1. Introduction
Playing a critical role in the national economy, the transportation sector is presented with significant challenges, such as associated environmental issues [
1]. Due to rapid economic development and urbanization, there has been a boom in road transportation in China. At the end of 2020 [
2], the total number of vehicles in China amounted to 372 million. In India [
3], rapid economic growth and massive urbanization has significantly promoted transport emissions. The transport sector consumes 29% of total energy demand, with the dominant 93% share being oil. Along with the large amount of energy consumption, traffic emissions are also high. Among them, 74% of transport emissions are from road transportation. Recent studies show that traffic-related air pollution is causing wide and urgent concern worldwide, especially in large developing countries and regions [
4,
5,
6,
7]. All around the world, road freight is one of the largest contributors to energy consumption and exhaust emissions. According to WHO’s report, the most serious atmospheric pollutants are particulate matter (PM
10 and PM
2.5), nitrogen oxides (NO
X) and ground-level ozone (O
3), which are harmful tohuman health. From the China Mobile Source Environmental Management Annual Report 2021 [
2], PM (Particulate Matter) and NO
X (Nitrogen Oxide) emitted by trucks are of a significantly higher level than that of passenger vehicles in China. Heavy-duty trucks (HDTs), with a total mass of 14 tons or more, are mainly used in logistics enterprises in China. The maintenance of exhaust after-treatment devices of trucks is largely overlooked. As a result, it is very difficult to monitor and control emissions derived from HDTs. As shown in
Figure 1, there are around 7.62 million HDTs in China, which account for 3.00% of the total number of vehicles. However, these HDTs contribute to 33 thousand tons of PM and 4630 thousand tons of NO
X, which accounts for 52.1% and 75.4% of the total emissions from all vehicles, respectively. It is worth noting that PM
2.5 is one of key pollutants in atmospheric pollution in China, and NO
X is a major precursor of regional O
3 and secondary PM
2.5 [
8,
9,
10]. With new national air quality standards taking effect, PM
2.5 and NO
X have become the focus of the future pollution control [
11].
Vehicle classification, retention and emissions are based on the China Mobile Source Environmental Management Annual Report 2021 released by the Ministry of Ecology and Environment of the People’s Republic of China [
2]. Given that the unit of emissions is 10,000 tons, the amounts of NO
X and PM emitted by mini trucks and mini buses are less than 0.001, displayed here approximately as zero.
There are a number of advantages associated with the use of natural gas as a transportation fuel. These include wide availability, cost savings and environmental friendliness [
12]. There are two forms of natural gas as a vehicle fuel: compressed natural gas (CNG) and liquefied natural gas (LNG) [
13].
The primary fuels of HDTs include gasoline and diesel. There are some choices of substitutions for conventional fuels. While electric vehicles have advantages in environmental protection, due to their significant reduction of emissions per kilometer traveled as compared with conventional vehicles, they are only suitable for light-duty vehicles [
14,
15]. In addition, CNG’s energy density is too low to maintain the power of HDTs. The advantages of LNG are safety and environmentally friendliness, while its supply safety is just behind diesel and gasoline. Therefore, LNG has become the priority of alternative vehicle fuels in many countries. In addition, the ratio of natural gas in energy supply has increased rapidly.
Shenzhen, a megacity in south China, has transformed from a small fishing village with 60,000 residents in the 1980s to an international city with over 17.49 million permanent population in 2020 [
16]. Neighboring the Hong Kong Special Administrative Region, it has become China’s first and the most successful Special Economic Zone. Shenzhen’s gross domestic product (GDP) reached 2767.0 billion RMB by the end of 2020 [
17]. As a demonstration city for the national low-carbon strategy, Shenzhen is facing significant environmental challenges similar to other megacities in China, while much attention has been paid to the reduction of PM
2.5 at the city scale. Local official statistics revealed that the mileage of urban roads and turnover volume of freight and passenger transport in Shenzhen have increased rapidly due to the rapid economic and social development in the area [
17]. Transport has been recognized by the Shenzhen government as a key factor to achieve the goal of urban energy-saving and air quality improvement. The complexity associated with environmental issues has led to much controversy in both environmental policies and the role of the transport sector. Specifically, the Shenzhen government has made a lot of efforts to promote LNG HDTs to replace existing diesel HDTs in the road freight since 2015. The promotion scale aims for up to 15,000 HDTs before 2020, which will be one of the largest LNG truck promotion programs in urban areas around the world [
18]. In 2018, Shenzhen issued relevant policies to subsidize LNG HDTs, which once again promoted their development [
19].
