Microbial Burden Estimation of Food Items, Built Environments, and the International Space Station Using Film Media

The use of film media involves considerably less preparation, waste, and incubator space than conventional agar-media-based assays and has proven in past studies to provide counts of cultivable microbes similar to those of traditional agar media. Film media also have the advantage of allowing sample volumes similar to those used in pour plates and, therefore, are well-suited for cultivable microbial counts in extremely low-biomass environments such as clean rooms or space habitats, particularly where the subsequent isolation of colonies is necessary. As the preparation of film media plates relies on water cohesion/adhesion rather than manual spreading, they may have future applications in low- or microgravity settings. In this study, cultivable microbial count performance was compared between agar media and film media in three kinds of samples: food items, surfaces in built environments on Earth (homes), and on the environmental surfaces of the International Space Station (ISS). Easy Plates (Kikkoman Corporation) and Petrifilm (3M) were compared with traditional agar plating for food and home surfaces, while only Easy Plates were compared with agar for ISS samples. For both food items and built environments on Earth, both types of film media performed comparably to agar media for bacterial counts, with R² values of 0.94–0.96. Fungal counts for built-environment samples had a lower correlation between film and agar counts, with R² values of 0.72–0.73. Samples from the ISS, which ranged from below detection to 10³ CFU per 100 cm², had R² values of 0.80 for bacterial counts and 0.73 for fungal counts, partially due to multiple samples recording below the detection limit for agar or too numerous to count, and the growth of fungal species on R2A medium. The species compositions of isolates picked from agar vs. film media plates were similar; however, further phylogenetic analysis is needed to confirm the differential microbial diversity composition. Overall, film media such as Easy Plates and Petrifilm are viable alternatives to agar plates for low-biomass built environments as well as for food samples, and the two brands tested in this study performed equally well.