Enhancement of Lutein Production in Chlorella sorokiniana (Chorophyta) by Improvement of Culture Conditions and Random Mutagenesis

Chlorella sorokiniana has been selected for lutein production, after a screening of thirteen species of microalgae, since it showed both a high content in this carotenoid and a high growth rate. The effects of several nutritional and environmental factors on cell growth and lutein accumulation have been studied. Maximal specific growth rate and lutein content were attained at 690 μmol photons m−2 s−1, 28 °C, 2 mM NaCl, 40 mM nitrate and under mixotrophic conditions. In general, optimal conditions for the growth of this strain also lead to maximal lutein productivity. High lutein yielding mutants of C. sorokiniana have been obtained by random mutagenesis, using N-methyl-N′-nitro-nitrosoguanidine (MNNG) as a mutagen and selecting mutants by their resistance to the inhibitors of the carotenogenic pathway nicotine and norflurazon. Among the mutants resistant to the herbicides, those exhibiting both high content in lutein and high growth rate were chosen. Several mutants exhibited higher contents in this carotenoid than the wild type, showing, in addition, either a similar or higher growth rate than the latter strain. The mutant MR-16 exhibited a 2.0-fold higher volumetric lutein content than that of the wild type, attaining values of 42.0 mg L−1 and mutants DMR-5 and DMR-8 attained a lutein cellular content of 7.0 mg g−1 dry weight. The high lutein yield exhibited by C. sorokiniana makes this microalga an excellent candidate for the production of this commercially interesting pigment.

several reports describing the isolation of mutants of Haematococcus pluvialis, showing higher astaxanthin content per cell than the wild type by random mutagenesis with ethyl methane sulfonate (EMS) or UV and subsequent mutant selection on carotenoid biosynthesis inhibitors, such as compactin, nicotine, diphenylamine or norflurazon [23][24][25]. However, there is no available information on the obtention of high lutein yielding mutants most probably because cell growth is negatively affected in these mutants.
The present study describes: (1) The screening of thirteen different microalgae to select a good candidate for lutein production; (2) The effect of some nutritional and environmental factors on growth and lutein content in Chlorella sorokiniana, the selected species; and (3) The obtention of mutants of C. sorokiniana with high yields of lutein in comparison to the wild type strain by random chemical mutagenesis using MNNG.

Screening of Different Species of Chlorophycean Microalgae for Lutein Production
Cell growth and carotenoid content of cultures of 13 chlorophycean microalgae are shown in Table 1. In all species lutein was the most abundant carotenoid. The highest lutein levels (24 mg L −1 ) were found in C. sorokiniana, Monoraphidium braunii, Scenedesmus armatus and Scenedesmus vacuolatus (Table 1). Other carotenoids like antheraxanthin, α-carotene, β-carotene, violaxanthin and zeaxanthin were also produced in all the tested species albeit at concentrations lesser than lutein. Astaxanthin and canthaxanthin were present only in Chlorella fusca, Chlorella zofingiensis, Chlorococcum sp. and S. vacuolatus. With regard to growth, C. sorokiniana and S. armatus exhibited the highest specific growth rates of 0.11 and 0.09 h −1 , respectively, and for most species the maximum biomass value attained in the culture ranged between 7.5 to 8.5 g L −1 , except for Chlamydomonas reinhardtii, Chlorella luteoviridis and Chlorella stigmatofora, which showed lower biomass values. Table 1. Specific growth rate (µ), biomass and carotenoids levels in cultures of several species of chlorophycean microalgae. Culture conditions for all the species were the standard ones as reported in the Experimental Section. Data correspond to the maximal values attained in the culture at the deceleration phase: 9-10 days ( a ), 11-12 days ( b ) and 13-14 days ( c ) of culture, being the means of three independent measurements. The standard deviation (SD) is omitted since it was lower than 10% of the mean values. Carotenoids: Ant, antheraxanthin; Ast, astaxanthin; C, canthaxanthin; α-c, α-carotene; β-c, β-carotene; L, lutein; V, violaxanthin; Z, zeaxanthin. nd: not detected.  Some of the species considered in this work, such as C. sorokiniana, M. braunii, S. armatus and S. vacuolatus are of potential practical interest on the basis of their high lutein level. Among these, C. sorokiniana has been selected for further work focused on the production of lutein, since this microalga also shows the highest specific growth rate (0.11 h −1 ) and a high biomass value (8.0 g L −1 ).  Figure 1 shows the evolution with time of growth and lutein content in a photoautotrophic batch culture of C. sorokiniana. Both volumetric and cellular lutein content increased with cell biomass, attaining a maximum of 24 mg L −1 at the end of the deceleration phase, and 4.2 mg g −1 DW in the early deceleration phase, respectively. However, whereas the volumetric content was kept constant in the deceleration phase, the cellular content decreased markedly to 2.8 mg g −1 DW. The accumulation of the rest of carotenoids followed the same trend as lutein (data not shown).

