ijerph International Journal of Environmental Research and Public Health Int. J. Environ. Res. Public Health International Journal of Environmental Research and Public Health 1660-4601 MDPI 10.3390/ijerph9041068 ijerph-09-01068 Article Respiratory Symptoms and Pulmonary Functions of Workers Employed in Turkish Textile Dyeing Factories Ozkurt Sibel * Kargi Beyza Akdag Kavas Murat Evyapan Fatma Kiter Göksel Baser Sevin Medical Faculty, Pamukkale University, Denizli 20100, Kinikli, Turkey; Email: bakdag@pau.edu.tr (B.A.K.); kavas_murat@yahoo.com (M.K.); ffisekci@yahoo.com (F.E.); gokselkiter@yahoo.com (G.K.); basersevin@yahoo.com (S.B.) Author to whom correspondence should be addressed; Email: sozkurt@pau.edu.tr; Tel.: +90-0258-444-0728; Fax: +90-0258-213-4922. 26 03 2012 04 2012 9 4 1068 1076 28 02 2012 19 03 2012 20 03 2012 © 2012 by the authors; licensee MDPI, Basel, Switzerland. 2012

This article is an open-access article distributed under the terms and conditions of the Creative Commons Attribution license (http://creativecommons.org/licenses/by/3.0/).

Dyes are known to be a causative agent of occupational asthma in workers exposed to them. We have evaluated respiratory symptoms among textile workers. The study population comprised 106 exposed workers and a control (unexposed) group. Data were collected by a questionnaire. PFTs (Pulmonary Function Test) were performed. Among the exposed workers 36.8% defined phlegm. Respiratory symptoms were not significantly different between two groups. The employment duration of the exposed workers with phlegm was longer than those without phlegm (p = 0.027). The mean % predicted of FEF25–75 of the exposed workers was found to be significantly lower than the control (unexposed) group (p = 0.01). Our study suggests that textile dyeing might cause respiratory symptoms in workers.

textile dyes respiratory symptoms pulmonary function test 1. Introduction

Dyes, especially reactive ones, are known to be a causative agent of occupational asthma, rhinitis and dermatitis in workers exposed to them [1,2,3,4]. Docker et al. showed that more than 15% of workers handling reactive dyes had work-related respiratory or nasal symptoms and considered that the symptoms could be attributed to an irritant response to chemicals used in this industry, including hydrochloric acid vapor, sulfur dioxide, as well as the reactive dyes themselves [5].

There are numerous publications on the effect of dust on the respiratory system of textile workers employed in processing textile materials such as cotton, hemp, flax and wool [6,7,8,9,10,11,12,13,14]. However, there are few available studies on respiratory function in the workers employed in the textile dyeing industry [15]. Viegi et al. evaluated respiratory functions in workers of a dyeing factory and found the prevalence of chronic bronchitis and dyspnea to be 32%, flow rates were significantly lower than reference values [16].

We planned this study to evaluate chronic respiratory symptoms among textile workers exposed to textile dyes and compare the respiratory symptoms and Pulmonary Function Test (PFT) results of exposed workers with a control group who were not exposed to textile dyes at work. To the best of our knowledge, this is the first study in our country (Turkey) which evaluates respiratory symptoms and PFTsof textile workers exposed to textile dyes.

 2. Material and Methods 2.1. Background

This study was conducted at textile dyeing factories. Among the textile dyeing factories located in the Denizli Industrial Zone, which has over a hundred textile factories, three of them which have given permission for the study were included in the research. These factories were experts in textile dyeing, and had over two hundred workers at each.

2.2. Patients and Study Design

Data were collected from 106 exposed workers and 106 in the control (unexposed) group (only working in the managerial departments of the textile dyeing factories). To avoid collection bias, all data for the exposed workers, including questionnaires, were collected by two experienced pulmonologists. Data on demographics, episodes of wheezing or chest tightness, symptoms of dyspnea, cough, phlegm, any other allergic and/or respiratory symptoms, duration of symptoms, past medical history (Are there any pulmonary diseases which were diagnosed by a doctor in the past? and pulmonary diseases that were not particularly investigated but might be were related to their occupational history, were identified by a questionnaire), smoking habits were determined by a questionnaire modified from the American Thoracic Society Questionnaire [17]. The questionnaire was administered in a person to person interview.

