Ethanol Production from Sweet Sorghum Juice at High Temperatures Using a Newly Isolated Thermotolerant Yeast Saccharomyces cerevisiae DBKKU Y-53

Ethanol production at elevated temperatures requires high potential thermotolerant ethanol-producing yeast. In this study, nine isolates of thermotolerant yeasts capable of growth and ethanol production at high temperatures were successfully isolated. Among these isolates, the newly isolated thermotolerant yeast strain, which was designated as Saccharomyces cerevisiae DBKKU Y-53, exhibited great potential for ethanol production from sweet sorghum juice (SSJ) at high temperatures. The maximum ethanol concentrations produced by this newly isolated thermotolerant yeast at 37  ̋C and 40  ̋C under the optimum cultural condition were 106.82 g ̈ L ́1 and 85.01 g ̈ L ́1, respectively, which are greater than values reported in the literatures. It should be noted from this study with SSJ at a sugar concentration of 250 g ̈ L ́1 and an initial pH of 5.5 without nitrogen supplementation can be used directly as substrate for ethanol production at high temperatures by thermotolerant yeast S. cerevisiae DBKKU Y-53. Gene expression analysis using real-time RT-PCR clearly indicated that growth and ethanol fermentation activities of the thermotolerant yeast S. cerevisiae DBKKU Y-53 at a high temperature (40  ̋C) were not only restricted to the expression of genes involved in the heat-shock response, but also to those genes involved in ATP production, trehalose and glycogen metabolism, and protein degradation processes were also involved.


Introduction
Bioethanol is a clean, renewable, environmental friendly source of fuel energy that can be produced from different feedstocks and conversion technologies.It is one of the most promising substitutes for fossil energy and has high potential to replace petroleum-based fossil fuels [1][2][3].Bioethanol can be used directly or blended with gasoline (known as "gasohol") to power engines without modification.Development of bioethanol is not only addressing climate change due to the burning of petroleum-based fuels but is also of great significance in protecting national energy security and promoting rural economic growth [3,4].Approximately 60% of global bioethanol is produced from sugar crops, the remaining 40% is produced from starchy grains [5].Sweet sorghum (Sorghum bicolor L. Moench) is one of the most promising sugar crops for industrial bioethanol production.It is a C4 plant, is similar to sugarcane, and belongs to the grass family.Due to a high photosynthetic efficiency, it is known for high carbon assimilation and the ability to store high levels of extractable sugars in its stalks [6].Sweet sorghum is one of the most drought-resistant agricultural crops and can be cultivated in nearly all temperate and tropical climate areas in both irrigated and non-irrigated lands [7,8].Unlike sugarcane, sweet sorghum has a short growing period (3-4 months).Therefore, it can be planted two or three times a year.Its stalks contain both soluble carbohydrates (such as sucrose, glucose, fructose) and insoluble carbohydrates (such as cellulose and hemicellulose) that can be converted into fuel ethanol using a biological fermentation process [9,10].With respect to the production cost, sweet sorghum has lower production cost than that of sugarcane and sugar beets because it requires less fertilizer.Therefore, considering the potential of sweet sorghum for industry, it is an ideal crop for commercial ethanol production [11].Although sweet sorghum is considered as an important food resource in some countries, such as India, China, which uses sweet sorghum juice (SSJ) to produce syrup, the Thai government promotes sweet sorghum to be used as an energy crop for large-scale ethanol production together with sugarcane and cassava.
Fermentation at high temperature is a key requirement for effective bioethanol production in tropical countries where average daytime temperatures are usually high throughout the year.The advantages of fermentation at high temperatures are not only an increased the rate of fermentation but also a decreased risk of contamination by mesophilic microorganisms, such as Williopsis sp., Candida sp., Zygosaccharomyces sp., a reduced cost of the cooling system, and the possible use of simultaneous saccharification and fermentation (SSF) when coupled with a continuous stripping system for ethanol recovery.Utilization of a high potential thermotolerant yeast strain is a key to success in ethanol production at high temperatures [12,13].There are several reports in the literature on the ethanol production at high temperatures using the thermotolerant yeast Kluyveromyces marxianus [13][14][15][16][17][18]; however, very few reports have considered the thermotolerant yeast Saccharomyces cerevisiae [12,19].
Under stressful conditions, such as heat, ethanol, or osmotic stress, several stress-responsive genes including those encoding for the heat shock proteins (HSPs), enzymes involved in protein degradation, such as ubiquitin ligase, and proteins involved in trehalose and glycogen metabolism in yeast have been reported to be stimulated [20,21].HSPs play a key role as molecular chaperones by either stabilizing new proteins to ensure correct folding or refolding of proteins to the proper conformation, or degrading misfolded proteins that are damaged by stress conditions.HSPs also help transport proteins across membranes within the cell [22,23].Trehalose, which is one of the compatible solutes synthesized during adverse environmental conditions, has been reported to protect the cell by replacing water at the surfaces of macromolecules, which holds proteins and membranes in their native conformation [24,25].Glycogen, which is a reserve carbohydrate in S. cerevisiae, has also been reported to be involved with tolerance towards several stresses [26,27].Although a number of genes responsible for the prevention of protein denaturation in yeast cells have been reported, the molecular mechanism conferring thermotolerance during ethanol fermentation at high temperatures is not fully understood.
In this study, the isolation and screening of highly efficient thermotolerant yeast strains capable of producing high levels of ethanol at high temperatures from SSJ were carried out.The optimum condition for ethanol production for the selected thermotolerant yeast strain was also investigated.Furthermore, to gain a better understanding of the molecular mechanism by which yeast cells adapt to adverse environmental conditions and acquire thermotolerance during high temperature ethanol fermentation, the expression of genes encoding the HSP26, HSP70, HSP90, HSP104, pyruvate kinase, trehalose-6-phosphate synthase, neutral trehalase, glycogen synthase, and ubiquitin ligase was evaluated.This work is the first to demonstrate the physiological changes related to the expression of genes involved in heat-shock response, ATP production, trehalose and glycogen metabolism, and

Isolation of Thermotolerant Yeast Strains
Samples including sugarcane juice, SSJ, rotten fruits, soils from sugarcane and sweet sorghum plantations collected from the Khon Kaen, Udon Thani, Nakhon Ratchasima, Maha Sarakham, Kalasin, Chaiyaphum, and Roi Et provinces of Thailand were used for the isolation of thermotolerant yeasts using the enrichment method described by Limtong et al. [13].YM broth (0.3% yeast extract, 0.3% malt extract, 0.5% peptone, and 1% glucose) supplemented with 4% (v/v) ethanol was used as a selective medium in this study.After incubation at 35 ˝C for 3 days on a rotary incubator shaker at 100 rpm, the enriched cultures were then spread on YM agar supplemented with 4% (v/v) ethanol and subsequently incubated at 35 ˝C.Pure cultures were collected and maintained on YM agar at 4 ˝C for short-term storage and in 50% (v/v) glycerol at ´20 ˝C for long-term storage.

Screening of Thermotolerant Yeast for Ethanol Fermentation at High Temperatures
SSJ containing 100 g¨L ´1 total sugars was used as substrate for screening thermotolerant ethanol-producing yeast strains.The ethanol production capability was tested by culturing the isolated thermotolerant yeast strains in 16 ˆ160 mm test tube containing 10 mL SSJ, which were then incubated at high temperatures (37 ˝C to 50 ˝C) on a rotary incubator shaker at 150 rpm.The Durham tube was placed inside the test tube, and strains that produced high levels of CO 2 in the Durham tube were selected for further study.

Identification of The Selected Thermotolerant Yeast Strains
Identification of the yeast strains was carried out using morphological and the D1/D2 domain of the 26S rDNA gene sequencing analysis [28].Genomic DNA was isolated from the yeast cells using the method described by Harju et al. [29].Amplification of the D1/D2 domain of the 26S rDNA gene was carried out using the specific primers NL-1 (5'-GCA TAT CAA TAA GCG GAG GAA AAG) and NL-4 (5'-GGT CCG TGT TTC AAG ACG G) [30] with the genomic DNA isolated from yeast cells as the template.After the PCR reaction, the amplified product was separated on a 1.0% agarose gel and purified using Invisorb ® Fragment CleanUp Kit (Invitek GmbH, Berlin, Germany).All procedures for DNA amplification and purification were carried out according to the manufacturer's instructions.DNA sequencing was performed in the First BASE Laboratories Sdn Bhd (Seri Kembangan, Selangor Darul Ehsan, Malaysia).The sequences of the D1/D2 domain of the 26S rDNA gene were analyzed using GENETYX (Software Development, Tokyo, Japan), whereas homology searching was performed using the FASTA and BLAST programs in the GenBank and DDBJ databases.Phylogenetic analysis was performed using MEGA5 [31], and the tree topologies were analyzed using bootstrap analysis based on the neighbor-joining method [32].

Comparative Study of Ethanol Production by the Selected Thermotolerant Yeast Strains
The ethanol fermentation efficiencies of the selected thermotolerant yeast strains were compared using SSJ with an initial sugar concentration of 220 g¨L ´1 as substrate.Batch ethanol fermentation was performed in a 500-mL air-locked flask with a final working volume of 400 mL, and the initial cell concentration was 10 6 cells¨mL ´1.Fermentation was carried out at 30 ˝C, 37 ˝C, 40 ˝C, 42 ˝C and 45 ˝C under static conditions.During ethanol fermentation, samples were withdrawn at certain time intervals and analyzed.All experiments were performed in duplicated and repeated twice, and the average values ˘SD are presented.

Factors Influencing Ethanol Production by the Selected Thermotolerant Yeast
The SSJ was sterilized at 110 ˝C for 28 min and used as raw material for ethanol production using the selected thermotolerant yeast.In this study, S. cerevisiae SC90, which is commonly used in industrial ethanol production in Thailand, was used as a reference strain.The batch ethanol fermentation was carried out in 500-mL Erlenmeyer flasks equipped with an air-lock with a final working volume of 400 mL.The effects of pH (4.0, 4.5, 5.0, 5.5, 6.0), initial cell concentration (1 ˆ10 6 , 1 ˆ10 7 , 1 ˆ10 8 cells¨mL ´1), initial sugar concentration (200, 250, 300 g¨L ´1), and nitrogen source (yeast extract, urea, (NH 4 ) 2 SO 4 ) at various concentrations on ethanol production at high temperatures (37 ˝C and 40 ˝C) by the selected thermotolerant yeast were investigated.During ethanol fermentation, samples were withdrawn at certain time intervals and analyzed.All experiments were performed in duplicated and were repeated twice.The average values ˘SD are presented.

Ethanol Production in a 2-L Bioreactor
The ethanol production potential of the selected thermotolerant yeast strain was evaluated in a 2-L bioreactor (Biostat ® B, B. Braun Biotech, Melsungen, Germany) with a working volume of 1.5 L. The fermentation conditions at the bioreactor scale were selected from the results obtained from the flask-scale trials.The fermentation was carried out at high temperatures (37 ˝C and 40 ˝C) with an agitation speed of 100 rpm, and samples were periodically collected and analyzed during ethanol fermentation.

Real-Time RT-PCR Analysis of Gene Expression during Ethanol Fermentation
The expressions of genes encoding HSP26 (hsp26), HSP70 (hsp70), HSP90 (hsp90), HSP104 (hsp104), pyruvate kinase (cdc), trehalose-6-phosphate synthase (tps), neutral trehalase (nth), glycogen synthase (gsy), ubiquitin ligase (rsp) during ethanol fermentation were evaluated using real-time RT-PCR.Cells were grown in SSJ containing 220 g¨L ´1 total sugars at 40 ˝C until growth reached the exponential phase, and then the cells were harvested by centrifugation at 4 ˝C and 5000 rpm for 5 min.Total RNA was extracted from the yeast cells using Trizol reagent.The concentration of RNA was measured and adjusted by Nanodrop (Nanodrop Technologies, Wilmington, DE, USA).The real-time RT-PCR amplifications were performed using the Biorad-I-Cycler with the qPCRBIO SyGreen One-Step Lo-ROX (PCRBIOSYSTEMS, London, UK).The reactions (final volume 20 µL) were composed of 1 µL RNA template (100 ng RNA), 0.8 µL of each forward and reverse primer, 1 µL 20X RTase, 10 µL 2X qPCRBIO Sygreen One-Step mix, and 6.4 µL RNase-free water.The thermal cycling conditions for gene amplification were initial denaturation at 95 ˝C for 2 min, followed by 40 cycles each of denaturation at 95 ˝C for 5 s and annealing at 55 ˝C for 30 s.The primers used in this study are listed in Table 1.The actin gene (act) was used as an internal control.As a negative control, RNase-free water was used instead of the RNA template.All experiments were independently carried out in triplicate, and data from real-time RT-PCR analysis were determined using the CFX Manager Software (Bio-Rad, Hercules, CA, USA).Calculation of relative gene expression was performed using the comparative critical threshold (∆∆C T ) method in which the amount of the target genes was adjusted to the reference gene (act gene) [33].

Analytical Methods
The yeast cell numbers and total soluble solids of the fermentation broth were determined using a direct counting method using hemacytometer and a hand-held refractometer, respectively [34].The fermentation broth was centrifuged at 13,000 rpm for 10 min.The supernatant was then determined for total residual sugars using the phenol sulfuric acid method [35].The ethanol concentration (P, g¨L ´1) was analyzed using gas chromatography (Shimadzu GC-14B, Kyoto, Japan) using a polyethylene glycol (PEG-20M) packed column with a flame ionization detector.N 2 was used as a carrier gas, and 2-propanol was used as an internal standard.The ethanol yield (Yp/s) was calculated as the actual ethanol produced and was expressed as g ethanol per g glucose utilized (g¨g ´1).The volumetric ethanol productivity (Qp, g¨L ´1¨h ´1) was calculated using the following equations: Qp = P/t, where P is the ethanol concentration (g¨L ´1), and t is the fermentation time (h) giving the greatest ethanol concentration.