Effect of Irradiance
Cell growth and lutein accumulation in C. sorokiniana batch cultures at different irradiances, in the range from 92 to 1495 µmol photons m −2 s −1 , was studied. Both specific growth rate and biomass in the culture increased with irradiance until 690 µmol photons m −2 s −1 , by 2.6-fold and 1.5-fold, respectively, keeping constant at higher intensity values. Lutein content in the culture was enhanced by 87% as irradiance increased from 92 to 690 µmol photons m −2 s −1 , decreasing at higher irradiance values. Cellular lutein content exhibited an optimum in an irradiance range between 368 and 690 µmol photons m −2 s −1 , decreasing at higher and lower irradiances by 22 and 19%, respectively ( Table 2). The maximum cellular lutein content (4.3 mg g −1 DW) was reached at 690 µmol photons m −2 s −1 , in the early deceleration phase of growth (data not shown).

Figure 1.
Kinetics of growth and lutein accumulation in a batch culture of C. sorokiniana under standard conditions. Culture conditions were the standard ones reported in Experimental Section. Data shown represent the mean values of three independent measurements, SD being lower than 10% of the means. Symbols: (closed circles) dry cell weight; (open circles) volumetric lutein content in the culture; (closed triangles) cellular lutein content. Table 2. Effect of irradiance on growth and lutein accumulation in C. sorokiniana. Cells were grown at the indicated irradiances, the rest of culture conditions being the standard ones described in Experimental Section. Biomass and lutein content data correspond to the mean values of three independent measurements recorded after 10 days, at the end of the deceleration phase, when the maximal volumetric lutein contents and biomass values were attained in the cultures. The SD were lower than 10% of the means. The influence of temperature on lutein level and growth of C. sorokiniana has also been examined. Cell growth, in terms of specific growth rate, increased by 50% when the temperature was raised from 25 to 28 °C, keeping constant at higher temperatures. Biomass in the culture increased by about 10% with temperatures up to 28 °C, decreasing by 44% at higher temperatures. Optimal volumetric and cellular lutein contents were recorded in a range from 28 to 32 °C, decreased values being registered at lower and higher temperatures ( Table 3). The maximum cellular lutein content (4.2 mg g −1 DW) was achieved at 28 °C in the early deceleration phase of growth (data not shown). Table 3. Effect of temperature on growth and lutein accumulation in C. sorokiniana. Cells were grown at the indicated temperatures, the rest of culture conditions being the standard ones described in Experimental Section. Biomass and lutein content data are the mean values of three independent measurements recorded after 9 days, when cultures were at the end of deceleration phase, which corresponds to the maximal volumetric lutein contents and biomass attained in the cultures. The SD were lower than 10% of the means. Nitrogen availability affects carotenoid accumulation in some microalgae [14], therefore the effect of nitrate concentration on lutein production was also assayed. Both specific growth rate and biomass in the culture increased by 30% when nitrate concentration in the medium was enhanced from 10 to 40 mM, decreasing by about 15% at higher concentrations. In addition, volumetric and cellular lutein contents increased 2.9 and 2.3-fold, respectively, when nitrate concentration in the medium was raised from 10 to 40 mM, decreasing by about 10% at higher nitrate concentrations (Table 4). Nevertheless, maximum cellular lutein content did not change significantly with nitrogen concentration in the range from 20 to 80 mM (data not shown). Table 4. Effect of nitrate concentration on growth and lutein accumulation in C. sorokiniana. Cells were grown at the indicated concentrations of NaNO 3 , the rest of culture conditions being the standard ones described in Experimental Section. Biomass and lutein content data are the mean values of three independent measurements recorded after 10 days, when cultures were at the end of the deceleration phase, which corresponds to the maximal volumetric lutein contents and biomass attained in the cultures. The SD were lower than 10% of the means.

