farmers who indicated that they provided perches.
Table 3. Summary of litter management aspects for pullet flocks placed between May and November 2017 according to housing system (single-tier n = 11, multi-tier n = 8) in Canada.
Table 3. Summary of litter management aspects for pullet flocks placed between May and November 2017 according to housing system (single-tier n = 11, multi-tier n = 8) in Canada.
VariableSingle-TierMulti-Tier
n%n%
Type of barn
All litter barn1090.900.0
Combination of wire, slats and litter19.18100.0
All wire/slatted barn00.000.0
Proportion of barn with litter 1
<1/3 of barn1100.0225.0
1/3 of barn00.0337.5
>1/3 of barn00.0337.5
Type of litter
Sand00.000.0
Wood shavings/sawdust763.6571.4
Straw218.200.0
Combination of the above19.100.0
None/manure19.1228.6
Litter replaced after first access
Yes00.000.0
No11100.08100.0
Frequency of breaking up of litter
Never1090.9675.0
Seasonally00.000.0
Monthly19.1225.0
Weekly00.000.0
Daily00.000.0
1 Only answered by farmers who indicated that they had a barn with ‘combination of wire, slats and litter’.
Table 4. Frequency of nutrition and feeding practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 4. Frequency of nutrition and feeding practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
Feed structure
Mashed feed857.111100.0675.0
Pelleted feed214.300.0112.5
Grains00.000.0112.5
Crumbs428.600.000.0
Feed source
Home-milled642.9654.6337.5
Purchased857.1545.5337.5
Combination00.000.0225.0
No. of times diet has been changed
No changes214.3218.200.0
17.1218.2112.5
00.0218.2225.0
428.6218.200.0
535.7327.3225.0
More than 4×214.300.0337.5
Method of changing diet 1
Gradual change541.7777.8675.0
Immediate change758.3222.2225.0
Midnight feeding
Yes17.100.000.0
No1392.911100.08100.0
Supplements provided
No650.0327.3233.3
Yes650.0872.7466.7
Insoluble grit 200.019.1116.7
Insoluble fibre 2325.0218.2233.3
Oyster shell 2216.7218.200.0
Vitamins 2325.0763.6350.0
Animal by-products in feed
Yes538.500.0337.5
No861.511100.0562.5
1 Only answered by farmers who indicated that they had changed the diet of the flock. 2 Those farmers who indicated that they provided supplements were asked to indicate if they provided: insoluble grit, insoluble fiber, oyster shell, and/or vitamins.
Table 5. Frequency of environmental control practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 5. Frequency of environmental control practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-Tier Multi-Tier
n%n%n%
Type of lighting
Incandescent428.6436.4112.5
Fluorescent428.619.100.0
LED642.9654.6787.5
Dawn/dusk period provided
Yes857.1654.68100.0
No642.9545.500.0
Method of dawn/dusk provision 1
All lights dimmed787.5583.3225.0
Gradual dimming by area112.5116.7675.0
Light intensity
Less than 5 lux327.3220.0233.3
5–10 lux327.3660.0116.7
11–15 lux436.4110.0350.0
16–20 lux00.000.000.0
21–25 lux00.000.000.0
More than 25 lux19.1110.000.0
Type of ventilation
Controlled (fan)14100.0872.78100.0
All natural00.000.000.0
Combination (fan + natural)00.0327.300.0
Manure removal
1× per day214.300.000.0
3× per week321.400.000.0
2× per week428.6110.0450.0
1× per week428.600.0112.5
Every 3 weeks17.100.000.0
End of flock00.0990.0337.5
1 Only answered by farmers who indicated that they provided a dawn/dusk period.
Table 6. Frequency of flock characteristics for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 6. Frequency of flock characteristics for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