Pulmonary function tests were performed with a portable spirometer (MIR Spirobank) according to American Thoracic Society criteria while the patients were at rest and seated in the upright position. A minimum of three satisfactory forced expiratory manoeuvers was required of each subject. A satisfactory test required that the forced vital capacity (FVC) and forced expiratory volume in 1 second (FEV1) of two manoeuvers was reproducible within 5% [18]. Analyses were performed on the largest FVC and FEV1 expressed as percentage of the predicted value. The FVC, FEV1 and forced expiratory flow at 25% to 75% of the FVC (FEF25–75) and peak expiratory flow (PEF) were determined.

Non-smokers were defined as those who had never smoked regularly, smokers were currently smoking at least one cigarette daily, ex-smokers were those who had formerly smoked regularly but gave it up at least 6 months before the study. Control (unexposed) subjects (n = 106) were employees in the managerial departments of the textile dyeing factories and had similar age, sex, smoking habits, social and economic status. The same questionnaire and PFTs were administered to the control group.

 2.3. Textile Dyeing Procedure

The dyeing was performed in several large open vats located in a large area with a temperature of 60 °C to 80 °C. The cotton materials were first sorted by type and then manually placed into vats and boiled for one hour.

The dyeing process used different types of commercially available azo and reactive dyes in addition to many other chemical agents. The dyes included: reactive dyes; azo and anthraquinone derivatives. The dyes were purchased from Germany.

Before dyeing, the materials are treated with acetic acid (CH3COOH), formic acid (HCOOH), sodium hydroxide (NaOH), sodium hydrosulphide (NaHS). At high temperatures vapors of different agents are released, including hydrogen (H2S) and nitrogen oxides (when azo dyes are used), as well as other vapors released from dyes, which may be found in the workplace atmosphere and inhaled by exposed workers. These workers were also exposed to high temperatures and to a high relative humidity in the workplace. Measurements of dusts, fumes and gases [acetic acid (CH3COOH), formic acid (HCOOH), sodium hydroxide (NaOH), sodium hydrosulphide (NaHS)] were not performed in the workplaces.

 2.4. Statistical Analysis

Descriptive statistics (including Mean ± SD, frequency and percentage) were calculated for two groups separately. The difference between the means of variables in two groups was compared using Independent Samples t test and the difference between the medians of variables in two groups was compared using Mann Whitney U test. The Chi-Square test was used to compare categorical variables. The statistical significance was set at p < 0.05. The statistical analyses were performed with the statistical package program SPSS version 11.5.

 3. Results 3.1. Characteristics of Patients

Our study population comprised 106 exposed workers (23.6% female and 76.4% male) with a mean age of 29.51 ± 0.56 years. Employment duration of the exposed workers was 65.39 ± 55.69 months. Control group (unexposed) comprised 106 workers (16% female, 84% male) with a mean age of 30.91 ± 0.78 years. The demographics and smoking data of the two groups are presented in Table 1. A significant correlation was detected between cigarette smoking and phlegm, wheezing and dyspnea (p = 0.005, p = 0.02, p = 0.033 respectively).

ijerph-09-01068-t001_Table 1

The descriptive statistics (Mean ± SD, frequency and percentage) of the exposed workers and control (unexposed) group.

Exposed workers (n = 106) Control (unexposed) group (n = 106) p
Mean age (±SD) 29.51 ± 0.56 30.91 ± 0.78 NS
Number of females 25 (23.6%) 17 (16.0%) NS
Number of males 81 (76.4%) 89 (84.0%) NS
Smoker 54 (50.9%) 52 (49.1%) NS
Non-smoker and ex-smoker 52 (49.1%) 54 (50.9%) NS
Cigarette (per-day) 6.44 ± 0.79 6.71 ± 0.84 NS
Employment duration (months) 65.39 ± 55.69 75.53 ± 73.63 NS

NS: Not significant, p > 0.05.

 3.2. Respiratory Symptoms

Respiratory symptoms among the workers and control group are presented in Table 2.

Among the exposed workers 36.8% reported having phlegm. Other respiratory symptoms were 34% atopy, 27.4% wheezing, 25.5% cough and 14.2% dyspnea. These symptoms were not significantly different between the exposed workers and the control (unexposed) group. Comparison of exposed workers employment duration means by phlegm and atopy are presented in Table 3.

ijerph-09-01068-t002_Table 2

Respiratory symptoms among the exposed workers and the control (unexposed) group.

Exposed workers n (%) Control (unexposed) group n (%) p
Cough 27 (25.5) 23 (21.7) NS
Wheezing 29 (27.4) 28 (26.4) NS
Dyspnea 15 (14.2) 16 (15.1) NS
Phlegm 39 (36.8) 41 (38.7) NS
Atopy 36 (34.0) 39 (36.8) NS

NS: Not significant, p > 0.05.

 ijerph-09-01068-t003_Table 3

Comparison of employment duration means by phlegm and atopy.