Isolation and Selection of Thermotolerant Yeast Strains
Natural habitats are a major source of useful microorganisms for biorefinery production [36].In this study, soil and plant samples from different locations in Northeastern Thailand were collected, and the isolation of thermotolerant yeasts was performed using the enrichment culture technique as described by Limtong et al. [13].The utilization of this technique under selection pressures has been widely used to isolate several thermotolerant yeast strains [13,17].It has been reported that the effects of high temperatures on microbial growth have often been aggravated by ethanol concentrations greater than 3% [37].Therefore, ethanol at 4% (v/v) and an incubation temperature of 35 ˝C served as selection pressures for the isolation of thermotolerant yeast strains in this work.As a result, sixty-two yeast isolates were obtained, and most of these yeasts were from soil samples.Their ability to grow and produce ethanol at high temperatures were tested by culturing the yeast strains in SSJ incubated at temperatures between 30 and 50 ˝C.The results showed that nine isolates of yeast, which were designated as DBKKU Y-53, DBKKU Y-55, DBKKU Y-58, DBKKU Y-102, DBKKU Y-103, DBKKU Y-104, DBKKU Y-105, DBKKU Y-106, and DBKKU Y-107, were able to grow and produce a relatively high level of ethanol at 45 ˝C.Of these, six isolates (i.e., DBKKUY-102, DBKKUY-103, DBKKUY-104, DBKKUY-105, DBKKUY-106, DBKKUY-107) were capable of growth and ethanol production at 47 ˝C.Their ability to grow and produce ethanol at high temperatures were comparable to that of K. marxianus ATCC 8554, which is known as a thermotolerant yeast.Based on growth performance of the isolated yeast strains at high temperatures (above 40 ˝C), we speculated that these nine isolates of yeast were thermotolerant yeasts [38].Therefore, all nine yeast isolates were selected for further study.
Successful isolation and selection of thermotolerant yeasts for ethanol production at high temperatures has been reported by several investigators.According to our literature review, SSJ has never been used directly as the substrate for yeast selection.Almost all previous research studies used glucose as a substrate, e.g., Ballesteros et al. [39] reported the screening and selection of thermotolerant yeast strains using glucose as the sole carbon source and found that K. marxianus L.G. was the most effective strain for ethanol production at high temperatures.This strain produced an ethanol concentration of approximately 3.76% (w/v) when the fermentation was carried out at 42 ˝C.Banat et al. [40] isolated and selected the thermotolerant yeast K. marxianus using an enrichment method with glucose as the carbon source and demonstrated that the selected K. marxianus strain produced an ethanol concentration of approximately 5.6%-6.0%(w/v) at 45-50 ˝C when using glucose as the substrate and ethanol concentration of approximately 7.5%-8.0%(w/v) and 6.5%-7.0%(w/v) at 37 ˝C and 40 ˝C, respectively, when using molasses as a substrate.Kiran Sree et al. [12] screened thermotolerant yeast S. cerevisiae VS3 using glucose as the sole carbon source, and they reported that the selected yeast strain produced an ethanol concentration of approximately 75 g¨L ´1 from a glucose concentration of 150 g¨L ´1 at 40 ˝C.Edgardo et al. [19] used glucose for the selection of thermotolerant yeast strains and obtained a good potential thermotolerant yeast S. cerevisiae that was able to produce approximately 75% of the theoretical ethanol yield at 40 ˝C.In addition to using glucose as a substrate, other carbon sources, such as sugarcane juice [13], xylose [41], sugarcane blackstrap molasses [42], and inulin [43] have also been used for screening and selecting thermotolerant yeasts.

Comparative Study on the Ethanol Production by the Selected Thermotolerant Yeasts
A preliminary study of the ethanol production using SSJ by the selected thermotolerant yeasts revealed that only four strains, i.e., DBKKU Y-53, DBKKU Y-102, DBKKU Y-103, and DBKKU Y-104, produced relatively high levels of ethanol at high temperatures after 24 h of fermentation.Therefore, these four strains were selected for further study of the ethanol production from SSJ at various incubation temperatures in a 500-mL flask scale.As shown in Table 2, strain DBKKU Y-53 produced the highest ethanol concentrations and volumetric ethanol productivities at 30 ˝C, 37 ˝C, 40 ˝C and 42 ˝C compared with the type strain, K. marxianus ATCC8554, and the other selected strains tested.At 45 ˝C, however, the ethanol concentration and volumetric ethanol productivity produced by this strain were lower than of the other strains tested.The ethanol concentrations and volumetric ethanol productivities produced by strains DBKKU Y-102, DBKKU Y-103, and DBKKU Y-104 were not significantly different compared with K. marxianus ATCC8554 at 30 ˝C, 37 ˝C, and 40 ˝C.At higher temperatures (42 ˝C and 45 ˝C), the ethanol concentrations and volumetric ethanol productivities from these strains were relatively greater than K. marxianus ATCC8554.It is evident from these results that increasing the fermentation temperature from 40 ˝C to 45 ˝C resulted in a reduction in the ethanol concentrations and productivities.Based on the maximum ethanol concentrations at 37 ˝C to 42 ˝C, which is a temperature commonly attained during fermentation in tropical regions, such as Thailand, S. cerevisiae DBKKU Y-53 was selected for further analysis.