Effect of NaCl
The influence of NaCl concentration in the medium was also analyzed in a range from 2 to 200 mM. Both growth and lutein content decreased drastically at NaCl concentrations higher than 2 mM (data not shown).

Effect of Acetate and Glucose (Mixotrophic Culture)
The main limiting factor for biomass productivity in photoautotrophic cultures of microalgae is imposed by light availability. To solve this problem mixotrophic cultures can be used. For that reason the effect of acetate, as an extra source of carbon, on growth and lutein accumulation was assayed in C. sorokiniana. As shown in Table 5, specific growth rate and biomass in the culture were enhanced by 33% and 20%, respectively, when acetate concentration in the medium was raised from 0 to either 40 or 50 mM, decreasing only by 8% thereafter. The volumetric and cellular lutein contents increased by 45% and 20%, respectively, when acetate was added to the medium at concentrations up to 40 mM, decreasing by a 25% at higher acetate concentrations. The maximum cellular lutein content followed the same trend as cellular lutein content at the end of the deceleration phase, attaining maximum values of 5.2 mg g −1 DW at 40 mM of acetate (data not shown). Table 5. Effect of acetate concentration on growth and lutein accumulation in C. sorokiniana. Cells were grown mixotrophically by the addition of sodium acetate at the indicated concentrations at the beginning of the culture, the rest of culture conditions being as described in Experimental Section. Biomass and lutein content data are the mean values of three independent measurements recorded after 10 days, when cultures were at the end of deceleration phase, which corresponds to the maximal volumetric lutein contents and biomass attained in the cultures. The SD were lower than 10% of the means. The addition of glucose, as the only extra carbon source, to cultures of C. sorokiniana increased by 60% the biomass in the culture and by 12% the volumetric lutein content, which attained a level of 33.5 mg L −1 , the cellular lutein content decreasing by 30% (Table 6). A similar effect was observed when glucose was added to cultures containing 40 mM acetate before the end of the exponential phase, reaching a volumetric lutein content of 35.0 mg L −1 . On the other hand, an extra addition of acetate or sodium nitrate before the end of the exponential phase did not affect either biomass or lutein content significantly. Moreover, when sodium nitrate was replaced by urea, the specific growth rate and lutein content were decreased by 17% and 20%, respectively. Table 6. Effect of carbon or nitrogen extra supply on growth and lutein accumulation in C. sorokiniana. Cells were grown mixotrophically at an irradiance of 690 µmol photons m −2 s −1 in Arnon medium modified to contain 4 mM K 2 HPO 4 , 40 mM sodium nitrate and 40 mM sodium acetate (AM), except where indicated ( b,c ). a Addition of glucose, extra nitrate or acetate during exponential phase after 24 h of culture. b Nitrate was replaced by urea at the beginning of the culture. c Acetate was replaced by glucose at the beginning of the culture. The rest of culture conditions were as described in Experimental Section. Biomass and lutein content data are the mean values of three independent measurements recorded after 10 days, when cultures were at the end of the deceleration phase, which corresponds to maximal volumetric lutein contents and biomass attained in the cultures. The SD were lower than 10% of the means. Similar values of growth and lutein content were registered when sodium nitrate was replaced by ammonium nitrate. When C. sorokiniana was grown heterotrophically in the dark with glucose as the only carbon source, specific growth rate was similar and biomass decreased only slightly with regard to the values obtained under mixotrophic conditions, however lutein accumulation was much lower than that measured in mixotrophic or photoautotrophic conditions (data not shown).

