Next Article in Journal
Preparation of PVA Fluorescent Gel and Luminescence of Europium Sensitized by Terbium (III)
Next Article in Special Issue
Effect of Bis (2-Aminoethyl) Adipamide/Adipic Acid Segment on Polyamide 6: Crystallization Kinetics Study
Previous Article in Journal
Tailoring the Thermal and Mechanical Properties of PolyActiveTM Poly(Ether-Ester) Multiblock Copolymers Via Blending with CO2-Phylic Ionic Liquid
Previous Article in Special Issue
Melting Kinetics of Nascent Poly(tetrafluoroethylene) Powder
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Pyrolysis of Low Density Polyethylene: Kinetic Study Using TGA Data and ANN Prediction

Department of Chemical Engineering, King Faisal University, Al-Ahsa 31982, P.O. Box 380, Saudi Arabia
*
Author to whom correspondence should be addressed.
Polymers 2020, 12(4), 891; https://doi.org/10.3390/polym12040891
Submission received: 7 March 2020 / Revised: 5 April 2020 / Accepted: 8 April 2020 / Published: 12 April 2020
(This article belongs to the Special Issue Thermal Analysis of Polymer Materials)

Abstract

:
Pyrolysis of waste low-density polyethylene (LDPE) is considered to be a highly efficient, promising treatment method. This work aims to investigate the kinetics of LDPE pyrolysis using three model-free methods (Friedman, Flynn-Wall-Qzawa (FWO), and Kissinger-Akahira-Sunose (KAS)), two model-fitting methods (Arrhenius and Coats-Redfern), as well as to develop, for the first time, a highly efficient artificial neural network (ANN) model to predict the kinetic parameters of LDPE pyrolysis. Thermogravimetric (TG) and derivative thermogravimetric (DTG) thermograms at 5, 10, 20 and 40 K min−1 showed only a single pyrolysis zone, implying a single reaction. The values of the kinetic parameters (E and A) of LDPE pyrolysis have been calculated at different conversions by three model-free methods and the average values of the obtained activation energies are in good agreement and ranging between 193 and 195 kJ mol−1. In addition, these kinetic parameters at different heating rates have been calculated using Arrhenius and Coats-Redfern methods. Moreover, a feed-forward ANN with backpropagation model, with 10 neurons in two hidden layers and logsig-logsig transfer functions, has been employed to predict the thermogravimetric analysis (TGA) kinetic data. Results showed good agreement between the ANN-predicted and experimental data (R > 0.9999). Then, the selected network topology was tested for extra new input data with a highly efficient performance.

Graphical Abstract

1. Introduction

Nowadays, plastic wastes have become an annoying global problem, especially in countries where a huge quantity of plastic wastes is produced and disposed. There are many academic research centers attempting to find a suitable way to recycle such vast wastes. Miskolczi et al. [1] mentioned that 65%–70% of plastic wastes in the world are disposed in landfills, and the remaining 30%–35% are incinerated. Both landfills and incineration are expensive and unfavorable for different reasons, including, but are not limited to, environmental concerns [2]. Therefore, recycling, which is the economic reuse of material and energy from wastes, is a favorable alterative. Although the term “recycling” was applied mostly to municipal solid wastes (MSW), it has been used for industrial and other generated wastes as well. Plastic wastes are increasing dramatically. MSW is considered to be the main source of plastic wastes and low-density polyethylene (LDPE) represented about 22.7 wt% of plastics in MSW [3].
Since the combustion as a “primary” recycling method is subjected to some problems environmentally, “secondary” recycling (like grinding) is again limited to only 20 wt% of the plastic wastes [4]. Therefore, most of the current research effort is focusing on “tertiary” recycling, which requires more advanced techniques such as pyrolysis and catalytic degradation [4]. Thermal decomposition of plastic wastes by pyrolysis has certain advantages over other forms of waste treatment methods since all its products can be used as fuel [5]. Another advantage of pyrolysis is the notable volume reduction of the gaseous products [5], and it can be conducted at a low temperature when the catalyst is used [6,7].
Kinetic parameters such as activation energy of the pyrolysis process are mandatory for the reactor design. Therefore, evaluation of the thermogravimetric analysis (TGA) data for the pyrolysis of LDPE has attracted the attention of some researchers. Activation energy (E) of the LDPE pyrolysis was targeted to be calculated from TGA data at different heating rates using different model-free methods. Some of the reported E values are presented in Table 1. Different values by different methods were reported.
For example, Das and Tiwari [15] investigated the LDPE pyrolysis at different heating rates. They used five different iso-conversional models: Friedman, Flynn-Wall-Qzawa (OFW), Kissinger-Akahira-Sunose (KAS), Starink and advanced iso-conversional (AIC) models. Different ranges of E values were reported for each method: Friedman (178–256 kJ mol−1), OFW (165–242 kJ mol−1), KAS (162–242 kJ mol−1), Starink (148–222 kJ mol−1), and AIC (170–231 kJ mol−1).
Recently, most researchers have been aiming to develop an artificial neural network (ANN) model for the prediction of different data since it showed a powerful performance to represent linear and non-linear relationship and hence save time. Therefore, ANN is used as another alternative technique to support the prediction of TGA data.
Conesa et al. [16], who are the pioneers in using ANN for TGA data, initiated a new method to study the thermal decomposition kinetics of different materials at different heating rates using TGA data. They applied the multilayer ANN model for the published experimental data. Yıldız et al. [17] studied the co-combustion of coal blends of various composition by applying ANN to the non-isothermal TGA data from 298 to 1273 K. In their network, temperature, blend ratio and heating rate were used as the input variables. Their results showed a good prediction indication. Çepelioĝullar et al. [18] developed an ANN model to predict the thermal behavior of TGA data of refuse-derived fuel with new input data. Heating rate and temperature were used as the input parameters and weight loss was set as the output parameter. For the best network topology, ANN model was optimized by checking different numbers of neurons, number of training data sets and type of transfer function. ANN with 7–6 neurons for both hidden layers and tansig-logsig non-linear function was reported as the best network.
Charde et al. [19] supported the TGA experimental investigation of the degradation of polycarbonate/CaCO3 composites using ANN for a quick determination of kinetic parameters. While conversion, temperature and time were the input variables, one of the kinetic triplets was the only output variable. The least mean squared error (MSE) and the highest Regression coefficients were used as the criteria for selecting the best ANN topology network.
Chen et al. [20] studied the co-combustion characteristics of different blends at different ratios of O2/CO2 using TGA. Mass loss percent was predicted as a function of gas mixing ratio, temperature and heating rate.
Recently, Naqvi et al. [21] implied an ANN model to predict the pyrolysis of high-ash sewage sludge and showed a good agreement between the predicted and experimental values.
This study aims to build knowledge of LDPE pyrolysis kinetics using TGA. The activation energy, as a function of conversion, of the thermal decomposed LDPE at four different heating rates has been estimated by three Model-free methods. In addition, the activation energy has been calculated using two Model-fitting techniques for each heating rate as well. Furthermore, pyrolytic behavior of LDPE has been predicted for the first time by a highly efficient developed ANN model (R ≈ 1.0).

2. Materials and Methods

2.1. Materials

LDPE black pellets, whose properties are presented in Table 2, were used. LDPE pellets were ground into powders by a grinding mill before feeding to the TGA system. Samples, weighting of 10 mg, were used throughout this study to avoid any error of discrepancy during the reproducibility of the collected data.

2.2. Thermal Decomposition of LDPE

TGA experiments were performed by a Perkin-Elmer TGA-7 thermal gravimetric analyzer (Perkin Elmer, Shelton, CT, USA). It consists of the following components: Thermogravimetric Analyzer, and 1020 system controller with 1020 thermal analysis software. TGA permits the measurement of weight changes in a sample material as a function of time or temperature. TGA was initially programmed from an initial temperature to a final temperature and weight changes due to chemical reaction in the sample were measured. The samples were purged with pure nitrogen gas and heated at 5, 10, 20 and 40 K min−1 in the temperature range of 298–873 K.

2.3. Kinetic Theory

Rate of reactions (r) can be expressed as follows [22]:
r = d α d t = K ( T ) f ( α )
α = w o w w o w f  
where α is conversion, t is time, K is the reaction rate constant, T is temperature, and wo, w and wf are the weight of the sample at initial time (t = 0), time t and at the end of the TGA experiment, respectively. The K value can be found from the Arrhenius relationship:
K ( T ) = A exp ( E R T   )
where A is the pre-exponential factor, E is the activation energy and R is the universal gas constant. For nth-order reactions:
f ( α ) = ( 1 α ) n
Substituting Equations (3) and (4) into equation (1) yields:
r = d α d t = A exp ( E R T   ) ( 1 α ) n
Estimation of the kinetic parameters from TGA data depends mainly on Equation (5). They can be obtained by different methods which are either “model-fitting” or “model-free” methods. They use either differential method (by including the term, dα/dt) or integral method by doing the integration.
Usually, when most of model-free equations are derived, the reaction order (n) is assumed to be first-order reaction [23]. However, the model-fitting methods are used for different reaction orders (n = 1, 2 or 3) [24]. Table 3 shows kinetic equations of three of the most used model-free methods and Table 4 represents equations of two widely used model-fitting methods [11,18,21,23,24,25,26].
Most of the published works for calculating kinetics parameters from TGA data focus on either model-free or model-fitting methods. However, in this work, both methods have been presented and compared with the available published data. One set implies multiple thermograms at different heating rates and constant conversion (model-free methods: Friedman (Equation (6)), FWO (Equation (7)) and KAS (Equation (8)). The other set implies only one single thermogram (model-fitting methods: Arrhenius (Equation (9)) and Coat-Redfern (Equation (11)).

2.4. Topology of ANNs

The traditional way of modelling any engineering process is to develop a model depending on parameters whose values are estimated from the process data. However, developing a model and estimating the parameters are not easy tasks in many cases. The task may turn out to be increasingly difficult when the system is complex with non-linear relationships. In such cases, the ANN becomes an alternative option.
An ANN architecture is typically organized in three layers of neurons: input, hidden and output. Each layer has a weight matrix, a bias vector and output vector [27]. Initially, one must fix all the variables that might have an influence on the result of the process. The data collection, usually done outside the ANN environment, must be representative and all the data must fall within the defined variation margin for each variable.
The architecture of ANN consists of number of layers, transfer function of each layer and the connection between the layers. The best architecture depends on the problem type to be modelled by the network. For better performance of ANNs, genetic algorithm should be implemented for optimizing parameters of the ANN such as number of neurons in hidden layers, number of hidden layers, the learning rate and the momentum rate [15].
The performance of an ANN model in predicting an output variable can be evaluated based on the following statistical correlations [28,29,30,31]:
R = Σ [ ( ( W % ) e x p ( ( W % ) e x p ) ¯ ) * ( ( W % ) e s t ( W % ) e s t ) ¯ ] Σ ( ( W % ) e x p ( ( W % ) e x p ) ¯   ) 2 * Σ ( ( W % ) e s t ( W % ) e s t ) ¯ ) 2  
R o o t   m e a n   s q u a r e   e r r o r   ( R M S E ) = 1 N   ( ( W   % ) e s t ( W   % ) e x p ) 2
M e a n   a b s o l u t e   e r r o r   ( M A E ) = 1 N | ( W   % ) e s t ( W   % ) e x p |
M e a n   b i a s   e r r o r   ( M B E ) = 1 N ( ( W   % ) e s t ( W   % ) e x p )
where R is the average correlation factor and (W %)exp, (W %)est, and ( W % ) ¯ are the experimental, ANN-estimated and average values of weight left %, respectively. In this investigation, mass loss of LDPE has been targeted to be predicted by a developed ANN model.

3. Results and Discussion

3.1. TG-DTG Analysis of LDPE

The TG and DTG thermograms of the LDPE pyrolysis at different heating rates are shown in Figure 1 and Figure 2, respectively. Generally, thermograms were identical at different heating rates. However, the thermal decomposition on-set, peak and final temperatures, extracted from the TG and DTG curves, were observed at higher temperatures as heating rate increased from 5 to 40 K min−1 as shown in Figure 1 and Figure 2. This range of heating rates is considered as a reasonable and moderate range compared with low range of heating rates (5, 10, 20 K min−1) [21] and high range of heating rates (100, 300, 500 K min−1) [24]. In addition, the decomposition rate increased as the heating rate increased. These figures show clearly that there was only one main reaction region for the pyrolysis of LDPE, which can be fitted by first-order straight line. Furthermore, the on-set, end-set and peak values, summarized in Table 5, increased as the heating rate increased as well.

3.2. Model-Free Kinetics Calculation

As mentioned earlier, Equation (5) is considered as the most essential equation from which the rest of kinetic equations can be derived.
In this section, three different type of iso-conversional (model-free) models were used to calculate some kinetic parameter (E and A). These models are reliable methods to obtain kinetic parameters from non-isothermal TGA data [9]. The fitted linear equations of Friedman, FWO and KAS at different conversions (ranging from 0.1 to 0.9) are shown in Figure 3, Figure 4 and Figure 5, respectively.
Table 6 shows the values of kinetic parameters (E and A) with the correlation coefficient (R2) obtained from the three methods (Friedman, FWO, and KAS) for the whole conversion range. Due to various mathematical formulation and approximations, the results differ slightly from each other at different conversions. However, the average values of the calculated activation energies were very close and ranging from 193 to 195 kJ mol−1 with R2 > 0.95. In addition, it can be reported that the obtained E values are neither function of conversion nor heating rate and this is in a good agreement with literature [11,23,26].

3.3. Model-Fitting Kinetics Calculation

If the activation energy is assumed to be constant over a specific temperature range, then its average value can be obtained from the slope of the plot of ln[(dW/dt)/W] versus 1/T (Arrhenius Equation (9)) and ln [-ln(1-α)/T2] against 1/T (Coats-Redfern (Equation 11)). The values of kinetic parameters (E and A) obtained by the two model-fitting methods are shown in Table 7.
Model-fitting methods include the reaction mechanism to get more kinetics parameters. In this work, only first order reaction mechanism is selected, since it is the most dominant mechanism [25,32].
The average calculated values of activation energies by Arrhenius (202 kJ mol−1, R2 < 0.96) and Coats-Redfern (196 kJ mol−1, R2 < 0.92) methods are slightly larger than the calculated values by the three model-free methods (Friedman, FWO and KAS) by less than 4%. However, all calculated values, by all the five models, are very close to some of the published values [9,10,15,16]. In addition, the A values, calculated by all five methods, increase as the E value increases and this is in a total agreement with the published data [24].

3.4. Pyrolysis Prediction by ANN Model

To our knowledge, a highly efficient ANN model was targeted to be developed for the first time to predict the thermal decomposition of LDPE. In the current study, a Feed-Forward Back-Propagation Neural Network (FFBPNN) was developed to predict the weight left % based on 154 experimental data sets. Heating rate (K min−1) and temperature (K) are the input variables for the proposed ANN model and the weight left % is the only output parameter from the network. The data sets were randomly divided into three groups as follows: 70% of the data sets were used for training, 15% for validation and 15% were used for testing.
Table 8 shows a performance comparison between different ANN structures based on numbers of hidden layers, numbers of neurons and transfer functions. The value of correlation coefficient (R) is considered as the main criterion for selecting the most efficient network structure for estimating the percentage weight left as the output variable. As shown in table below, a better performance was achieved as number of hidden layers increases. However, number of neurons in each hidden layer should be optimized to avoid over/under-fitting.
The final and best ANN structure is ANN12, shown in Figure 6, has 10 neurons in two hidden layers with logsig-logsig transfer functions. Levenberg-Marquardt algorithm was used for the network since this algorithm is recommended for moderate-size data [31]. However, the ANN program was run with different algorithms like Bayesian Regularization and Scaled Conjugate Gradient to confirm and test its performance. As shown in Figure 7, all the comparative results are near the diagonal, which indicates a full agreement between ANN-predicted values (Y-axis) and experimental values (X-axis).
The prediction performance of the current ANN12 model was then evaluated by the values of R, RMSE, MAE and MBE. Table 9 lists these values for the training, validation test and all data sets. All statistical measurements of deviations are significantly low for the selected ANN model, which implies that the selected ANN model can effectively predict the output parameter (R > 0.9999).
After checking the ANN with 154 data sets in the three stages (training, validation, and test), the final and best architecture NN-2-10-10-1 has been tested to predict the output parameter of 28 new input data sets covering 7 experiments for each heating rate (5, 10, 20, or 40 K min−1) as presented in Table 10. In this stage, only the new input data sets were fed to the system, and the ANN produce the new predicted-output according the final architecture NN-2-10-10-1. Figure 8 shows the comparison between the ANN-predicted values with the measured ones, which confirms the high performance of the selected network. In addition, Table 11 lists the statistical parameters (R, RMSE, MAE and MBE) of this stage. As presented, R is very high (>0.9999) with very low values of RMSE, MAE and MBE which implies the highly efficient performance of the developed ANN model.

4. Conclusions

The TG & DTG thermograms obtained from TGA study of the LDPE pyrolysis showed the same shapes and trends at different heating rates. From the TGA data, it has been observed that the data conforms only to one reaction region, which can be fitted by a first-order straight line.
In this work, two approaches have been implemented to model the TGA kinetic data. In the first approach, five different methods, to approximate the TGA data with straight line regression, have been used to calculate the values of the decomposition kinetic parameters. However, in the second one, a highly efficient ANN model has been developed, for the first time, to predict the thermal decomposition of LDPE.
In the first approach, three Model-free (Friedman, FWO, and KAS) and two Model-fitting (Coats- Redfern and Arrhenius) methods have been used to obtain the LDPE pyrolysis kinetic parameters (E and A). The values of the calculated activation energies by Friedman, FWO, and KAS were ranging between 193 and 195 kJ mol−1 which are slightly lower than those obtained by the Model-fitting methods (Arrhenius 202 kJ mol−1 and Coats-Redfern methods 196 kJ mol−1). However, these values are still very close to the published data.
An ANN with the architecture of 2-10-10-1, with two hidden layers (Logsig-Logsig), has been found as the most efficient network which could predict the output variable (weight loss %) very precisely with regression coefficient value of (R ≈ 1.0). Then, the proposed network topology has been tested with extra new input data and results were in close agreement with the experimental values with very high R (>0.9999) and very low RMSE, MAE and MBE.

Author Contributions

Conceptualization, I.D. and M.A.-Y.; Data curation, I.D.; Formal analysis, I.D.; Funding acquisition, M.A.-Y.; Investigation, I.D. and M.A.-Y.; Methodology, I.D.; Project administration, M.A.-Y.; Software, I.D.; Validation, M.A.-Y.; Visualization, M.A.-Y.; Writing—original draft, I.D.; Writing—review & editing, M.A.-Y. All authors have read and agreed to the published version of the manuscript.

Funding

This research and the APC were funded by Deanship of Scientific Research (DSR) at King Faisal University (KFU) in Al-Ahsa, Saudi Arabia under the Research Group Support Track (Grant No. 17122013).

Acknowledgments

The authors acknowledge the Deanship of Scientific Research at King Faisal University (KFU) in Al-Ahsa for the financial support under the Research Group Support Track (Grant No. 17122013).

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Miskolczi, N.; Bartha, L.; Deák, G. Thermal degradation of polyethylene and polystyrene from the packaging industry over different catalysts into fuel-like feed stocks. Polym. Degrad. Stabil. 2006, 91, 517–526. [Google Scholar] [CrossRef]
  2. Diaz Silvarrey, L.S.; Phan, A.N. Kinetic study of municipal plastic waste. Int. J. Hydrogen Energy 2016, 41, 16352–16364. [Google Scholar] [CrossRef] [Green Version]
  3. Cardona, S.C.; Corma, A. Tertiary recycling of polypropylene by catalytic cracking in a semi batch stirred reactor. Appl. Catalysis B 2000, 25, 151–162. [Google Scholar] [CrossRef]
  4. Arandes, J.; Abajo, I.; Lopez-Valerio, D.; Fernandez, I.; Azkoiti, M.J.; Olazar, M.; Bilbao, J. Transformation of several plastic wastes into fuels by catalytic cracking. Ind. Eng. Chem. Res. 1997, 36, 4523–4529. [Google Scholar] [CrossRef]
  5. Kaminsky, W.; Schlesselmann, B.; Simon, C.M. Thermal degradation of mixed plastic waste to aromatic and gas. Poly. Degrad. Stab. 1996, 53, 189–197. [Google Scholar] [CrossRef]
  6. Aguado, J.; Serrano, D.P.; Miguel, G.S.; Castro, M.C.; Madrid, S. Feedstock recycling of polyethylene in a two-step thermo-catalytic reaction system. J. Anal. Appl. Pyrolysis 2007, 79, 415–423. [Google Scholar] [CrossRef]
  7. Jan, M.R.; Shah, J.; Gulab, H. Catalytic conversion of waste high-density polyethylene into useful hydrocarbons. Fuel 2013, 105, 595–602. [Google Scholar] [CrossRef]
  8. Lyon, R.E. An integral method of non-isothermal kinetic analysis. Thermochim. Acta 1997, 297, 117–124. [Google Scholar] [CrossRef]
  9. Saha, B.; Ghoshal, A.K. Model-free kinetics analysis of ZSM-5 catalyzed pyrolysis of waste LDPE. Thermochim. Acta 2007, 453, 120–127. [Google Scholar] [CrossRef]
  10. Aboulkas, A.; El Harfi, K.; Bouadili, A. Pyrolysis of olive residue/low density polyethylene mixture: Part I Thermogravimetric kinetics. J. Fuel Chem. Technol. 2008, 36, 672–678. [Google Scholar] [CrossRef]
  11. Aboulkas, A.; El Harfi, K.; Bouadili, A. Thermal degradation behaviors of polyethylene and polypropylene. Part I: Pyrolysis kinetics and mechanisms. Energy Convers. Manag. 2010, 51, 1363–1369. [Google Scholar] [CrossRef]
  12. Aguado, R.; Olaza, M.; Gaisan, B.; Prieto, R.; Bilbao, J. Kinetic study of polyolefin pyrolysis in a conical spouted bed reactor, Chem. Eng. J. 2003, 92, 91–99. [Google Scholar] [CrossRef]
  13. Sorum, L.; Gronli, M.; Hustad, J.E. Pyrolysis characteristics and kinetics of municipal solid wastes. Fuel 2001, 80, 1217–1227. [Google Scholar] [CrossRef]
  14. Wu, C.H.; Chang, C.Y.; Hor, J.L.; Shih, S.M.; Chen, L.W.; Chang, F.W. On the thermal treatment of plastic mixture of MSW: Pyrolysis kinetics. Waste Manag. 1993, 13, 221–235. [Google Scholar] [CrossRef]
  15. Das, P.; Tiwari, P. Thermal degradation kinetics of plastics and model selection. Thermochim. Acta 2017, 654, 191–202. [Google Scholar] [CrossRef]
  16. Conesa, J.A.; Caballero, J.A.; Reyes-Labarta, A.J. Artificial neural network for modelling thermal decompositions. J. Anal. Appl. Pyrolysis 2004, 71, 343–352. [Google Scholar] [CrossRef]
  17. Yıldız, Z.; Uzun, H.; Ceylan, S.; Topcu, Y. Application of artificial neural networks to co-combustion of hazelnut husk–lignite coal blends. Bioresour. Technol. 2016, 200, 42–47. [Google Scholar] [CrossRef]