Factors Influencing Ethanol Production When Using Thermotolerant Yeast S. cerevisiae DBKKU Y-53
There are several factors influencing the growth and ethanol production of yeast, such as the incubation temperature, the pH of the fermentation medium, the cell concentration, the sugar concentration, the nitrogen sources, and the aeration [13,44].Therefore, the effects of some of the major factors on ethanol production using SSJ by thermotolerant yeast S. cerevisiae DBKKU Y-53 were investigated.In this work, the ethanol production efficiency of S. cerevisiae DBKKU Y-53 was compared with that of S. cerevisiae SC90, which is one of the industrial yeast strains widely used to produce ethanol on a commercial scale in Thailand.
The effect of temperature on ethanol production from SSJ using S. cerevisiae DBKKU Y-53 and S. cerevisiae SC90 was analyzed, and the results are summarized in Table 3.There was no significantly difference in ethanol concentration produced by both strains at 30 ˝C.However, at 37 ˝C and 40 ˝C, S. cerevisiae DBKKU Y-53 produced greater ethanol concentrations than S. cerevisiae SC09.The maximum ethanol concentrations produced by S. cerevisiae DBKKU Y-53 at 37 ˝C and 40 ˝C were 71.73 ˘2.62 g¨L ´1 and 58.14 ˘7.71 g¨L ´1, respectively.When the incubation temperature was shifted from 40 ˝C to 42 ˝C and 45 ˝C, ethanol concentrations and volumetric ethanol productivities produced by both strains were remarkably decreased.This might be due to the negative effect of high temperature on growth and metabolic processes in yeast cells.It has been reported that high temperature causes a modification of plasma membrane fluidity and a reduction in the effectiveness of the plasma membrane as a semipermeable barrier allowing leakage of essential cofactors and coenzymes required for the activity of enzymes involved in glucose metabolism and ethanol production [44].Roukas [45] reported that high temperatures caused denaturation of cellular proteins, which resulted in the reduction of cell growth and fermentation activity.Moreover, the reduction in yeast growth at high temperatures was also due to the accumulation of intracellular ethanol, which modifies the cell membrane structure of yeast cell [46].Our results were in good agreement with Banat et al. [40], who observed a reduction in ethanol concentration produced by the thermotolerant yeast K. marxianus at 40 ˝C.Kiran Sree et al. [12] reported the ethanol production from glucose (150 g¨L ´1) using thermotolerant yeast S. cerevisiae VS3 and observed a reduction in ethanol concentration when the incubation temperature shifted from 30 ˝C to 40 ˝C.Limtong et al. [13] demonstrated that the ethanol concentration produced by the newly isolated thermotolerant yeast K. marxianus DMKU3-1042 decreased significantly when the incubation temperature was increased from 37 ˝C to 40 ˝C.Tofighi et al. [47] reported the reduction in cell mass productivity and ethanol fermentation ability of the thermotolerant yeast S. cerevisiae when the incubation temperature increased to greater than 40 ˝C.Recently, Charoensopharat et al. [43] found that the ethanol concentration produced by the newly isolated thermotolerant yeast K. marxianus decreased dramatically when ethanol fermentation was carried out at temperatures greater than 40 ˝C.
The pH of the medium is an important factor influencing ethanol yield.Generally, the optimum pH for yeast growth and ethanol production is in the range of 4.0 to 6.0 depending on growth conditions, such as the temperature, the presence of oxygen, the yeast species, and the type of raw material.For instance, the optimum pH for ethanol production from sugarcane juice at high temperatures using the thermotolerant yeast K. marxianus DMKU 3-1042 was 5.0 [13].During ethanol fermentation, the pH of the fermentation medium is almost in the range of 4.0 to 5.5.This pH level typically prevents bacterial contamination during the fermentation process [48].In this study, the effect of pH on ethanol production by the thermotolerant yeast S. cerevisiae DBKKU Y-53 and a reference strain was investigated, and the results are summarized in Tables 4 and 5.The optimum pH for ethanol production from SSJ by both strains at 37 ˝C and 40 ˝C was 5.5, which is in agreement with reports by Ercan et al. [49] and Sign and Bishnoi [50].At a pH less than or greater than 5.5, ethanol concentrations and volumetric ethanol productivities tended to decrease.This might be related to the activity of enzymes involved in the ethanol production pathway.It has been reported that enzymes may be inactivated at a pH level that is less than or greater than the optimum value causing a reduction in cell growth and ethanol fermentation ability [48].The initial pH of the SSJ was in the range of 5.2-5.5.Therefore, a pH of 5.5, which gave the highest ethanol concentration, was selected for further study.The initial cell concentration affects not only the ethanol yield but also the substrate consumption rate and ethanol fermentation rate.Generally, high initial cell concentrations reduce the lag phase of growth and increase the sugar consumption and ethanol fermentation rate, leading to a high ethanol yield and productivity.In this study, the effect of initial cell concentrations (1 ˆ10 6 , 1 ˆ10 7 , 1 ˆ10 8 cells¨mL ´1) on ethanol fermentation from SSJ containing 220 g¨L ´1 of total sugars was investigated, and the results are summarized in Tables 4 and 5.As a result, increasing the cell concentration resulted in an increase in the ethanol concentration and the volumetric ethanol productivity.The maximum ethanol concentrations and volumetric ethanol productivities produced by S. cerevisiae DBKKU Y-53 and SC09 at 37 ˝C and 40 ˝C were achieved at an initial cell concentration of 1 ˆ10 8 cells¨mL ´1, which is in good agreement with Charoensopharat et al. [43] and Laopaiboon et al. [51].
High sugar concentrations (more than 20% w/v) are not often used in industrial ethanol production because they may reduce the yeast cell viability, the substrate conversion rate, and the ethanol yield [52,53].However, ethanol production with high sugar concentrations have also been reported, and the fermentation efficiencies vary depending on the yeast species and fermentation conditions.For example, Laopaiboon et al. [54] reported a maximum ethanol concentration of 120.68 g¨L ´1 and volumetric ethanol productivity of 2.01 g¨L ´1¨h ´1 when S. cerevisiae NP01 was used to produce ethanol from SSJ under a very high gravity fermentation.Charoensopharat et al. [43] reported a maximum ethanol concentration of 104.83 g¨L ´1 and a volumetric ethanol productivity of 4.37 g¨L ´1¨h ´1 when K. marxianus DBKKU Y-102 was used to produce ethanol from Jerusalem artichoke tubers at 37 ˝C during consolidated bioprocessing.To verify the effect of sugar concentration on ethanol production efficiency of the thermotolerant yeast S. cerevisiae DBKKU Y-53, SSJ containing various sugar concentrations (200, 250, 300 g¨L ´1) was tested.As shown in Tables 4 and 5 increasing in the sugar concentration from 200 g¨L ´1 to 250 g¨L ´1 resulted in an increase in the ethanol concentration.However, at a sugar concentration of 300 g¨L ´1 the ethanol concentration was remarkably decreased, and a large amount of sugar remained in the fermentation broth at both 37 ˝C and 40 ˝C.High sugar concentrations have been reported to cause negative effects on cell viability and morphology due to an increase in the osmotic pressure, which leads to a reduction in the cell biomass and ethanol yield [53,55].The maximum ethanol concentrations produced by S. cerevisiae DBKKU Y-53 and SC90 were achieved at a sugar concentration of 250 g¨L ´1.Therefore, this sugar concentration was used for subsequent experiments.Approximately 10% of yeast's dry weight is nitrogen [44].Therefore, nitrogen is one of the important constituents for cell growth and synthesis of structural and functional proteins involved in metabolic processes.Various types of nitrogen sources have been used to supplement ethanol fermentation medium both in organic (yeast extract, corn steep liquor) and inorganic forms (ammonium sulfate, ammonium nitrate, urea, diammonium phosphate).In this study, the effects on ethanol production of using yeast extract, urea, and ammonium sulfate at different concentrations from SSJ by S. cerevisiae DBKKU Y-53 and SC90 were determined, and the results are summarized in Tables 6  and 7. Supplementation of urea in the SSJ was shown to significantly enhance the ethanol production by both strains of yeast at 37 ˝C and 40 ˝C, which is in good agreement with reports from Yue et al. [56].There was no significant difference in ethanol production at 37 ˝C when comparing yeast extract supplementation and supplementation-free fermentations.However, at 40 ˝C, supplementation of yeast extract tended to result in a lower ethanol concentration compared with the control condition.Yeast extract has been reported to be a good organic nitrogen source for ethanol production using S. cerevisiae.However, its availability to be utilized by yeast cells is depended on the fermentation conditions.For example, Laopaiboon et al. [54] reported that supplementation of yeast extract in SSJ improved the ethanol production by S. cerevisiae NP01 for very high gravity fermentation.With respect to ammonium sulfate, supplementation of this nitrogen compound resulted in a reduction of the ethanol concentration in all conditions tested compared with the control without nitrogen supplementation.These results clearly indicate that ammonium sulfate was not a good nitrogen source for ethanol production at high temperatures using S. cerevisiae DBKKU Y-53 and SC90 when SSJ was used as a substrate.One possibility is that this nitrogen compound was not taken up by the yeast cells during high temperature fermentation.Ter Schure et al. [57] and Magasanik and Kaiser [58] reported that the uptake of nitrogen by yeast cells is regulated by the mechanism known as nitrogen catabolite repression (NCR).NCR enables yeast cells to select the best nitrogen sources by repressing the transcription of genes involved in the utilization of the poorer nitrogen [59].However, the effectiveness of NCR mechanism is influenced by many factors including fermentation temperature and the presence of ethanol.Normally, high temperatures and high ethanol concentrations cause the modification of the plasma membrane.Therefore, the nitrogen sources sensing system, which is mainly located in the plasma membrane of yeast cells, may be affected by these stress conditions, leading to the impairment of ammonium sulfate uptake [60,61].In this study, urea proved to be the best nitrogen source for ethanol production from SSJ during high temperature fermentation using S. cerevisiae DBKKU Y-53 and SC90; therefore, it was chosen for further analysis.