Exposed workers Exposed workers Employment duration (month, Mean ± SD) p
Phlegm (+) 76.28 ± 58.02 p = 0.027
Phlegm (−) 66.93 ± 69.36
Atopy (+) 83.04 ± 73.71 p = 0.019
Atopy (−) 63.57 ± 59.41
Cough (+) 65.78 ± 50.80 NS
Cough (−) 65.26 ± 57.58 NS
Wheezing (+) 71.24 ± 73.46 NS
Wheezing (−) 63.19 ± 47.75 NS
Dyspnea (+) 75.90 ± 67.88 NS
Dyspnea (−) 63.66 ± 53.68 NS

NS: Not significant, p > 0.05.

When the employment duration of the exposed workers with and without phlegm is compared, there was statistically significantly difference; the employment duration of the exposed workers with phlegm was longer than those without phlegm (p = 0.027). The duration of employment of those with atopy was found to be longer than those without (p = 0.019). Diagnosis of pulmonary diseases was put by only history taking in exposed workers and control group.

Pulmonary diseases (tuberculosis, asthma, bronchitis) among the exposed workers and control group are presented in Table 4.

ijerph-09-01068-t004_Table 4

Tuberculosis, asthma, bronchitis among the exposed workers and control (unexposed) group.

Exposed workers (n = 10) Control (unexposed) group (n = 7)
Tuberculosis 1 -
Asthma 1 1
Bronchitis 8 6

PFTs were performed on 106 exposed workers and 106 (unexposed) controls. The results of PFTs of the exposed workers and the control (unexposed) group are presented in Table 5.

ijerph-09-01068-t005_Table 5

The descriptive statistics (including Mean ± SD) and the significance levels of PFTs of the exposed workers and the control (unexposed) group.

PFT Exposed workers Actual value Control (unexposed) group Actual value p
FEV1 (L/sc) 3.68 ± 0.73 3.76 ± 0.55 NS
(96.16 ± 11.75) * (98.43 ± 11.69) *
FVC (L) 4.31 ± 0.89 4.30 ± 0.64 NS
(95.82 ± 12.61) * (96.28 ± 12.52) *
FEV1/FVC (%) 85.15 ± 5.94 85.84 ± 10.31 NS
(104.13 ± 7.43) * (106.09 ± 8.02) *
PEF (L/sc) 7.29 ± 1.78 7.69 ± 1.60 NS
(80.34 ± 13.97) * (84.52 ± 16.30) *
FEF25–75 (L/sc) 4.21 ± 1.13 4.46 ± 0.97 p = 0.01
(88.99 ± 19.41) * (96.31 ± 21.16) *

* Predict values %. NS: Not significant, p > 0.05.

 3.3. Pulmonary Function Test

The mean % predicted of FEF25–75 of the exposed workers was found to be significantly lower than the control (unexposed) group (p = 0.01).

4. Discussion

In our study, symptoms were not significantly different between the exposed workers and the control (unexposed) group. Employment duration was higher in exposed workers with phlegm and atopy. The mean % predicted of FEF25–75 of the exposed workers was found to be significantly lower than the control (unexposed) group. Exposure to dyes may be a potential health hazard. Reactive dyes are common causative agents for respiratory symptoms among dyehouse workers [4].

Workers employed in textile dyeing industries may have developed acute and chronic respiratory symptoms. In a study, prevalences of chronic respiratory symptoms in exposed workers were significantly higher than in control workers [15]. Park et al. reported that 25.2% of reactive-dye exposed workers had work-related lower respiratory symptoms [19]. In a survey which was conducted at 15 textile plants with dyehouses in western Sweden, 162 workers were exposed to reactive dyes and 10 of these (6%) reported work-related respiratory symptoms [4]. In our study, there was no significant difference in respiratory symptoms (cough, wheezing, dyspnea) between the control and study group.

Jiin et al. showed that cough is higher in workers when compared to unexposed workers (29% and 14.8% respectively) [20]. According to Wang et al. symptom incidence at 3 months was 3.6%, for usual with phlegm, and 7% for usual dry cough [21]. High ECH exposure and low ECH exposure were significantly associated with cough plegm, chest tightness and dyspnea [20]. In our study, we also found cough symptoms in a similar ratio. Jiin et al. showed a linear relation between exposure and cough and sputum. In the study, the most common symptom was sputum and that symptom was seen more in the exposed workers [20].