Isolation of High Lutein Yielding Mutants of C. sorokiniana
To obtain high lutein producing mutants of C. sorokiniana, cells were subjected to random chemical mutagenesis with MNNG and mutants were screened on the basis of their resistance either norflurazon or nicotine, growth rate and lutein content. First, the survival curve for mutagenesis with MNNG was performed to determine the MNNG concentration which resulted in around 5-10% of cells viability (Figure 2), and afterwards, a wide range of concentrations of the herbicides were tested to find out the minimal concentration which inhibited the grown of the wild strain, resulting in 400 µM for nicotine and 4 µM for norflurazon (data not shown).
According to the first step of selection, 745 herbicide-resistant colonies were obtained, from which only 222 (210 resistant to norflurazon and 12 resistant to nicotine) were selected according to the second step criterion, which consisted of discarding mutants exhibiting either low growth or unstable resistance to the herbicides. The selected mutants were grown in shaken liquid cultures under photoautotrophic standard conditions to determine lutein content and growth rate. Increases in volumetric and cellular lutein contents of the best mutants as compared to the wild type are shown in Table 7. The mutant MR-16, resistant to nicotine, exhibited volumetric and cellular lutein contents 2.0-and 1.4-fold higher, respectively, than those of the wild strain. This mutant also showed a 3.0-fold higher volumetric α-carotene and antheraxanthin levels and 2.0-fold higher β-carotene and zeaxanthin contents as compared with those of the wild type, being the total volumetric carotenoid content 2.0-fold higher than in the wild strain (data not shown). The mutants DMR-5 and DMR-8, both resistant to norflurazon, stood out in terms of cellular content in lutein, showing 53-55% increase relative to the wild type, reaching values of 7.0 mg lutein g −1 DW.

Figure 2.
Survival curve of C. sorokiniana to the chemical mutagen MNNG. Data shown represents mean values of three independent measurements, SD being lower than 10%. Table 7. Increase in lutein content of the best mutants of C. sorokiniana relative to the wild type. Cells were grown photoautotrophically in shaken cultures at 50 µmol photons m −2 s −1 , the rest of conditions being the standard ones described in Experimental Section. Data are mean values of three independent measurements in the deceleration phase after 13 days of growth, SD being lower than 10%. NF: resistant to norflurazon; NIC: resistant to nicotine. Moreover, the growth of the selected high lutein producing mutants under photoautotrophic conditions was similar or even higher than that of the parental strain, as shown in the Figure 3 for MR-16.  Table 7. Data shown represent mean values of three independent measurements, SD being lower than 10%. Symbols: (closed circle) wild type; (open circles) mutant MR-16.
All mutants of C. sorokiniana obtained in the processes of mutagenesis were analyzed for their viability and stability by consecutive sub-cultures in nonselective and selective media with herbicides to check their resistance.  Table 7). For this reason, cells of the wild type and the MR-16 mutant were grown under the best photoautotrophic and mixotrophic conditions found previously in the wild strain of C. sorokiniana for lutein accumulation in order to know accurately the improvement of the MR-16 mutant as compared to the wild type. As shown in Table 8, the volumetric and cellular lutein contents increased both by 68% in the mutant MR-16 with respect to the wild strain when the mutant was grown photoautotrophically, attaining maximum values of 42.0 mg L −1 and 5.0 mg g −1 DW at the end of the deceleration phase. On the other hand, specific growth rate was either constant or very similar at the different conditions assayed in both strains. However when the mutant was grown mixotrophically, biomass decreased 40% as compared to the wild strain. The addition of acetate and glucose to cells of the MR-16 mutant had a negative effect decreasing a 48% the maximum lutein content in the culture, and a 33% the cellular content with regard to the parental strain. A difference between the wild and the mutant C. sorokiniana strains was that the wild type showed the maximum values of cellular lutein during the early deceleration phase, whereas MR-16 mutant attained these contents at the end of the deceleration phase, due to a continuous and higher lutein accumulation. Table 8. Growth and lutein accumulation in MR-16 mutant and wild strain of C. sorokiniana under photoautotrophic and mixotrophic conditions. Cells were grown photoautotrophically at an irradiance of 690 µmol photons m −2 s −1 in Arnon medium modified to contain 4 mM K 2 HPO 4 and 40 mM sodium nitrate, and mixotrophycally by the addition of both 40 mM sodium acetate and 100 mM glucose after 24 h of culture (by the middle of the exponential phase). The rest of culture conditions were as described in Experimental Section. Biomass and lutein content data are the mean values of three independent measurements recorded after 10 days, when cultures were at the end of the deceleration phase, which corresponds to maximal volumetric lutein content and biomass attained in the cultures. The SD were lower than 10% of the means.

Effect of Several Environmental and Nutritional Factors on Lutein Production by C. sorokiniana under Photoautotrophic Conditions
Since irradiance, temperature, NaCl and nitrate concentration are known to affect the levels of different carotenoids in microalgae, the effect of these factors on cell growth and lutein accumulation was analyzed in C. sorokiniana which has been selected among thirteen chlorophycean microalgae, since it showed the highest growth rate and lutein accumulation. In this selected microalga lutein content in the culture was optimal at moderate irradiances, since both biomass and cellular content in lutein decreased at both high and low irradiance ( Table 2). A similar trend with regard to the cellular content has also been observed for lutein and β-carotene in different species of C. zofingiensis and Muriellopsis sp. [26,16,18]. In contrast, in H. pluvialis and C. zofingiensis the cellular content of secondary carotenoids, such as astaxanthin and canthaxanthin, followed the opposite trend to lutein, being enhanced at high irradiance [18,27]. C. sorokiniana exhibited maximal volumetric and cellular lutein content in the range of 28 to 32 °C decreasing at lower and higher temperatures (Table 3); these results being in agreement with those obtained in the lutein-producing microalga C. zofingiensis [16] and Scenedesmus almeriensis [20,28]. Contrastingly, extreme temperatures triggered carotenogenesis in H. pluvialis. It has been suggested that endogenously generated active oxygen is responsible for the stimulation of astaxanthin synthesis at high temperature in this microalga [24]. Nitrogen limitation enhances the synthesis of secondary carotenoids such as astaxanthin, but reduces biomass yield. However, nitrogen at none limiting concentrations is required for primary carotenoids accumulation due possibly to the need of a continued synthesis of light-harvesting proteins and structural xanthophylls under optimal growth conditions [3,16,18]. This agrees with the results obtained in C. sorokiniana since both volumetric and cellular lutein content increased when nitrate concentration in the culture medium was raised from 10 to 40 mM, decreasing slightly at higher nitrate concentrations (Table 4). On the other hand, although in heterotrophic cultures of C. protothecoides maximal lutein productivities were achieved using urea as the nitrogen source [29], in C. sorokiniana grown mixotrophically either a slight decrease or no effect in growth and lutein content was registered when sodium nitrate was replaced by either urea (Table 6) or ammonium nitrate (data not shown). NaCl stress, which has been described to induce the biosynthesis of secondary carotenoids [30], seems not to trigger the biosynthesis of the primary ones. Thus in C. sorokiniana, both growth and lutein content decreased drastically when NaCl concentrations were increased (data not shown), and in the cases of other chlorophyta as Muriellopsis sp., C. zofingiensis and S. almeriensis, the lutein levels per cell remained practically constant at the different NaCl concentrations assayed [16,18,20]. Therefore, although stress factors, such as high irradiance, extreme temperatures, high NaCl concentration or nutrients limitation enhance the cellular accumulation of secondary carotenoids, such as astaxanthin [1,18,31], these factors do not increase the cellular levels of lutein in C. sorokiniana, since lutein is a primary carotenoid, being required for the structure and function of the light-harvesting complexes in photosynthesis [2], and accordingly, conditions that increase photoautotrophic growth of this microalga are also those enhancing lutein accumulation.

Lutein Production by C. sorokiniana under Mixotrophic Conditions
In photoautotrophic mass cultures of microalgae for the production of biomass and valuable compounds, the main limiting factor is usually light availability, which in many cases limits cell density and productivity of the cultures, making it unprofitable for industry. An alternative to overcome this problem is to use mixotrophic cultures. In C. sorokiniana, the addition of acetate to the cultures enhanced both growth and volumetric and cellular lutein contents (Table 5). Although it is known that acetate enhances growth and synthesis of astaxanthin in H. pluvialis [32], the effect of this carbon source on the biosynthesis of lutein has not been studied in other microalgae. Even though the addition of glucose decreased the cellular content in lutein, it increased biomass considerably; therefore, the volumetric lutein content was enhanced and the highest volumetric lutein levels (35 mg L −1 ) were achieved in cultures supplemented with this carbon source (Table 6). Therefore the supply of an extra carbon source to cultures supported higher growth and productivity, overcoming the limitation by light. Recently, it has been shown that in heterotrophically grown C. zofingiensis, glucose increased the cellular accumulation of astaxanthin and zeaxanthin by increasing the transcription levels of both β-carotene ketolase and β-carotene hydroxylase involved in the synthesis of these carotenoids, but decreased the cellular content of lutein and chlorophyll [33,34] and in C. protothecoides lutein productivity was much higher in heterotrophic cultures supplemented with glucose than in photoautotrophic cultures, since in the former very high cell densities were achieved [35]. Therefore, our results are in agreement with these findings, which indicate that although glucose decreases the celular content of lutein, it increases considerably the biomass, therefore resulting in a higher lutein production in mixotrophic cultures as compared to those performed photoautotrophically.