Ethanol Production in 2-L Bioreactor
The time profiles of ethanol production from SSJ using S. cerevisiae DBKKU Y-53 and SC90 at 37  8 summarizes the kinetic parameters of ethanol production from the SSJ at high temperatures using S. cerevisiae DBKKU Y-53 and SC90.It can be seen from this finding that the newly isolated thermotolerant yeast S. cerevisiae DBKKU Y-53 resulted in a greater ethanol concentration as well as sugar utilization capability compared with SC90.

Ethanol Production in 2-L Bioreactor
The time profiles of ethanol production from SSJ using S. cerevisiae DBKKU Y-53 and SC90 at 37 °C and 40 °C in a 2-L bioreactor are illustrated in Figure 2.During the first 12 h after fermentation, ethanol concentrations produced by both strains sharply increased and reached their maximum values at 24 h for S. cerevisiae SC90 and 48 h for S. cerevisiae DBKKU Y-53.Table 8 summarizes the kinetic parameters of ethanol production from the SSJ at high temperatures using S. cerevisiae DBKKU Y-53 and SC90.It can be seen from this finding that the newly isolated thermotolerant yeast S. cerevisiae DBKKU Y-53 resulted in a greater ethanol concentration as well as sugar utilization capability compared with SC90.A comparative analysis of the ethanol production from SSJ using the thermotolerant yeast S. cerevisiae DBKKU Y-53 with values reported in the literatures using different raw materials and yeast strains was performed, and the results are summarized in Table 9.The ethanol concentration and volumetric ethanol productivity produced by S. cerevisiae DBKKU Y-53 were greater than values reported in other works, suggesting that the newly isolated thermotolerant yeast S. cerevisiae DBKKU Y-53 was a good candidate for ethanol production from SSJ at high temperatures.Although several isolates of the thermotolerant yeast K. marxianus have been reported to be capable of growth and ethanol production at temperatures greater than 45 ˝C, almost all of these isolates had relatively lower ethanol yields and were less tolerant to ethanol than S. cerevisiae.Furthermore, these isolates also required oxygen during ethanol fermentation resulting in an increase in the operating cost.Therefore, the thermotolerant yeast S. cerevisiae is more promising for ethanol production at high temperatures on a commercial scale compared with K. marxianus.This work will contribute a significant amount of information on ethanol production at an industrial scale.However, the ethanol production cost at a large-scale should be concerned.There are many techniques which can be employed to reduce the production cost; for example, cell recycling, various fermentation approaches, such as very high gravity fermentation, consolidated bioprocessing, and continuous ethanol fermentation using stirred tank bioreactor coupling with plug flow bioreactor [17,18,43,54].