Natural gas vehicles (NGVs) have played a critical role to improve the air quality of urban areas around the world, e.g., America, Canada, Europe and China [
20,
21]. NGVs mainly includes school buses, waste haulers and buses especially, since travel distances are relatively short and a central refueling network already exists [
21]. In China, CNG buses and LNG buses were introduced to the bus fleet in Beijing in 1999 and 2012, respectively [
22,
23]. There are a number of advantages associated with LNG buses compared to their CNG counterparts, such as higher energy density, lower investment in supporting infrastructure and longer service life [
24]. In the United States, the number of urban buses powered by natural gas (including CNG and LNG) has tripled between 2000 and 2015 [
25,
26]. An analysis of technology and policy tradeoffs indicated that NGVs could have significant market penetration in Class 7–8 trucks in the United States depending on technological and economic uncertainties [
20], which provides a good reference for China, to some extent.
From an environmental perspective, the engine type of HDTs is almost the same as ignition natural gas (NG) buses, and emission patterns are also similar to these vehicles due to their similar characteristics [
27]. Natural gas engines have been used in urban transit buses as an alternative to diesel engines due to their lower PM and NO
X emissions [
28,
29]. The regular emissions from spark NG engines are much lower than the emissions from the latest technology diesel engines with after-treatment devices, measured by chassis dynamometer testing facilities [
30,
31]. By using dual fuel mode (e.g., natural gas and diesel), NO
X and PM emissions can be reduced significantly compared with normal diesel combustion [
12]. Guo et al. (2014) found that NG buses perform better than diesel buses in terms of lower NO
X and PM emissions, fewer particles and smaller particle mass [
22]. The PM
2.5 emitted from an LNG vehicle is smaller than that from a diesel vehicle [
32]. Similarly, CNG and LNG technologies also help to reduce the NO
X emissions by as high as 73% compared to Euro-V diesel buses [
9].
Some studies attempted to evaluate greenhouse gas (GHG) mitigation potentials. Tong et al. (2015) compared the life cycle GHG emissions from medium and heavy-duty trucks using natural gas as fuel. Their study indicated that two of the key approaches to reducing GHG emissions from natural gas-fueled media and heavy-duty trucks are improving the fuel efficiency and reducing the methane leakage rate [
31,
33]. Zhang et al. (2014) investigated the fuel consumption and CO
2 emissions of urban public buses in Beijing that used various fuel systems (e.g., conventional diesel, natural gas and diesel hybrid). Natural gas buses have slightly lower CO
2 emission factors but higher fuel consumption relative to diesel buses [
23,
34]. In Europe, the transport sector plays a critical role in the GHG emissions mitigation strategy. Arteconi et al. (2010) compared the life cycle of GHG emissions of heavy-duty vehicles in the European market that used diesel and LNG as fuels. Their study suggested that a 10% reduction of GHG emissions can be achieved by using LNG compared to the diesel option [
13]. This is in line with Graham et al. (2008)’s study that GHG emissions of heavy-duty vehicles can be reduced by as high as 20% when switching diesel to natural gas [
35]. Osorio-Tejada J et al. (2017) found that LNG trucks would be an attractive option compared to diesel oil and hydro-treated vegetable oil (HVO) on the premise of environmental priority and government policy support [
36].