Enhancement of Lutein Yield in C. sorokiniana by Random Mutagenesis
There are few reports concerning the isolation of high carotenoid yielding mutants of microalgae by random mutagenesis. A mutant of Chlorella regularis showing a high cellular content of lutein has been isolated by Ishikawa et al. (2004) [36], although it exhibited lower growth than the wild strain and no volumetric lutein content data have been reported. Some mutants with enhanced accumulation of astaxanthin have also been described, however their growth rates are usually lower than that of the wild type [37,23,38]. In our experiments with C. sorokiniana, mutants were selected not only on the basis of high lutein content, but also according to a high growth rate. Thus, the mutant MR-16 exhibited a growth and cellular lutein content higher than those of the wild type and, as a consequence, lutein yields 2.0-fold higher than those measured in the wild strain were achieved (Table 7 and Figure 3). In addition, this mutant shows the highest lutein content described in the literature under photoautotrophic conditions of growth at laboratory scale [14,16,[18][19][20], attaining a value of 42.0 mg L −1 at the end of the deceleration phase ( Table 8). The mutant MR-16 was resistant to nicotine, a specific inhibitor for the enzyme lycopene β-cyclase, involved in lutein biosynthesis, which could possibly have an altered specific activity in this mutant, for instance a modified structure for the herbicide-binding site, and/or a different expression of this enzyme, which means a higher enzyme activity, and would result into an improved lutein production under photoautotrophic growth. In addition, the higher growth rate of this mutant with respect to the wild type strain under photoautotrophic conditions could be due to the higher cellular lutein content, since this carotenoid plays important roles in the function, structure and photo-protection of the photosynthetic apparatus, leading to a higher photosynthetic efficiency. It is relevant to mention that the addition of acetate and/or glucose to the culture medium decreased the biomass in the cultures of MR-16. The mechanism of this effect is not understood yet. It is possible that the mutation has provoked a metabolic alteration causing a weak repression of growth by glucose or acetate.

C. sorokiniana as a Promising Lutein Producer for Commercial Applications
Although microalgae are not used yet as a lutein source at industrial scale, first steps have been made at laboratory and pilot scales in the recent years [16,14,28,21]. The data here reported point to C. sorokiniana as an attractive candidate for the production of lutein, since it shows a high growth rate (0.12 h −1 ), a volumetric lutein content of 35 mg L −1 and cellular lutein contents of 5.2 mg g −1 DW, which are enhanced by random mutagenesis up to 42.0 mg L −1 and 7.0 mg g −1 DW. These values are similar or higher than those reported for other lutein producing microalgae grown at laboratory scale under photoautotrophic conditions. Thus, C. zofingiensis shows a specific growth rate of 0.04 h −1 and a volumetric and cellular lutein content of 20.0 mg L −1 and 3.0 mg g −1 DW, respectively [18,14]; Scenedesmus almeriensis has been reported to accumulate 5.5 mg g −1 DW and a specific growth rate of 0.07 h −1 [20]; Muriellopsis exhibited a growth rate of 0.17 h −1 and a volumetric and cellular lutein content of 29.0 mg L −1 and 5.5 mg g −1 DW, respectively [16]; and Coccomyxa acidophila has been reported to accumulate 6.1 mg g −1 DW under extreme culture conditions [19]. From all this information, we can propose C. sorokiniana as a promising microalgal species for the production of lutein for commercial applications.

Organisms
The

Standard Culture Conditions
Cells were grown photoautotrophically by bubbling through the cell suspension air supplemented with 1% (v/v) CO 2 as the only source of carbon. The culture medium of Arnon et al. (1974) [39] modified to contain 4 mM K 2 HPO 4 and 20 mM NaNO 3 , was used. The cells were grown in batch culture at 28 °C, in Roux flasks of 1 L capacity, laterally illuminated with mercury halide lamps at 460 µmol photons m −2 s −1 , measured at the surfaces of the flasks using a LI-COR quantum sensor (model L1-1905B, Li-Cor, Inc. Lincoln, NE, USA) connected to a quantum photometer.

Mixotrophic Culture Conditions
Cells were grown mixotrophically by the addition to Arnon medium (modified to contain 4 mM K 2 HPO 4 and 20 mM NaNO 3 ) sodium acetate and/or glucose, either at the beginning of the culture or after 24 h (by the middle of the exponential phase) and at an irradiance of either 460 or 690 µmol photons m −2 s −1 . The rest of culture conditions were the same as the standard ones.

Random Mutagenesis and Selection of High Lutein Yielding Mutants of C. sorokiniana
Cells of C. sorokiniana in the exponential phase of growth (10 6 cells mL −1 ) were harvested by centrifugation (2700× g, 10 min), washed with sterile water and treated with 0.1 mg mL −1 of 1-methyl-3-nitro-1-nitrosoguanidine (MNNG) (survival rate 5-10%) for 1 h. This mutagen is known to induce nucleotides substitutions at high frequencies and little lethality, and the inhibitors nicotine and norflurazon were used as the selection method. These herbicides inhibit the carotenogenic enzymes lycopene β-cyclase and phytoene desaturase, respectively. Therefore, the screening of the mutants was performed by their resistance to the carotenoid biosynthesis inhibitors nicotine and norflurazon.
The treated cells were washed with sterile water, resuspended in Arnon modified medium and incubated under dim light during 24 h. After the incubation, cells were spread on solid modified Arnon medium containing, either 4 µM norflurazon (Supelco, Bellefonte, PA, USA) or 400 µM nicotine (Sigma-Aldrich, Steinheim, Germany) and incubated at 25 °C and 50 µmol photons m −2 s −1 for 3-4 weeks. Then, the herbicide-resistant colonies were sub-cultivated several times in solid medium containing either norflurazon or nicotine to check their resistance to the herbicide and growth in solid medium. Herbicide-resistant mutants that showed good growth were grown in 100 mL-capacity erlenmeyers under photoautotrophic conditions, shaken at 100 rpm and illuminated from the top at 50 µmol photons m −2 s −1 , in order to analyze carotenoids content and growth.

Analytical Methods
For dry weight (DW) determinations, 5 mL aliquots of the cell culture were filtered through pre-dried Whatman GF/C paper (Whatman International Ltd., Maidstone, England), washed three times with distilled water, and the filters containing the algae were dried at 80 °C for 24 h.
Specific growth rate (µ) was calculated from the measured DW during the exponential phase of growth, using the equation: µ = (ln x 2 − ln x 1 )/(t 2 − t 1 ), where x 2 and x 1 represent DW values in terms of g L −1 at times t 2 and t 1 , respectively.
For carotenoid analysis, pigments were extracted with methanol at 70 °C, centrifuged, the supernatant evaporated under N 2 and the pellet dissolved in methanol. Then the samples were centrifuged and analyzed by HPLC using a Waters Spherisorb ODS2 column (4.6 × 250 mm, 5 µm particle size) (Waters, Mildford, MA, USA). The chromatographic method described by Cordero et al. [40] was used. The pigments were eluted at a flow rate of 1.2 mL min −1 and detected at 440 nm using a Waters 2996 photodiode-array detector. Identification of carotenoids was achieved by comparison of the individual characteristic absorption spectrum and the retention time with known standards. Quantification was performed using a calibration curve generated with commercially available carotenoids standards from Sigma-Aldrich (St. Louis, MO, USA) and DHI (Holsholm, Germany).
Samples analyzed were withdrawn along the curve of growth. Independent triplicate analyses were carried out for each sample, the results representing the mean values. The standard deviation (SD) is omitted since it was lower than 10% of the mean values.

Conclusions
Chlorella sorokiniana has been selected for lutein production after a screening of thirteen species of microalgae. The effects of several nutritional and environmental factors on cell growth and lutein content have been studied. Maximal specific growth rate and lutein accumulation were attained at 690 µmol photons m −2 s −1 , 28 °C, 2 mM NaCl, 40 mM nitrate and under mixotrophic conditions, attaining values of lutein of 35.0 mg L −1 and 5.2 mg g −1 DW. In general, optimal conditions for the growth of this species also lead to maximal lutein productivity, since lutein is a primary carotenoid, being required for the structure and function of the light-harvesting complexes in photosynthesis. These lutein values were further enhanced by chemical random mutagenesis up to 42.0 mg L −1 and 7.0 mg g −1 DW, using MNNG and selecting mutants by: (1) their resistance to the inhibitors of the carotenogenic pathway nicotine and norflurazon; (2) their high growth rate; and (3) high lutein content. From all our results we can propose C. sorokiniana as an interesting and promising microalga for the production of lutein for commercial and industrial applications.