Real-Time RT-PCR Analysis of Gene Expression
Stressful conditions during ethanol fermentation, such as high temperatures, and high concentrations of ethanol or sugar, have been reported to trigger the expression of several stress-responsive genes including those encoding HSPs, enzymes involved in protein degradation and in the glycolysis pathway, and other proteins involved in the synthesis of compatible solutes and reserve carbohydrates [22,23,25,66,67].In the present study, the expression levels of hsp26, hsp70, hsp90, hsp104, cdc, tps, nth, gsy, and rsp in the thermotolerant yeast S. cerevisiae DBKKU Y-53 and SC90 were determined using real-time RT-PCR.As shown in Figure 3, the expression of all genes was activated in both strains of yeast during ethanol fermentation at 40 ˝C.Although the expression levels of tps, nth, gsy, and rsp in S. cerevisiae DBKKU Y-53 and SC90 were not dramatically different, the genes encoding HSPs (hsp26, hsp70, hsp90, hsp104) in DBKKU Y-53 were much greater than in SC90.This finding suggests that high growth and ethanol fermentation capabilities of DBKKU Y-53 at a high temperature might be related to increased expression levels of HSP genes.Conversely, the expression level of cdc encoding pyruvate kinase, which is involved in ATP production, in SC90 was greater than that in DBKKU Y-53, suggesting that SC90 required more ATP for growth and ethanol production at high temperature.The results in this study were in good agreement with Auesukaree et al. [20], who observed high expression levels of genes encoding the small HSP, HSP70, HSP90, and HSP100 family and those genes encoding trehalose-6-phosphate synthase, neutral trehalase, and glycogen synthase in S. cerevisiae after heat shock and long-term heat exposure at 37 ˝C.Piper et al. [68] reported that several HSPs are constitutively expressed at appropriate temperatures and play a crucial role in folding and assembling proteins.Many of the HSPs, such as HSP70, HSP90, and HSP104, play an important role as molecular chaperones.These molecular chaperones depend on the energy of ATP hydrolysis for function [69].Therefore, increasing the expression level of cdc during ethanol fermentation at a high temperature may provide sufficient energy not only for growth and ethanol fermentation activity but may also function as molecular chaperones to protect the structural integrity of the proteins in yeast cells.In addition to the HSPs, the accumulation of trehalose has also been reported to be associated with heat stress protection and thermotolerance [70].Trehalose can stabilize the protein structure, reduce the aggregation of denatured proteins, and cooperate with HSPs to promote protein refolding [71][72][73].
In S. cerevisiae, ubiquitin ligase plays a key regulatory role in many cellular processes, such as trafficking, sorting, modifying gene expression, DNA repair, RNA transport as well as the degradation of a large number of proteins in multiple cellular compartments [74].This protein is also involved in the pathways responsible for the regulation of chromatin function and ultimately controls gene expression under limited nutrient conditions [75].Most recently, Shahsavarani et al. [76] also demonstrated that overexpression of RSP5 encoding ubiquitin ligase improved the ability of S. cerevisiae to tolerate high temperatures.An increase in the ubiquitin ligase, which was observed in this study by the high expression level of rsp during ethanol fermentation at high temperature, might regulate the transcription of some genes and induce the heat stress response through the ubiquitination process.Therefore, the ability of S. cerevisiae DBKKU Y-53 and SC90 to grow and produce a relatively high level of ethanol at a high temperature might be explained by this mechanism.
In the thermotolerant yeast K. marxianus, the molecular mechanisms conferring thermotolerance are complicated and are controlled by multiple genes not only for HSPs biosynthesis but also for those genes encoding the proteins involved in DNA replication and repair, RNA processing, ribosome biogenesis, and carbohydrate metabolism process [21].The expression of hsp genes and those functioning to prevent protein denaturation may be insufficient to allow growth and efficient ethanol fermentation of S. cerevisiae at high temperatures.To gain a better understanding and provide useful information for fundamental and applied research for innovative applications, further studies are required to clarify the precise mechanism conferring thermotolerance in S. cerevisiae.
37 °C.Piper et al. [68] reported that several HSPs are constitutively expressed at appropriate temperatures and play a crucial role in folding and assembling proteins.Many of the HSPs, such as HSP70, HSP90, and HSP104, play an important role as molecular chaperones.These molecular chaperones depend on the energy of ATP hydrolysis for function [69].Therefore, increasing the expression level of cdc during ethanol fermentation at a high temperature may provide sufficient energy not only for growth and ethanol fermentation activity but may also function as molecular chaperones to protect the structural integrity of the proteins in yeast cells.In addition to the HSPs, the accumulation of trehalose has also been reported to be associated with heat stress protection and thermotolerance [70].Trehalose can stabilize the protein structure, reduce the aggregation of denatured proteins, and cooperate with HSPs to promote protein refolding [71][72][73].