In summary, previous studies mainly focused on the emissions reduction of a single HDT for LNG substitution while the policy promotion at the city level was largely overlooked. Thus, this study attempts to fill this gap by focusing on the evaluation of economic and environmental advantages by promoting LNG HDTs at the city level. Normally, alternative fuel vehicles provide fleet operators novel opportunities to reduce fuel costs and emissions. However, fleet operators may be unfamiliar with the performance and costs associated with these vehicles. In this paper, by taking Shenzhen city as an example, a Monte Carlo simulation method is combined with Shenzhen Atmospheric Environmental Quality Improvement Plan (SAEQIP). Then, the economic and environmental effects of the development of LNG HDTs in road freight are predicted dynamically. Using the results obtained, we can finally put forward policy suggestions for developing a cleaner road freight industry.
3. Methodology
The promotion of LNG HDTs in Shenzhen’s road freight industry is one of the largest-scale promotion programs around the world. A lot of efforts are required to ensure the efficiency of this program, e.g., government subsidies and voluntary participation by freight fleet operators. Therefore, it is imperative to conduct an economic and environmental analysis of this program. The main focus of the economic analysis is the vehicle cost, with the main indicators being the annual cost and breakeven year of various types of HDTs. Similarly, the environmental analysis mainly focuses on pollutants, such as PM2.5 and NOX, adopting the MOVES model.
3.1. Economic Analysis Methods
Container tractors, engineering dump trucks, and engineering mixer trucks are typical types of LNG vehicles to be promoted in the road freight. To analyze the economic benefits of LNG HDTs compared with diesel HDTs, the first step is to investigate their purchase, maintenance and fuel consumption through a variety of methods, such as an official database, and field survey. Official data sources mainly include the Shenzhen Statistical Yearbook and Shenzhen Port and Freight Management Bureau statistical reports. Field surveys were conducted among ports, freight enterprises and market dealers, including vehicle properties and operating features.
One of the critical factors during the decision-making process for the replacement of diesel HDTs with LNG HDTs is cost-effectiveness [
42]. The annual cost per vehicle is a critical indicator of economic benefits. The cost of HDTs mainly consists of purchase cost and operational cost. In terms of purchase cost, LNG HDT cost is higher than diesel HDT cost in the same configuration. This difference is mainly due to the type of engine and fuel tank. As for operational cost, this consists of maintenance cost (includes the cost of regular maintenance and unscheduled repair) and fuel cost (dependent on fuel price and use intensity).
Operating features vary according to types of HDTs. Therefore, different indicators should be used to calculate the use intensity. VKT is the most appropriate indicator for container tractors and engineering dump trucks. For engineering mixer trucks, operational time per year is the most appropriate indicator. The engine is running and emitting pollutants all the time during the transportation process, because it not only makes the vehicle run but also keeps the mixer tank rotating to maintain the concrete’s liquid state [
43].
In this study, vehicle purchase cost is distributed among service life to obtain the annual purchase cost. Furthermore, the average annual purchase cost and operational expense are summed to facilitate the comparative analysis of LNG and diesel vehicles.
- (1)
Container tractors & engineering dump trucks
where
i represents the fuel type of each vehicle (LNG or diesel);
represents the annual cost of each vehicle powered by fuel
i (USD/year);
represents the purchase cost of each vehicle powered by fuel
i (USD);
represents the service life of the vehicle (years);
represents the annual average maintenance cost of each vehicle powered by fuel
i (USD/year);
represents the price of fuel
i per kilometer (USD/km);
is the annual average vehicle mileage (km/year) [
44].
- (2)
Engineering mixer trucks
where
i represents the fuel type of vehicle (LNG or diesel);
represents the annual cost of each vehicle powered by fuel
i (USD/year);
represents the purchase cost of each vehicle powered by fuel
i (USD);
represents the service life of this vehicle (years);
represents the annual average maintenance cost of each vehicle powered by fuel
i (USD/year);
represents the average daily fuel cost of each vehicle powered by fuel
i;
is the average vehicle operating days per year (day/year).
The break-even year is another important indicator for road freight enterprises. As the purchase cost of LNG HDTs is higher than that of diesel HDTs, the return on investment is a common consideration to be taken. The breakeven year is influenced by a number of factors, most of which are non-determined factors. Therefore, the breakeven year is simulated through the Monte Carlo method with the assistance of Crystal Ball software in this study. A number of factors were considered during the simulation process such as subsidy, vehicle type, fuel price, use intensity and fuel consumption rate.