In our study, 36.8% of the exposed workers defined phlegm. Other respiratory symptoms were 34% atopy, 27.4% wheezing, 25.5% cough and 14.2% dyspnea. These symptoms were not significantly different between the exposed workers and the control (unexposed) group in our research. This might be due to the exposed workers and the control (unexposed) group had similar smoking habits, mean age and the employment durations of both two groups were similar and the “healthy workers effect” (a phenomenon observed initially in studies of occupational diseases, whereby workers usually exhibit lower overall death rates than the general population because severely ill and disabled people are typically excluded from employment).

Raza et al. have suggested that morbidity among textile workers is due to smoking [22]. Zuskin et al. found that the exposed nonsmoking workers had more complaints than the controls who were nonsmokers, and the respiratory symptoms were exacerbated by cigarette smoking [15]. However, Luo et al. showed that there was no significant relation between small airway abnormalities or obstructive lung abnormalities and smoking status [20]. In our study a significant correlation was detected between cigarette smoking and phlegm, wheezing and dyspnea. We could not analyse the effect of cigarette smoking by excluding other factors, as our study group was small and our study control group had a similar smoking history.

After both short and long term exposures non smoking dyeing workers, primarly women, had significantly greater prevalence of dyspnea than controls [15]. Zuskin et al. reported that there were significantly higher prevalences of all chronic respiratory symptoms compared to the control workers among the male dyeing industry workers, and for the female dyeing workers, the differences were significant for dyspnea, rhinitis, sinusitis [15]. In another study, there were no significant differences in the prevalence of respiratory symptoms between men and women [23]. Females had significantly more complaints of chest tightness and dyspnea [20]. In our study gender results were similar for the study and control groups.

A study by Zuskin et al. showed that in workers exposed for more than 10 years, there were significantly higher prevalences of chronic cough and chronic phlegm in smokers than in nonsmokers [15]. Our finding was that employment duration was higher for exposed workers with phlegm and atopy. We didn’t discuss atopy, as we could not find that symptom in the literature.

According to Pauluhn et al. the predominant dysfunction appeared to be consistent with obstructive rather than restrictive lung diseases [24]. Exposure and the onset of symptoms and objective evidence suggested that these symptoms were related to airflow limitation [2]. Workers demonstrated significant decreases in all ventilatory capacity tests in males and FEF50 and FEF25 for female workers [15]. Twenty-eight of 79 (35.4%) ECH exposed workers had obstructive or small airway lung lesions [20]. FEF25–75 may be used as a marker of initial bronchial damage [25]. In our study, the mean % predicted of FEF25–75 levels was significantly lower in the exposed workers. The Zuskin et al. Study environmental measurements were carried out at work place. Mesurements included fumes and gases, total and respirable dust samples [15,22].

5. Conclusions

To the best of our knowledge, this is the first study in our country (Turkey) which evaluates respiratory symptoms and PFTs of exposed workers who work in textile dyeing factories. Our study suggests that textile dyeing might cause some respiratory symptoms in exposed workers. It seems clear that exposure to reactive dyes should be considered a potential health hazard.

Acknowledgements

The authors like to thank instructor Tamer Sarı and instructor Devrim Höl for their excellent language assistance.