Feather colour
Brown216.7763.6450.0
White1083.3436.4450.0
Breed
Dekalb White19.100.0233.3
Hisex Brown00.019.100.0
H&N Nick Chick218.219.100.0
Hy-line Brown19.119.100.0
ISA Brown00.019.100.0
Lohmann Brown Classic00.019.1116.7
Lohmann Brown Lite19.1218.2233.3
Lohmann LSL Lite545.5327.3116.7
Novogen00.019.100.0
Shaver19.100.000.0
Table 7. Description of flock rearing and placement practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 7. Description of flock rearing and placement practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
Supply farm
Own laying farm1178.6654.6450.0
External laying farm(s)17.100.0112.5
Combination214.3545.5337.5
Discuss rearing with laying farm
Yes1392.9981.8583.3
No17.1218.2116.7
Match conditions barn to laying
No214.319.100.0
Yes1285.71090.98100.0
Housing 1866.7880.0675.0
Perches 100.0660.0450.0
Litter 1216.7550.0562.5
Feed 112100.0990.0787.5
Environment 112100.0990.0787.5
Slats 100.0220.000.0
1 Those farmers who indicated that they matched conditions between rearing and laying facilities were asked whether they do this for the following aspects: housing, perches, litter, feed and environment.
Table 8. Frequency of flock health management practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
Table 8. Frequency of flock health management practices for 33 pullet flocks placed between May and November 2017 according to housing system (cage n = 14, single-tier n = 11, multi-tier n = 8) in Canada.
VariableCageSingle-TierMulti-Tier
n%n%n%
No. of bird inspections per day
214.319.1112.5
857.1654.6450.0
214.3327.3337.5
00.000.000.0
00.000.000.0
More than 5×214.319.100.0
No. of workers
1 worker964.3654.6675.0
2 workers428.6545.5225.0
3 workers17.100.000.0
More than 3 workers00.000.000.0
Average time spent on inspection per day
Less than 15 min17.119.100.0
15–30 min428.6327.3337.5
30–45 min214.3545.5112.5
45–60 min428.6218.2450.0
More than 60 min321.400.000.0
Vary route during inspections
Yes857.1770.0675.0
No642.9330.0225.0
Flock health plan implemented
Yes753.9327.3450.0
No646.2872.7450.0
Vaccination of birds
Marek’s disease14100.0990.08100.0
Newcastle disease14100.010100.08100.0
Infectious bronchitis1392.910100.08100.0
Avian encephalomyelitis1285.7777.8787.5
Infectious bursal disease1178.6880.0675.0
E. Coli428.6770.08100.0
Coccidiosis428.6440.0562.5
Salmonella428.6220.0337.5
Fowl pox214.300.0337.5
Infectious laryngotracheitis214.3220.0225.0
Mycoplasmosis00.000.000.0
Infectious coryza00.000.000.0
Fowl cholera (pasteurellosis)00.000.000.0
Egg drop syndrome00.000.000.0
Avian pneumovirus00.000.000.0
Diseases observed since placement
Yes214.3111.1112.5
No1285.7888.9787.5

Share and Cite

MDPI and ACS Style

van Staaveren, N.; Decina, C.; Baes, C.F.; Widowski, T.M.; Berke, O.; Harlander-Matauschek, A. Housing and Management Practices on 33 Pullet Farms in Canada. Animals 2019, 9, 49. https://doi.org/10.3390/ani9020049

AMA Style

van Staaveren N, Decina C, Baes CF, Widowski TM, Berke O, Harlander-Matauschek A. Housing and Management Practices on 33 Pullet Farms in Canada. Animals. 2019; 9(2):49. https://doi.org/10.3390/ani9020049

Chicago/Turabian Style

van Staaveren, Nienke, Caitlin Decina, Christine F. Baes, Tina M. Widowski, Olaf Berke, and Alexandra Harlander-Matauschek. 2019. "Housing and Management Practices on 33 Pullet Farms in Canada" Animals 9, no. 2: 49. https://doi.org/10.3390/ani9020049

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop