Evaluation of the Enzymatic Activity of Immobilized Lysobacter sp. †

: The specific enzymatic activity of bacterial cultures illustrates the key applications of a studied strain of bacteria and the biological products based on it. The proteolytic activity of extracellular enzymes in the temperature range 20–45 and the activity of β -1,4-glucanase were studied, and the influence of pH and temperature on the activity and stability of the enzyme was revealed. The optimal cultivation conditions for the Lysobacter strain were selected for the highest production of β -1,4-glucanase: glucose, 1% by weight; yeast extract, 0.2% by weight; CMC, 0.75% by weight; pH 7; amount of inoculum, 3.5% by volume; optimal temperature for incubation, 30 ◦ C. Enzyme stability results showed that the enzyme retained 90% of its activity after minimal preincubation at pH 5.5 and more than 60% of its maximum activity at pH 4–10, demonstrating stability over a wide pH range. More than 60% of β -1,4-glucanase’s enzymatic activity is observed in the range of 20–45 ◦ C. Consequently, biocompositions based on Lysobacter sp. can be used in a wide range of temperatures and pH, which represents its promising use as a probiotic drug.


Introduction
Microorganisms are one of the most important sources of biologically active substances such as proteins, enzymes, antibiotics, and vitamins.When exposed to various stress factors (temperature, drying, oxidizers), new unique properties can appear, from superproduction to the emergence of new protective mechanisms.However, most of them still reduce their biological functions.
It is now known that immobilization and shielding of bacterial cells can increase the safety and viability of microorganisms [1][2][3].It was previously shown that the immobilization of Lysobacter sp. on the sodium form of montmorillonite has a beneficial effect on the safety of cells, and an increase in colony-forming units is observed during storage [4].
The aim of this study was to determine the enzymatic activity of immobilized Lysobacter sp. cells on inorganic matrices.

Materials and Methods
Determination of enzymatic (proteolytic) activity: lyophilic culture of Lysobacter sp.(0.1 g) and biocomposition Lysobacter sp. on various carriers (0.1 g each, respectively), obtained according to the method described in [4] in a carrier: biomass ratio of 1:4, were sown on a solid agar medium containing 0.2 wt.% casein and 0.1 wt.% yeast extract.Then, they were incubated for 24 h at T = 30 • C. Afterwards, they were subcultured onto agar slants and incubated under the same conditions.
A 24-h culture on agar slants was suspended in 4 mL of distilled water.Next, 1000 µL of culture liquid was sterilely transferred into previously prepared liquid media with a volume of 100 mL and thermostated at 30 • C for 24 h (until the onset of the logarithmic growth phase).
The proteolytic activity was assessed by the spectrophotometric method using the modified Anson method (Russian Federation State Standard "Enzyme Preparations Methods for Determining Proteolytic Activity") using a UV/Vis spectrophotometer for studying nano-and microvolumes of liquids (NABI MicroDigital).A 1% aqueous solution of casein was used as a substrate.
To increase the production of β-1,4-glucanase in the nutrient medium for the cultivation of Lysobacter sp., 0.5% sodium carboxymethylcellulose was added and incubated at 37 • C and 150 rpm for 2 days.
To assess enzyme activity, every 12 h, 500 µL of the culture medium was taken and centrifuged at 10,000× g with cooling for 15 min.
The enzymatic activity of β-1,4-glucanase was studied using the method described in [5].
The optimal temperature for β-1,4-glucanase activity was studied by incubating the enzyme with the substrate in the temperature range of 20-80 • C. The temperature stability of the enzyme was tested by keeping the purified enzyme at various temperatures of 20-80 • C for 1 h, and then adding the substrate to the reaction mixture and incubating at 50 • C. Residual enzyme activity was determined.The sample without the enzyme was used as a control.
The dependence of Lysobacter sp.cell binding to the surface of the sodium form of montmorillonite was studied by confocal microscopy (Digital Eclipse C1 Plus, Nikon, Japan) and scanning electron microscopy using a (Quanta 600 FEG, FEI, Netherlands) scanning electron microscope with an EDX energy-dispersive detector.