 References Park H.W. Kim D.I. Sohn S.W. Park C.H. Kim S.S. Chang Y.S. Min K.U. Kim Y.Y. Cho S.H. Outcomes in occupational asthma caused by reactive dye after long-term avoidance. Clin. Exp. Alergy 2007 37 225 230 10.1111/j.1365-2222.2007.02641.x Nakano Y. Tsuchiya T. Hirose K. Chida K. Occupational asthma caused by pyrazolone derivate used in silver halide photograhic paper. Chest 2000 118 246 248 10.1378/chest.118.1.24610893388 Romano C. Sulotto F. Pavan I. Chiesa A. Scansetti G. A new case of occupational asthma from reactive dyes with severe anaphylactic response to the specific challenge. Am. J. Ind. Med. 1992 21 209 216 10.1002/ajim.47002102101536155 Nilsson R. Nordlinder R. Wass U. Meding B. Belin L. Asthma, rhinitis, and dermatitis in workers exposed to reactive dyes. Br. J. Ind. Med. 1993 50 65 70 8431393 Docker A. Wattie J.M. Topping M.D. Luczynska C.M. Taylor A.J. Pickering C.A. Thomas P. Gompertz D. Clinical and immunological investigations of respiratory disease in workers using reactive dyes. Br. J. Ind. Med. 1987 44 534 541 3651352 Beck G.J. Schachter E.N. Maunder L.T. Schilling R.S.F. A prospective study of chronic lung disease in cotton textile workers. Ann. Intern. Med. 1982 97 645 651 7137730 Witek T.J. Mazzara C.A. Zuskin E. Beck G.J. Buck M.G. Schachter E.N. Bronchial responsiveness after inhalation of cotton bract extract. Am. Rev. Respir. Dis. 1988 138 1579 1583 3059900 Zuskin E. Ivankovic D. Schachter E.N. Witek T.J. A ten year follow-up study of cotton textile workers. Am. Rev. Respir. Dis. 1991 143 301 305 1990943 Zuskin E. Kanceljak B. Schachter E.N. Witek T.J. Muatabegovic J. Maayani S. Buck M.G. Rienzi N. Immunological and respiratory function in cotton textile workers. Int. Arch. Occup. Environ. Health 1992 46 31 37 Bouhuys A. Zuskin E. Chronic respiratory disease in hemp workers. A follow-up study 1967-1974. Ann. Intern. Med. 1976 84 398 405 1259285 Zuskin E. Kanceljak B. Pokrajac D. Schachter E.N. Witek T.J. Respiratory symptoms and lung function in hemp workers. Br. J. Ind. Med. 1990 47 627 632 2207034 Valic F. Zuskin E. Effects of different vegetable dust exposure. Br. J. Ind. Med. 1972 29 293 297 5044600 Zuskin E. Valic F. Bouhuys A. Effect of wool dust on respiratory function. Am. Rev. Respir. Dis. 1976 114 705 709 989708 Love R.G. Smith T.A. Gurr D. Soutar C.A. Scarisbbrick D.A. Seaton A. Respiratory and allergic symptoms in wool textile workers. Br. J. Ind. Med. 1988 45 727 741 3264511 Zuskin E. Mustajbegovic J. Schachter E.N. Doko-Jelinic J. Respiratory function of textile workers employed in dyeing cotton and wool fibers. Am. J. Ind. Med. 1997 31 344 352 10.1002/(SICI)1097-0274(199703)31:3<344::AID-AJIM11>3.0.CO;2-09055958 Viegi G. Fazzi P. Giuliano G. Begliomini E. Pistelli G. Pulmonary function in chemical workers. G. Ital. Med. Lav. 1985 7 127 131 3836916 Ferris B.G. Epidemiology standardization project (American thoracic society). Am. Rev. Respir. Dis. 1978 118 1 120 742764 Standardization of Spirometry, 1994 Update. American thoracic society. Am. J. Respir. Crit. Care Med. 1995 152 1107 1136 7663792 Park M.S. Lee M.K. Kim B.O. Lee K.J. Roh J.M. Clinical and immunologic evaluations of reactive dye-exposed workers. J. Allergy Clin. Immunol. 1991 87 639 649 10.1016/0091-6749(91)90382-X2005316 Luo J.C. Kuo H.W. Cheng T.J. Chang M.J. Pulmonary function abnormality and respiratory tract irritation symptoms in epichlorohydrin-exposed workers in Taiwan. Am. J. Ind. Med. 2003 43 440 446 10.1002/ajim.1017712645100 Wang X.R. Pan L.D. Zhang H.X. Sun B.X. Dai H.L. Christiani D.C. Follow-up study of study of respiratory health of newly-hired female cotton textile workers. Am. J. Ind. Med. 2002 41 111 118 10.1002/ajim.1004211813216 Raza S.N. Fletcher A.M. Pickering A.C. Niven R.M. Faragher E. Ventilatory function and personal breathing zone dust concentratios in Lancashire textile wearvers. Occup. Environ. Med. 1999 56 520 526 10.1136/oem.56.8.52010492648 Talini D. Montaverdi A. Benvenuti A. Petrozzini M. di Pede F. Lemmi M. Carletti A. Macchioni P. Serretti N. Viegi G. Asthma-like symptoms, atopy, and bronchial responsiveness in furniture workers. Occup. Environ. Med. 1998 55 786 791 10.1136/oem.55.11.786 Pauluhn J. Repeated pulmonary function measurements in rats after intratracheal instillation of a polyamine textile pigment component. Inhal. Toxicol. 2000 12 591 604 10.1080/0895837005003096710880146 Lipworth B.J. Clark D.J. Effects of airway calibre on lung delivery of nebulised salbutamol. Thorax 1997 52 1036 1039 10.1136/thx.52.12.10369516895