3.2. Environmental Analysis Methods
A variety of air pollutants are emitted by vehicles such as PM
2.5, NO
X, hydrocarbons (HC) and carbon monoxide (CO). The PM
2.5 and NO
X emissions derived from HDTs account for over 50% of the total emissions in Shenzhen. A series of measures were taken to improve air quality, with the main focus being on the reduction of PM
2.5 and NO
X. Therefore, this study focuses on the reduction of these two pollutant emissions by means of promoting LNG or China-V diesel HDTs instead of original diesel HDTs. The emissions from vehicles are calculated as follows:
where
i represents pollutant type (PM
2.5 and NO
X in this study);
j represents fuel type (LNG or diesel);
k represents the emission standard (corresponding to China-I, China-II, China-III, China-IV and China-V standard);
is the vehicle emissions of pollutant
i (ton/year);
is the number of emission standard
k vehicles using fuel
j;
is the emission factor of pollutant
i of emission standard
k vehicles using fuel
j (g/km);
CF is the correction factors of emission factor;
is the annual average vehicle mileage traveled of fuel
j vehicle (km/year) [
45].
Vehicle emission factor is affected by a large number of factors, such as engine technology, fuels, local meteorological conditions and driving patterns. Local meteorological adjustment factors can significantly affect vehicle emissions, including temperature, humidity and altitude. Since Shenzhen neighbors the South China Sea, there is no need to take altitude into consideration. The temperature and humidity factors were taken into account by referring to the technical guide released by the Ministry of Environmental Protection.
3.3. Introduction of MOVES Model and Parameters Settings
MOVES (Motor Vehicle Emission Simulator) is a traffic emission calculation model developed by United States Environmental Protection Agency (EPA, Washington, DC, USA). This model provides an accurate estimate of vehicle emissions at several scales, which has been developed over 20 years and widely adopted since [
46,
47]. In this paper, the latest revision, MOVES 2014, was selected to calculate traffic emissions under different conditions. In the MOVES model, four key components were used in the following calculations: Total Activity Generator (TAG), Operating Mode Distribution Generator (running OMDG), Source Bin Distribution Generator (SBDG), and Emission Calculator. In SBDG, the source bin takes vehicle type, age, load, engine type and fuel type into consideration.
3.3.1. Vehicles’ Parameters Settings
In this paper, typical LNG HDTs and diesel HDTs, with the same horsepower and configuration meeting the China-V emission standard, of three types of HDTs were chosen and compared. According to the most common vehicle brand in Shenzhen, a questionnaire survey was conducted among local market dealers in different districts of Shenzhen, including model number, purchase cost, horsepower and drive type. By calculation, the average purchase costs of different vehicle types were obtained. The information of these vehicles is shown in
Table A1.
The operating parameters of HDTs mainly include four parts: vehicle maintenance cost, use intensity, service life and fuel consumption rate. Fuel consumption rate, service life and maintenance cost were collected from the Shenzhen Port and Freight Transportation Management Bureau. Vehicles in different enterprises may have different use intensity since their diverse performance. Therefore, the intensity is assigned with three kinds of value, namely the minimum value, the likeliest value and the maximum value, which are obtained by means of expert consultation (see
Table A2).
3.3.2. The Prices of Fuels
The past 2 years witnessed a significant fluctuation of fuel prices in China. The fuel prices of diesel and LNG in the past 2 years were collected from the China National Offshore Oil Corporation Shenzhen Gas Energy Co., Ltd., one of the largest automotive LNG suppliers in Shenzhen (See
Figure A1).
LNG price is closely linked to the diesel price following the form of Equation (4).
where
represents the price of LNG (USD/kg);
represents the price of diesel in the market (USD/L);
is a coefficient set by the pricing mechanism established by government for new energy industrial development, its value is stabilized at 0.955 with minor change.