Results
The results of determining the proteolytic activity of extracellular enzymes of the bacterial culture Lysobacter sp. are given in Table 1.The maximum proteolytic activity of enzymes in the culture liquid of the studied Lysobacter strain is observed at a temperature of 40 • C.
The immobilization of cells on carriers generally has a positive effect on enzyme production and activity.In the case of immobilization on sodium carboxymethylcellulose and the sodium form of montmorillonite, the temperature range of enzymatic activity expands from 35 • C to 45 • C, which will expand the use of biocompositions based on immobilized cells and their enzymes.
Eng. Proc.2024, 67, 17 3 o from 35 °C to 45 °C, which will expand the use of biocompositions based on immobiliz cells and their enzymes.
The optimal medium for the highest production of β-1,4-glucanase consists of g cose (1% w/v), yeast extract (0.2% w/v), CMC (0.75% w/v), pH 7, inoculum size (3.5% volume), and the optimal incubation temperature of 30 °C (Figure 1).Under optimal conditions, the culture supernatant had an activity of 2.31 U/mL specific activity of 1.26 U/mg, a protein content of 1.98 mg/mL, and a total protein cont of 990 mg.The culture supernatant was 85% purified.The precipitation of the protein w ammonium sulfate increased the specific activity to 1.37 U/mg.Subsequent purificat on a Q-Sepharose ion exchange chromatography column resulted in 8.5-fold purificat and a specific activity of 11.5 U/mg.The purified enzyme was active over a wide pH ran and had maximum activity at pH 5.5.
Enzyme stability results showed that the enzyme retained 90% of its activity af minimal preincubation at pH 5.5 and more than 60% of maximum activity was retain at pH 4-10, demonstrating tolerance to a wide range of pH.
The optimal temperature for β-1,4-glucanase activity was studied by incubating enzyme with the substrate in the temperature range of 20-80 °C.The temperature stabil of the enzyme was tested by keeping the purified enzyme at various temperatures of 2 80 °C for 1 h, then adding the substrate to the reaction mixture and incubating at 50 The residual enzyme activity was determined.The sample without the enzyme was us as a control.
Figure 2 shows micrographs of a biocomposition based on Lysobacter sp.bacter cells shielded by the sodium form of montmorillonite.Under optimal conditions, the culture supernatant had an activity of 2.31 U/mL, a specific activity of 1.26 U/mg, a protein content of 1.98 mg/mL, and a total protein content of 990 mg.The culture supernatant was 85% purified.The precipitation of the protein with ammonium sulfate increased the specific activity to 1.37 U/mg.Subsequent purification on a Q-Sepharose ion exchange chromatography column resulted in 8.5-fold purification and a specific activity of 11.5 U/mg.The purified enzyme was active over a wide pH range and had maximum activity at pH 5.5.
Enzyme stability results showed that the enzyme retained 90% of its activity after minimal preincubation at pH 5.5 and more than 60% of maximum activity was retained at pH 4-10, demonstrating tolerance to a wide range of pH.
The optimal temperature for β-1,4-glucanase activity was studied by incubating the enzyme with the substrate in the temperature range of 20-80 • C. The temperature stability of the enzyme was tested by keeping the purified enzyme at various temperatures of 20-80 • C for 1 h, then adding the substrate to the reaction mixture and incubating at 50 • C. The residual enzyme activity was determined.The sample without the enzyme was used as a control.
Figure 2 shows micrographs of a biocomposition based on Lysobacter sp.bacterial cells shielded by the sodium form of montmorillonite.
Due to the layered structure of montmorillonite type 2:1 and the swelling crystal lattice, which contains water molecules, as well as exchangeable cations Na + , the viability of the microorganism cells is maintained.
Thin nanostructured layered film particles of montmorillonite aggregate on the surface of the bacterial cell wall, thereby protecting it from the effects of UV rays, oxidizers, drying, etc. Due to the layered structure of montmorillonite type 2:1 and the swelling crystal tice, which contains water molecules, as well as exchangeable cations Na + , the viabilit the microorganism cells is maintained.
Thin nanostructured layered film particles of montmorillonite aggregate on the face of the bacterial cell wall, thereby protecting it from the effects of UV rays, oxidiz drying, etc.

Conclusions
It was found that the optimal nutrient medium and conditions for the productio β-1,4-glucanase by bacteria Lysobacter sp.consists of glucose (1% w/v), yeast extract (0 w/v), CMC (0.75% w/v), pH 7, and an optimal incubation temperature of 30 °C.
The immobilization of cells on carriers generally has a positive effect on enzyme duction and activity.In the case of immobilization on sodium carboxymethylcellulose the sodium form of montmorillonite, the temperature range of enzymatic activity expa from 35 °C to 45 °C, which will expand the use of biocompositions based on immobil cells and their enzymes.
When cells are immobilized, β-1,4-glucanase activity is maintained over a wide ra of pH and temperatures, which expands the possibilities of using compositions un acidic/alkaline conditions and elevated temperatures.
Biocomposites obtained by screening bacterial cells can be used to obtain espec valuable animal feed, biomedical products, and preparations for phytoremediation.

Figure 2 .
Figure 2. Screened Lysobacter bacteria using montmorillonite: (a,b) Stained Lysobacter bacteria o surface of montmorillonite particles.Nikon Digital Eclipse C1 Plus confocal microscopy.(c) glomerates of Lysobacter bacteria screened with montmorillonite film particles.Scanning elec microscopy using a Quanta 600 FEG scanning electron microscope with an EDAX energy-dispe detector.

Figure 2 .
Figure 2. Screened Lysobacter bacteria using montmorillonite: (a,b) Stained Lysobacter bacteria on the surface of montmorillonite particles.Nikon Digital Eclipse C1 Plus confocal microscopy.(c) Conglomerates of Lysobacter bacteria screened with montmorillonite film particles.Scanning electron microscopy using a Quanta 600 FEG scanning electron microscope with an EDAX energydispersive detector.

Table 1 .
Proteolytic activity of extracellular enzymes of Lysobacter sp.immobilized on various carriers in relation to casein in the temperature range of 20-45 • C.