  18. Çepelioĝullar, O.; Mutlu, I.; Yaman, S.; Haykiri-Acma, H. A study to predict pyrolytic behaviors of refuse-derived fuel (RDF): Artificial neural network application. J. Anal. Appl. Pyrolysis 2016, 122, 84–94. [Google Scholar] [CrossRef]
  19. Charde, S.J.; Sonawane, S.S.; Sonawane, S.H.; Shimpi, N.G. Degradation Kinetics of Polycarbonate Composites: Kinetic Parameters and Artificial Neural Network. Chem. Biochem. Eng. Q. 2018, 32, 151–165. [Google Scholar] [CrossRef]
  20. Chen, J.; Xie, C.; Liu, J.; He, Y.; Xie, W.; Zhang, X.; Chang, K.; Kuo, J.; Sun, J.; Zheng, L.; et al. Co-combustion of sewage sludge and coffee grounds under increased O2/CO2 atmospheres: Thermodynamic characteristics, kinetics and artificial neural network modeling. Bioresour. Technol. 2018, 250, 230–238. [Google Scholar] [CrossRef]
  21. Naqvi, S.R.; Tariq, R.; Hameed, Z.; Ali, I.; Taqvi, S.A.; Naqvi, M.; Niazi, M.B.K.; Noor, T.; Farooq, W. Pyrolysis of high-ash sewage sludge: Thermo-kinetic study using TGA and artificial neural networks. Fuel 2018, 233, 529–538. [Google Scholar] [CrossRef]
  22. Chan, J.H.; Balke, S.T. The thermal degradation kinetics of polypropylene: Part III. thermogravimetric analyses. Polym. Degrad. Stabil. 1997, 57, 135–149. [Google Scholar] [CrossRef]
  23. Khedri, S.; Elyasi, S. Kinetic analysis for thermal cracking of HDPE: A new isoconversional approach. Polym. Degrad. Stabil. 2016, 129, 306–318. [Google Scholar] [CrossRef]
  24. Xu, F.; Wang, B.; Yang, D.; Hao, J.; Qiao, Y.; Tiana, Y. Thermal degradation of typical plastics under high heating rate conditions by TG-FTIR: Pyrolysis behaviors and kinetic analysis. Energy Convers. Manag. 2018, 171, 1106–1115. [Google Scholar] [CrossRef]
  25. Gundogar, A.S.; Kok, M.V. Thermal characterization, combustion and kinetics of different crude oils. Fuel 2014, 123, 59–65. [Google Scholar] [CrossRef]
  26. Baloch, M.K.; Khurran, M.J.Z.; Durrani, G.F. Application of different methods for the Thermogravimetric analysis of polyethylene samples. J. Appl. Polym. Sci. 2011, 120, 3511–3518. [Google Scholar] [CrossRef]
  27. Quantrille, T.E.; Liu, Y.A. Artificial Intelligence in Chemical Engineering; Academic Press: San Diego, LA, USA, 1991. [Google Scholar]
  28. Halali, M.A.; Azari, V.; Arabloo, M.; Mohammadi, A.H.; Bahadori, A. Application of a radial basis function neural network to estimate pressure gradient in water–oil pipelines. J. Taiwan Inst. Chem. Eng. 2016, 58, 189–202. [Google Scholar] [CrossRef]
  29. Govindan, B.; Jakka, S.C.B.; Radhakrishnan, T.K.; Tiwari, A.K.; Sudhakar, T.M.; Shanmugavelu, P.; Kalburgi, A.K.; Sanyal, A.; Sarkar, S. Investigation on kinetic parameters of combustion and oxy-combustion of calcined pet coke employing thermogravimetric analysis coupled to artificial neural network modeling. Energy Fuels 2018, 32, 3995–4007. [Google Scholar] [CrossRef]
  30. Boostani, M.; Karimi, H.; Azizi, S. Heat transfer to oil-water flow in horizontal and inclined pipes: Experimental investigation and ANN modeling. Int. J. Therm. Sci. 2017, 111, 340–350. [Google Scholar] [CrossRef]
  31. Beale, M.H.; Hagan, M.T.; Demuth, H.B. Neural Network Toolbox TM User’s Guide; MathWorks: Natick, MA, USA, 2018. [Google Scholar]
  32. Quan, B.; Kun, C.; Wei, X.; Yuanyuan, L.; Mengjie, C.; Xianghai, K.; Qiulu, C.; Hanping, M. Hydrocarbon rich bio-oil production, thermal behavior analysis and kinetic study of microwave-assisted co-pyrolysis of microwave-torrefied lignin with low density polyethylene. Bioresour. Technol. 2019, 291, 121860. [Google Scholar] [CrossRef]
Figure 1. Thermograms of low-density polyethylene pyrolysis at different heating rates.
Figure 1. Thermograms of low-density polyethylene pyrolysis at different heating rates.
Polymers 12 00891 g001
Figure 2. Derivative thermogravimetric curves of LDPE pyrolysis at different heating rates.
Figure 2. Derivative thermogravimetric curves of LDPE pyrolysis at different heating rates.
Polymers 12 00891 g002
Figure 3. Linear regression lines of Friedman model at different conversions.
Figure 3. Linear regression lines of Friedman model at different conversions.
Polymers 12 00891 g003
Figure 4. Linear regression lines of FWO model at different conversions.
Figure 4. Linear regression lines of FWO model at different conversions.
Polymers 12 00891 g004
Figure 5. Linear regression lines of KAS model at different conversions.
Figure 5. Linear regression lines of KAS model at different conversions.
Polymers 12 00891 g005
Figure 6. Topology of the selected network.
Figure 6. Topology of the selected network.
Polymers 12 00891 g006
Figure 7. Linear Regression plots of (a) training data, (b) validation data, (c) test data, and (d) complete data set of the selected ANN model.
Figure 7. Linear Regression plots of (a) training data, (b) validation data, (c) test data, and (d) complete data set of the selected ANN model.
Polymers 12 00891 g007
Figure 8. Linear regression of the tested new input data of the selected ANN model.
Figure 8. Linear regression of the tested new input data of the selected ANN model.
Polymers 12 00891 g008
Table 1. Values of activation energy of low-density polyethylene pyrolysis.
Table 1. Values of activation energy of low-density polyethylene pyrolysis.
ReferenceActivation Energy (kJ mol−1)
Diaz Silvarrey and Phan [2]267.61 ± 3.23
Lyon [8]130–200
Saha and Ghoshal [9]190
Aboulkas et al. [10]215
Aboulkas et al. [11]215–221
Aguado et al. [12]261 ± 21
Sorum et al. [13]340
Wu et al. [14]194–206
Table 2. Physical properties of black low-density polyethylene.
Table 2. Physical properties of black low-density polyethylene.
ManufacturerIpoh SY Recycle Plastic, Perak, Malaysia
Polymer TypeRecycled LDPE
Appearance (at 25 °C)Solid
Physical StatePellets
ColourBlack
Density (Kg/m3)910–940
Melting Temperature (°C)115 ± 10
Table 3. Equations of the selected model-free methods.
Table 3. Equations of the selected model-free methods.
MethodEquationIntegral (I) or Differential (D)Plot
Friedman ln ( β d α d T ) = ln ( A ) + ln ( 1 α ) E R 1 T (6)D ln ( β d α dT )     vs . 1 T
Flynn-Wall-Qzawa (FWO) ln ( β ) = ln ( A E R   ln ( 1 α ) ) 5.331 1.052 E R 1 T (7)I ln ( β )   vs . 1 T
Kissinger-Akahira-Sunose (KAS) ln ( β T 2 ) = ln ( A R E   ln ( 1 α ) ) E R 1 T (8)I ln ( β / T 2 )   vs . 1 T
Table 4. Equations of the selected model-fitting methods.
Table 4. Equations of the selected model-fitting methods.
MethodEquationPlot
Arrhenius ln ( dW dt W ) = ln A E R 1 T (9) ln ( dW dt W )   vs . 1 T
Coats-Redfern ln [ 1 ( 1 α ) 1 n T 2 ( 1 n ) ] = ln [ A R β E ( 1 2 RT E ) ] E R 1 T n ≠ 1 (10) ln [ 1 ( 1 α ) 1 n T 2 ( 1 n ) ]   vs . 1 T
ln [ ln ( 1 α ) T 2 ] = ln [ A R β E ( 1 2 RT E ) ] E R 1 T n = 1 (11) ln [ ln ( 1 α ) T 2 ]   vs . 1 T
Table 5. The on-set, end-set and peak values of the LDPE pyrolysis at different heating rates.
Table 5. The on-set, end-set and peak values of the LDPE pyrolysis at different heating rates.
Heating Rate (K/min)On-Set (K)End-Set (K)Peak (K)
5665750741
10668755744
20688782765
40700794785
Table 6. Kinetic parameters of LDPE pyrolysis at different conversions calculated by three model-free methods: Friedman, FWO and KAS.
Table 6. Kinetic parameters of LDPE pyrolysis at different conversions calculated by three model-free methods: Friedman, FWO and KAS.
Conversion Friedman FWO KAS
E (kJ/mol)A
(min−1)
R2E (kJ/mol)A
(min−1)
R2E (kJ/mol)A
(min−1)
R2
0.11972.63 × 10130.97721938.14 × 10120.95321915.51 × 10120.9474
0.21854.85 × 10120.92651982.17 × 10130.95751961.49 × 10130.9523
0.31866.68 × 10120.92881982.46 × 10130.96291961.65 × 10130.9582