Conclusions
Utilization of high-potential thermotolerant ethanol-producing yeast is a promising approach to reduce the energy used in cooling systems and to also reduce the operating cost of ethanol production at high temperatures.In this study, the newly isolated thermotolerant ethanol-producing yeast designated as S. cerevisiae DBKKU Y-53 exhibited high growth and ethanol production efficiencies at high temperatures (37 ˝C and 40 ˝C) compared with the other isolated strains and the industrial ethanol producer S. cerevisiae SC90.The optimum conditions for ethanol production by this thermotolerant yeast using SSJ as a raw material were the following: a pH of 5.5, a sugar concentration of 250 g¨L ´1, a cell concentration of 1.0 ˆ10 8 cells¨mL ´1.The SSJ without the addition of an exogenous nitrogen source can be used directly as substrate for ethanol production at high temperatures by the thermotolerant yeast S. cerevisiae DBKKU Y-53.During ethanol fermentation at 40 ˝C, genes encoding HSP26, HSP70, HSP90, HSP104, pyruvate kinase, trehalose-6-phosphate synthase, neutral trehalase, glycogen synthase, and ubiquitin ligase were highly expressed in S. cerevisiae DBKKU Y-53 and SC90 compared with the expression levels at 30 ˝C.This finding suggests that the growth and ethanol fermentation activity of yeast at high temperatures were not only correlated with the expression of genes involved in heat-stress response but were also correlated with genes involved in ATP production, trehalose and glycogen metabolism, and the protein degradation process.
the newly isolated thermotolerant yeast S. cerevisiae DBKKU Y-53 during ethanol fermentation at high temperatures.

Figure 1 .
Figure 1.An unrooted phylogenetic tree showing the relationship between the isolated yeasts and the type strain K. marxianus and S. cerevisiae based on the D1/D2 domain of the 26s rDNA sequence analysis.The tree was built using the neighbor-joining method.Numbers given at the nodes indicate the percentage bootstrap values based on 1000 replications.

Figure 1 .
Figure 1.An unrooted phylogenetic tree showing the relationship between the isolated yeasts and the type strain K. marxianus and S. cerevisiae based on the D1/D2 domain of the 26s rDNA sequence analysis.The tree was built using the neighbor-joining method.Numbers given at the nodes indicate the percentage bootstrap values based on 1000 replications.

˝C and 40
˝C in a 2-L bioreactor are illustrated in Figure2.During the first 12 h after fermentation, ethanol concentrations produced by both strains sharply increased and reached their maximum values at 24 h for S. cerevisiae SC90 and 48 h for S. cerevisiae DBKKU Y-53.Table

Table 1 .
Primer used in this study.

Table 2 .
Ethanol production from sweet sorghum juice by isolated yeasts and the type strain, K. marxianus ATCC8554, at various temperatures.
P: ethanol concentration produced (g¨L ´1); Q p : volumetric ethanol productivity (g¨L ´1¨h ´1); Mean values ˘SD with different letters in the same column are significant different at p < 0.05 based on DMRT analysis.

Table 3 .
Kinetic parameters of ethanol production from sweet sorghum juice at various temperatures by S. cerevisiae DBKKUY-53 and S. cerevisiae SC90.

Table 4 .
Kinetic parameters of ethanol production from sweet sorghum juice under various pHs, cell concentrations, and sugar concentrations by S. cerevisiae DBKKUY-53 at 37 ˝C and 40 ˝C.
P: ethanol concentration (g¨L ´1); Q p : volumetric ethanol productivity (g¨L ´1¨h ´1); E y : percentage of ethanol production efficiency (%); Mean values ˘SD with different letters in the same column are significant different at p < 0.05 based on DMRT analysis.

Table 5 .
Kinetic parameters of ethanol production from sweet sorghum juice under various pHs, cell concentrations, and sugar concentrations by S. cerevisiae SC90 at 37 ˝C and 40 ˝C.
P: ethanol concentration (g¨L ´1); Q p : volumetric ethanol productivity (g¨L ´1¨h ´1); E y : percentage of ethanol production efficiency (%); Mean values ˘SD with different letters in the same column are significant different at p < 0.05 based on DMRT analysis.

Table 6 .
Kinetic parameters of ethanol production from sweet sorghum juice with various nitrogen sources by S. cerevisiae DBKKUY-53 at 37 ˝C and 40 ˝C.Q p : volumetric ethanol productivity (g¨L ´1¨h ´1); E y : percentage of ethanol production efficiency (%); Mean values ˘SD with different letters in the same column are significant different at p < 0.05 based on DMRT analysis.

Table 7 .
Kinetic parameters of ethanol production from sweet sorghum juice with various nitrogen sources by S. cerevisiae SC90 at 37 ˝C and 40 ˝C.

Table 7 .
Cont.Q p : volumetric ethanol productivity (g¨L ´1¨h ´1); E y : percentage of ethanol production efficiency (%); Mean values ˘SD with different letters in the same column are significant different at p < 0.05 based on DMRT analysis.

Table 8 .
Kinetic parameters of ethanol production from sweet sorghum juice by S. cerevisiae DBKKU Y-53 and S. cerevisiae SC90 in a 2-L bioreactor at 37 ˝C and 40 ˝C.

Table 9 .
Comparison of ethanol production by S. cerevisiae DBKKU Y-53 and other yeast strains reported in the literatures using different raw materials.