3.3.3. Characteristics of Meteorological Conditions
The statistical characteristics of meteorological features in 2016 are shown in
Table A3. The humidity was above 50% across the whole year. A temperature of 25
was taken as the critical value. The high-temperature season was classified as those days with an average temperature of higher than 25
(from May to October). The rest of the year was classified as the low-temperature season (from November to April of next year). The emissions during these two types of seasons were calculated separately, which were summed to the annual pollutant emissions.
5. Conclusions and Recommendation
In this paper, the economic and environmental benefits of the promotion of LNG HDTs program at the city scale were characterized by using Shenzhen as a case study. LNG HDTs have the advantage of saving considerable fuel costs compared to diesel HDTs, ranging from 10% to 17%. Meanwhile, the promotion of LNG HDTs could significantly reduce PM2.5 and NOX emissions of HDTs, by 36.0% and 16.3% respectively. To summarize, the effectiveness of the promotion of LNG HDTs is significant in Shenzhen city, and these findings could provide references for other cities, particularly port cities, to firmly promote LNG HDTs and beyond.
In order to promote LNG vehicles in the freight industry, two policy measures could be considered. (1) Policy and financial support need to be intensified so as to optimize the quantity and layout of LNG fueling stations. The major obstacles to developing LNG fueling stations include available land for the construction, huge investment and a complicated approval process. Therefore, the government should issue a series of policies and financial support, such as the introduction of private investment, the prioritization of land use and a new approval process for LNG fueling stations. If the security of supply is weak and diversification targets do not meet the requirement of the city, new LNG terminals should be installed on the city outskirts. (2) The market behavior of freight fleet operators could be directed towards LNG HDTs rather than diesel HDTs. Moreover, the advantages of LNG HDTs (e.g., the performance, costs and environmental friendliness) should be publicized properly and effectively. On the other hand, the LNG/diesel price ratio has gradually adjusted to a lower rate and policies need to be strengthened on LNG HDT purchase subsidies. In particular, the subsidy for replacing aging HDTs with LNG vehicles should higher than normal, to accelerate the elimination of aging automobiles to guarantee the goal of reduction of total vehicle emissions while maintaining vehicle fleet growth.
Overall, the potential economic and environmental benefits of LNG HDTs for megacities were analyzed in this study. The findings and recommendations provide useful inputs for the policy-making process. This paper also provides a guiding development framework for promoting LNG HDTs. This is of high relevance to other cities in China and even other countries with an interest in promoting LNG HDTs. However, when borrowing experience from the Shenzhen case, the uniqueness of Shenzhen’s conditions should be fully considered. First, natural gas has been promised as a cleaner energy for the whole country in the near future, and promoting natural gas vehicles is an important aspect of this. However, the reasonableness of developing LNG HDTs should be seriously considered in areas where natural gas supply cannot be guaranteed. Second, the government plays an important role in LNG pricing policy and in keeping LNG prices lower than diesel. In countries where natural gas pricing is market-oriented, the situation would be quite different. Third, policy and regulations are critical for every aspect of promoting LNG HDTs in China, where the government dominates resource allocation. LNG HDT subsidy policy and infrastructure issues are all substantially affected by policies. In other countries, this could be a totally different story.
There are some limitations associated with the macro level approaches proposed in this study: (1) Our approach was concise, and mainly analyzed economic and environmental benefits on the macroscopic level. Some non-critical aspects, such as average load of HDT, were not taken into consideration. (2) The investigation has constraints. Sample sizes, which obtained vehicle property information and operating features, were not big. Even some of the data were obtained through expert consultation. As a result, the triangular distribution was used in a Monte Carlo simulation, instead of normal distribution. (3) The data used to determine the unit emission factors for each type of HDT were taken from governmental databases and may not necessarily be sufficient to represent the current and rapid change in the transportation sector of Shenzhen. Furthermore, many earlier studies of real-world emissions can differ quite a lot from ones based on emission standard requirements. Indeed, extensive data on vehicles is necessary for a detailed study of the transport sector. In the future, this evaluation model could be further improved by expanding its scale, type and variety of impacts. Other critical factors such as rate of inflation, technology, fuels and driving patterns could also be incorporated in future studies.