0.42061.97 × 10140.93871951.70 × 10130.94981931.09 × 10130.9435
0.51985.20 × 10130.97931941.55 × 10130.95271919.74 × 10120.9467
0.61943.06 × 10130.98441941.97 × 10130.95671921.23 × 10130.9511
0.71881.17 × 10130.96741963.07 × 10130.96121941.94 × 10130.9562
0.81964.31 × 10130.93451974.15 × 10130.96651952.62 × 10130.9621
0.91984.50 × 10130.95591922.16 × 10130.97201901.28 × 10130.9681
Average1944.63 × 10130.95471952.23 × 10130.95921931.43 × 10130.9540
Table 7. Kinetic parameters of LDPE pyrolysis at different heating rates by two model-fitting methods: Arrhenius and Coats-Redfern.
Table 7. Kinetic parameters of LDPE pyrolysis at different heating rates by two model-fitting methods: Arrhenius and Coats-Redfern.
Heating Rate (K/min) Arrhenius MethodCoats-Redfern Method
E
(kJ/mol)
A
(min−1)
R2E
(kJ/mol)
A
(min−1)
R2
52071.42 × 10140.96731934.22 × 10100.9295
102002.29 × 10130.9851936.75 × 10100.9436
202139.13 × 10130.97241978.66 × 10100.9413
401871.11 × 10120.96492011.61 × 10110.9459
Average2026.43 × 10130.97241968.92 × 10100.9401
Table 8. Performance of different ANN structures.
Table 8. Performance of different ANN structures.
ModelNetwork Topology1st Transfer Function2nd Transfer FunctionR
ANN1NN-2-10-1TANSIG-0.99943
ANN2NN-2-15-1TANSIG-0.99981
ANN3NN-2-5-1TANSIG-0.99724
ANN4NN-2-10-1LOGSIG-0.99865
ANN5NN-2-15-1LOGSIG-0.98047
ANN6NN-2-5-1LOGSIG-0.99544
ANN7NN-2-15-15-1TANSIGTANSIG0.99978
ANN8NN-2-15-15-1LOGSIGTANSIG0.99961
ANN9NN-2-15-15-1TANSIGLOGSIG0.99989
ANN10NN-2-10-15-1TANSIGLOGSIG0.99990
ANN11NN-2-10-10-1TANSIGLOGSIG0.99993
ANN12NN-2-10-10-1LOGSIGLOGSIG1.00000
ANN13NN-2-15-15-1LOGSIGLOGSIG0.99998
ANN14NN-2-10-15-1LOGSIGLOGSIG0.99997
ANN15NN-2-15-10-1LOGSIGLOGSIG0.99996
Table 9. Statistical parameters of the ANN12 model.
Table 9. Statistical parameters of the ANN12 model.
SetStatistical Parameters
RRMSEMAEMBE
Training0.999990.097860.041770.00583
Validation0.999990.045780.03291−0.01063
Test0.999990.051970.037130.002655
All0.999990.086210.039750.002897
Table 10. Performance evaluation of the selected network for extra new input data at different heating rates.
Table 10. Performance evaluation of the selected network for extra new input data at different heating rates.
No.Input DataPredicted-Output Data
Heating Rate (K min−1)Temperature (K)Weight Left (%)
15528.03699.87579
25578.0999.6904
35628.07299.328
45678.06296.50681
55728.02549.30348
65778.0430.048376
75828.05−0.01156
810528.014100.0249
910578.02699.66833
1010628.01798.99761
111067896.5807
1210728.00264.78094
13107780.450783
1410828.0180.344112
1520528.14899.97255
1620578.20599.85724
1720628.00699.64173
1820678.27398.72066
1920728.20388.68082
2020778.2910.577601
2120828.075−0.04285
2240528.19499.98355
2340578.39799.8972
2440628.45299.74232
2540678.1299.26672
2640728.50194.30099
2740778.04730.7278
2840828.380.264529
Table 11. Statistical parameters of the ANN12 model for the tested extra new input data.
Table 11. Statistical parameters of the ANN12 model for the tested extra new input data.
SetStatistical Parameters
RRMSEMAEMBE
simulated0.999980.170170.079410.04903

Share and Cite

MDPI and ACS Style

Dubdub, I.; Al-Yaari, M. Pyrolysis of Low Density Polyethylene: Kinetic Study Using TGA Data and ANN Prediction. Polymers 2020, 12, 891. https://doi.org/10.3390/polym12040891

AMA Style

Dubdub I, Al-Yaari M. Pyrolysis of Low Density Polyethylene: Kinetic Study Using TGA Data and ANN Prediction. Polymers. 2020; 12(4):891. https://doi.org/10.3390/polym12040891

Chicago/Turabian Style

Dubdub, Ibrahim, and Mohammed Al-Yaari. 2020. "Pyrolysis of Low Density Polyethylene: Kinetic Study Using TGA Data and ANN Prediction" Polymers 12, no. 4: 891. https://doi.org/10.3390/polym12040891

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop