molecules Molecules Molecules Molecules 1420-3049 MDPI 10.3390/molecules171213989 molecules-17-13989 Article Synthesis and Insecticidal Activity of an Oxabicyclolactone and Novel Pyrethroids de Alvarenga Elson S. 1 * Carneiro Vânia M. T. 2 Resende Gabriela C. 2 Picanço Marcelo C. 2 Farias Elizeu de Sá 2 Lopes Mayara Cristina 2 Department of Chemistry, Federal University of Vicosa, Av. P. H. Rolfs, s/n, 36570-000, Vicosa, MG, Brazil Department of Animal Biology Animal, Federal University of Vicosa, Av. P. H. Rolfs, s/n, 36570-000, Vicosa, MG, Brazil Author to whom correspondence should be addressed; Email: elson@ufv.br; Tel.: +55-31-3899-2304. 26 11 2012 12 2012 17 12 13989 14001 18 10 2012 13 11 2012 16 11 2012 © 2012 by the authors; licensee MDPI, Basel, Switzerland. 2012

This article is an open-access article distributed under the terms and conditions of the Creative Commons Attribution license (http://creativecommons.org/licenses/by/3.0/).

Deltamethrin, a member of the pyrethroids, one of the safest classes of pesticides, is among some of the most popular and widely used insecticides in the World. Our objective was to synthesize an oxabicyclolactone 6 and five novel pyrethroids 8–12 from readily available furfural and D-mannitol, respectively, and evaluate their biological activity against four insect species of economic importance namely A. obtectus, S. zeamais, A. monuste orseis, and P. americana. A concise and novel synthesis of 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one (6) from furfural is described. Photochemical addition of isopropyl alcohol to furan-2(5H)-one afforded 4-(1'-hydroxy-1'-methylethyl)tetrahydro-furan-2-one (3). The alcohol 3 was directly converted into 4-(1'-bromo-1'-methylethyl)-tetrahydrofuran-2-one (5) in 50% yield by reaction with PBr3 and SiO2. The final step was performed by cyclization of 5 with potassium tert-butoxide in 40% yield. The novel pyrethroids 8–12 were prepared from methyl (1S,3S)-3-formyl-2,2-dimethylcyclopropane-1-carboxylate (7a) by reaction with five different aromatic phosphorous ylides. Compounds 6–12 presented high insecticidal activity, with 6 and 11 being the most active. Compound 6 killed 90% of S. zeamais and 100% of all the other insects evaluated. Compound 11 killed 100% of all insects tested.

 oxabicyclo photochemistry furfural insecticide pyrethroid 1. Introduction

The term pyrethroid is used to designate synthetic insecticides derived structurally from the pyrethrins. Decades of research done by the agrochemical industry, government, and academic laboratories have resulted in a wide range of new pyrethroids and in a multiplicity of uses in agriculture, veterinary medicine and control of domestic pests. Few classes of biologically active compounds have such great potential for structural variation with retention or enhancement of potency [1,2]. Deltamethrin, a member of one of the safest classes of pesticides, is among some of the most popular and widely used insecticides in the World. This pyrethroid, which is derived from (1R, 3S)-cis-chrysanthemic acid (Figure 1), was first prepared by Elliott and Janes [3].

Structure of the (1R, 3S)-cis-chrysanthemic acid.

Pyrethroid insecticides have been used for more than 40 years and are sold as mixtures containing a combination of two or more compounds. Most of the pyrethroids registered for use in the World in a large variety of agricultural products are derived from cis-chrysanthemic acid. The toxicity of DDT urged the development of pyrethroids which rapidly knock down flying insects and have negligible persistence in the environment. Moreover, an important feature of the pyrethroids is that they present low toxicity to mammals and birds [4,5,6,7,8,9].

Because of the utility of the oxabicyclo moiety as a building block for the construction of cis-chrysanthemic acid as well as other natural products and biologically active compounds, there has been much interest in the synthesis of 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one [10,11,12,13,14,15,16,17,18,19,20,21].

The insecticidal activity of eight pyrethroids were evaluated against four insect species of economic importance namely Acanthoscelides obtectus (Say) (Coleoptera: Bruchidae), Sitophilus zeamais Mots. (Coleoptera: Curculionidae), Ascia monuste orseis Latr. (Lepidoptera: Pyralidae), and Periplaneta americana (L.) (Dictyoptera: Blattidae). A. obtectus and S. zeamais are cosmopolitan grain store pests mainly found in bean and maize, respectively. S. zeamais has been causing great damages in several fruit cultures, such as apple, peach trees, and grapevines in the South of Brazil [22,23]. The kale leaf worm, A. monuste orseis, is a key pest of Brassicaceae (kale, cabbage, cauliflower, broccolis, mustard and radish), mainly in subtropical and tropical regions [24]. The cockroach, P. americana, is a domestic pest in tropical countries. Cockroaches are urban pests of major importance because of their appearance in household products and the transmission of diseases. They are a common pest of restaurants, bakeries, grocery stores, etc. In this paper we describe a novel synthetic route to the 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one from the readily available furfural in four steps. Five novel pyrethroids have been prepared also from D-mannitol and biological assays of the synthesized compounds were conducted with A. obtectus, adults of S. zeamais, second-instar larvae of A. monuste orseis, and second-instar nymph of P. americana.

 2. Results and Discussion 2.1. Synthesis

The butenolide furan-2(5H)-one (2) was obtained by performic acid oxidation of furfural (1) in the presence of N,N-diethylethanolamine [25]. Irradiation of furan-2(5H)-one in isopropyl alcohol with four low pressure mercury lamps of 15 W each (LPML) afforded the adduct 3 in quantitative yield (Scheme 1). The excited butenolide 2 abstracts a hydrogen from the isopropyl alcohol and the alcohol radical adds to the double bond β to the carbonyl of the butenolide (1,4-addition) to afford the alcohol 3 [26].

molecules-17-13989-scheme1_Scheme 1

Synthesis of 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one (6).

Dehydration of the alcohol 3 with PCl5 in anhydrous DCM was carried out in 90% yield. The isomeric alkenes 4a and 4b were not fully separated from each other by flash column chromatography. Only a small fraction of each isomer was obtained for the spectrometric identification and insecticidal evaluation. The mixture of the alkenes containing the major isomer 4a (as estimated by 1H-NMR spectroscopy) was used in the next step of the synthesis.

Addition of HBr to the double bond of alkenes 4a and 4b afforded only 4-(1'-bromo-1'-methylethyl)tetrahydrofuran-2-one (5) in 39% yield. The reaction was carried out with PBr3/SiO2 in DCM, which was adapted from the methodology described for other compounds by Sanseverino and Mattos [27]. This methodology has the advantage of avoiding the need of drying chemicals, rigorous exclusion of moisture, light, and oxygen from the reaction media, and generation of dry HBr.

Trying to optimize the synthesis we envisaged a direct conversion of the alcohol 3 into the bromide withough having to prepare the alkenes, therefore avoiding one step. The alcohol 3 was thus treated with PBr3 and SiO2 in DCM to afford 4-(1'-bromo-1'-methylethyl)tetrahydrofuran-2-one (5a) in 50% yield. In addition to saving one step, the yield was increased by 15% in comparison with the dehydration followed by addition of HBr (35% yield for the two steps).

Treatment of compound 5 with potassium tert-butoxide in anhydrous THF gave 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one (6), in 40% yield. The strong base removed the α-proton to the carbonyl group to form a stabilized carbanion. The positively charged carbon (formed after displacement of the bromine) is attacked by the negative carbon (stabilized carbanion) to afford the oxabicyclo compound 6. The mechanism of nucleophilic substitution unimolecular is favored in this reaction by formation of the relatively stable tertiary carbocation.

The carbonyl from the lactone is characterized by the intense band in 1774 cm−1 in the infra-red and by the signal in 175.3 ppm in the 13C-NMR spectrum. The complete assignment of the signals in the NMR spectra was carried out with the aid of COSY and HETCOR. All the other data from infra-red, mass and NMR spectroscopies add up confirming the structure of the oxabicyclo.

The preparation of novel pyrethroid methyl esters from the readily available D-mannitol is depicted in Scheme 2. The convertion of D-mannitol to aldehyde (7) is described in the literature [4].

molecules-17-13989-scheme2_Scheme 2

Synthesis of pyrethroids 8–12 from D-mannitol.

Five different phosphorus ylides were employed to prepare ten novel pyrethroids 8–12 from aldehyde 7 in yields which varied from 45 to 65% (Table 1).

molecules-17-13989-t001_Table 1

Synthesis of the pyrethroids 8–12 from 7: reaction conditions and yields.

Pyrethroids Wittig salt R1 R2 Proportion Yield (%)
Z : E
8a o-MeOPhCH2PPh3+Cl− -H o-CH3OPh 1 : 1 46
8b o-CH3OPh -H
9a m-MeOPhCH2PPh3+Cl− -H m-CH3OPh 1 : 1 45
9b m-CH3OPh -H
10a o-ClPhCH2PPh3+Br− -H o-ClPh 2 : 1 64
10b o-ClPh -H
11a F5PhCH2PPh3+Br− -H F5Ph 1 : 1 50
11b F5Ph -H
12a * p-EtOPhCH2PPh3+Cl− -H p-(CH3CH2O)Ph 1 : 1 65
12b p-(CH3CH2O)Ph -H

* (4-Ethoxybenzyl)triphenylphosphonium chloride 9g was acquired from Sigma-Aldrich.

The close retention factors of the diastereomeric pyrethroids hampered their separation by flash column chromatography. The alkenes were characterized by FTIR, NMR, and mass spectrometry as a mixture of isomers. Microanalytical data of oils are usually unsatisfactory thus the assessments of the purity of the oily pyrethroids were carried out by TLC and high field NMR.

 2.2. Bioassay

Table 2 presents the biological assays of compounds 6–12, permethrin and the control sample (acetone) for A. obtectus, S. zeamais, A. monuste orseis, and P. americana. All evaluated substances showed insecticidal activity against the four species of pests since they caused significant mortality (p < 0.05), higher than the control (acetone). When the substances are compared with the standard of efficiency (permethrin) we found that all substances caused high mortality to A. obtectus (mean 97.5% 24 h after application).

Substances 6 and 8–12 presented high mortality to S. zeamais (mean 95.42% 24 h after application) and larvae of A. monuste (mean 97.08% 24 h after application). Moderate activity for substances 7a (45.00% mortality) and 7b (42.50% mortality) and high activity for all the other substances were observed after 12 h of treatment against S. zeamais. Mortality reached 100% after 24 h for compounds 11 and 12.

Compounds 6, 10 and 11 caused 100% mortality after 12 h against A. monuste orseis. After 24 h, compounds 8, 9 and 12 also presented similar activity (92.50% and 95.00%) to the commercial pyrethroid. Compounds 6, 8, 9 and 11 presented high toxicity 12 h after application against P. Americana (mean 95.42% 24 h after application), pointing to a rapid mechanism of action similar to that of permethrin. Only compounds 7a and 7b presented an increase in toxicity from 12 h (79.33% and 67.00%) to 24 h (96.00% and 71.00%) respectively.

Compounds 6 and 11 were the most active against the insect species evaluated and presented almost complete mortality even after 12 hours of application. We observed that all the substances, except 8, 9 and 12, showed fast insecticidal action, as the highest amount of insects deaths occurred 12 h after application. Substances 8, 9 and 12 presented the highest activity against A. monuste only after 24 h.

molecules-17-13989-t002_Table 2

Contact toxicity of the synthetic compounds at concentration of 5 μg (P. americana), 10 µg (A. monuste) and 50 μg (A. obtectus and S. zeamais) of compound per mg of insect.

Treatment (compound) Mean percent mortality *
A. obtectus S. zeamais A. monuste orseis P. americana
12 h 24 h 12 h 24 h 12 h 24 h 12 h 24 h
Permethrin # 100.0 aA 100.0 aA 85.5 bA 90.0 aA 100.0 aA 100.0 aA 87.5 bA 97.5 aA
6 100.0 aA 100.0 aA 85.00 aA 90.00 aA 100.00 aA 100.00 aA 100.00 aA 100.00 aA
7a 100.0 aA 100.0 aA 45.00 bB 47.50 bB 27.50 cD 47.50 bC 79.33 aABC 96.00 aAB
7b 90.00 aA 97.50 aA 42.50 cB 45.00 cB 50.00 cC 67.50 bB 67.00 bC 71.00 aCD
8 87.50 aA 95.00 aA 95.00 aA 95.00 aA 62.50 bBC 95.00 aA 100.00 aA 100.00 aA
9 82.50 aA 92.50 aA 92.50 aA 97.50 aA 75.00 aB 95.00 aA 92.00 aAB 92.00 aABC
10 97.50 aA 97.50 aA 82.50 aA 90.00 aA 100.00 aA 100.00 aA 67.00 bC 67.00 bD
11 100.0 aA 100.0 aA 97.50 aA 100.00 aA 100.00 aA 100.00 aA 100.00 aA 100.00 aA
12 97.50 aA 97.50 aA 97.50 aA 100.00 aA 75.00 aB 92.50 aA 75.00 aBC 75.00 aBCD
Control § 0.00 aB 3.33 aB 0.00 aC 3.33 aC 11.67 aD 13.33 aD 4.00 aD 6.00 aE

* Means followed by the same lower-case letter in a row or by the same upper-case letter in a column are not significantly different by the Tukey test at p > 0.05. § Only ketone was used in the control. # Commercial insecticide.

Therefore, the substances 6, 8, 9 and 11 have a potential use in controlling pests of stored products (A. obtectus and Sitophilus zeamais), caterpillars (A. monuste) and cockroaches (P. americana). These results are promising since the discovery of new substances with insecticidal action is an alternative to be used in pest management to avoid selection of resistant populations to insecticides as with P. americana [28] and S. zeamais [29].

Moreover, as these substances present fast insecticide action they present potential use in pest control when infestations are high. Herbivores such as A. obtectus, A. monuste, and S. zeamais could be controlled before they cause damage to plants, or household pests (cockroaches) before they transmit diseases to humans [30,31].

 3. Experimental 3.1. General Procedures

DCM and THF were dried as described in the literature [32]. The melting points were determined on an Electrothermal digital (MQAPF-301) apparatus without correction. Infrared spectra were recorded on a Perkin Elmer Paragon 1000 FTIR grating spectrophotometer using potassium bromide disks and scanning from 4000 to 625 cm−1. 1H- and 13C-NMR spectra were recorded in a Varian Mercury (300 MHz) spectrometer. Tetramethylsilane (SiMe4) was used as internal standard (δ = 0). GC-MS was conducted with a Shimadzu QP5050A spectrometer, using a glass capillary column (25 m × 0.25 mm) DB-1. The elementary analysis was carried out in a Perkin Elmer 2400 instument. The reactions were monitored by thin layer chromatography (TLC) using plates coated with 60GF254 silica-gel (POLYGRAM-UV254 0.25 mm MACHEREY—NAGEL).

 3.2. Synthetic Procedures

4-(1'-Hydroxy-1'-methylethyl)tetrahydrofuran-2-one (3). A solution of furan-2(5H)-one (4.5 g; 53.52 mmol) in isopropyl alcohol (100 mL) was degassed in a quartz tube by a steady flow of nitrogen for 1 h. The tube was stoppered and irradiated for 12 h under four low pressure mercury lamps (4 × 15 W). The solvent was removed under reduced pressure and the residue purified by column chromatography (hexane-ethyl acetate, 1:2 v/v) to afford 3 (7.7 g; 53.52 mmol) in 100% yield as a yellowish oil. TLC: Rf = 0.52 (hexane-ethyl acetate, 1:2 v/v); IR (, cm−1): 3426, 2978, 2928, 1774, 1378, 1186, 1016, 956, 850. 1H-NMR (CDCl3) δ (m, l, J (Hz), atrib.): 1.28 (m, 6H, 2 × CH3), 2.61 (m, 3H, H3, H3' and H4), 2.8 (s, 1H, OH), 4.4 (m, 2H, H5 and H5'); 13C-NMR (CDCl3): δ 27.9 (CH3), 28.3 (CH3), 30.1 (C3), 46.1 (C4), 69.7 (C5), 70.0 (C-OH), 178.0 (C=O); MS, m/z (100%): [M•+] 144 (1.43), 126 (3.40), 111 (3.60), 85 (56.39), 59 (100.00).

4-Isopropenyltetrahydrofuran-2-one (4a) and 4-(1-methylethylidene)tetrahydrofuran-2-one (4b). A suspension of PCl5 (20 g; 95.92 mmol) in anhydrous DCM (25 mL) was added to an ice cooled solution of 3 (7 g; 48.61 mmol) in anhydrous DCM (40 mL). The reaction mixture was stirred for 5 min, quenched with distilled water (150 mL), the organic phase separated, and the aqueous layer extracted with DCM (3 × 50 mL). The combined organic phases was washed with brine (3 × 25 mL), dried with anhydrous magnesium sulfate, filtered, and concentrated under reduced pressure. Flash column chromatography (hexane:ethyl acetate, 1:1 v/v) of the residue gave a mixture of the isomers (4a) and (4b) in 90% yield (5.5 g). Compound 4a: TLC: Rf = 0.65 (hexane-ethyl acetate, 1:1 v/v); IR (KBr, , cm−1): 3083, 2975, 2916, 1794, 1650, 1179, 1021, 900; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.73 (s, 3H, CH3), 2.43 (dd, 1H, Jgem = 17.1, J3–4 = 8.5, H3), 2.62 (dd, 1H, Jgem = 17.1 and J3'-4 = 8.5, H3), 3.15 (m, 1H, H4), 4.07 (dd, 1H, Jgem = 8.8 and J5–4 = 7.8, H5), 4.42 (dd, 1H, Jgem = 8.8 and J5'-4 = 7.8, H5'), 4.85 (m, 2H, =CH2); 13C-NMR (CDCl3): δ 20.5 (CH3), 33.2 (C3), 42.5 (C4), 71.9 (C5), 112.4 (=CH2), 176.9 (C=O); MS, m/z (100%): [M•+] 126 (12.36), 125 (28.86), 95 (22.98), 68 (88.19), 67 (100.00), 59 (34.65). Compound 4b: TLC: Rf = 0.68 (hexane-ethyl acetate, 1:1 v/v); IR (, cm−1): 2974, 2912, 1784, 1650, 1362, 1180, 1025, 847, 558; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.60 (m, 3H, CH3), 1.68 (m, 3H, CH3'), 3.13 (m, 2H, H3 e H3'), 4.83 (m, 2H, H5 and H5'); 13C-NMR (CDCl3): δ 19.6 (CH3), 21.6 (CH3'), 32.4 (C3), 71.6 (C5), 121.8 (C4), 126.8 (C6), 176.7 (C=O).

4-(1'-Bromo-1'-methylethyl)tetrahydrofuran-2-one (5) from the mixture of 4a and 4b. A solution of PBr3 (1.6 mL, 17.02 mmol) in DCM (10 mL) was added dropwise to a suspension of SiO2 (15 g) in DCM (50 mL) containing the isomers 4a and 4b (5.5 g; 43.65 mmol). The mixture was stirred for 1 h, filtered under vacuum and the SiO2 washed with DCM (30 mL). The filtrate was washed with NaHCO3 10% (2 × 20 mL) and brine (2 × 20 mL). The organic phase was dried with MgSO4, filtered, concentrated under reduced pressure and the residue purified by flash column chromatography (hexane:ethyl acetate, 1:1 v/v) to afford 5 (3.5 g; 17.02 mmol) in 39% yield as a white solid. TLC: Rf = 0.52 (hexane-ethyl acetate, 1:1 v/v); IR (, cm−1): 2973, 2917, 1779, 1373, 1175, 1115, 1027, 629; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.75 (m, 6H, 2 × CH3), 2.64 (m, 3H, H3, H3' and H4), 4.29 (m, 1H, H5), 4.45 (m, 1H, H5'); 13C-NMR (CDCl3): δ 31.9 (C3), 32.1 (CH3), 32.4 (CH3), 48.3 (C4), 66.6 (C-Br), 70.6 (C5), 175.8 (C=O); MS, m/z (100%): [M•++ 2] 209 (1.63), [M•+] 207 (1.67), 126 (17.59), 111 (60.31), 83 (100.00), 68 (54.27).

4-(1'-Bromo-1'-methylethyl)tetrahydrofuran-2-one (5) from 4-(1′-hydroxy-1′-methylethyl)tetrahydrofuran-2-one (3). A solution of PBr3 (2.0 mL; 21.28 mmol) in DCM (10 mL) was added dropwise to a solution of 3 (7.00 g; 48.61 mmol), and pyridine (4.0 mmL; 49.56 mmol) in DCM (25 mL). The reaction mixture was stirred for 1 h, and a further dropwise addition of PBr3 (2.0 mL; 21.28) in DCM (10 mL) was performed. After addition of SiO2 (15 g), the mixture was stirred for a further 40 min. The reaction mixture was filtered under vacuum and the silica was washed with DCM (30 mL). The filtrate was washed with NaHCO3 10% (2 × 20 mL) and brine (2 × 20 mL). The organic phase was dried with MgSO4, filtered, concentrated under reduced pressure and the residue purified by flash column chromatography (hexane:ethyl acetate, 1:1 v/v) to afford 5 (5.03 g; 24.3 mmol) in 50% yield as a white solid. TLC: Rf = 0.52 (hexane-ethyl acetate, 1:1 v/v); IR (, cm−1): 2973, 2917, 1779, 1373, 1175, 1115, 1027, 629; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.75 (m, 6H, 2 × CH3), 2.64 (m, 3H, H3, H3' e H4), 4.29 (m, 1H, H5), 4.45 (m, 1H, H5'); 13C-NMR (CDCl3): δ 31.8 (C3), 32.0 (CH3), 32.3 (CH3), 48.2 (C4), 66.5 (C-Br), 70.5 (C5), 175.7 (C=O); MS, m/z (100%): [M•++ 2] 209 (1.63), [M•+] 207 (1.67), 126 (17.59), 111 (60.31), 83(100.00), 68 (54.27).

6,6-Dimethyl-3-oxabicyclo[3.1.0]hexan-2-one (6). A solution of 5 (2.00 g; 9.66 mmol) in anhydrous THF (20 mL) was added dropwise to an ice cooled suspension of potassium tert-butoxide (2.20 g; 19.64 mmol) in anhydrous THF (30 mL). The reaction mixture was stirred for 5 min, quenched with NH4Cl (30 mL) and extracted with DCM (3 × 50 mL). The combined organic phases was dried with anhydrous MgSO4, filtered and concentrated under reduced pressure. The residue was purified by flash column chromatography (hexane:ethyl acetate, 1:1 v/v) to afford 6 (0.4870 g; 3.87 mmol) in 40% yield as a colorless oil. TLC: Rf = 0.52 (hexane-ethyl acetate , 1:1 v/v); IR (, cm−1): 3068, 2961, 2909, 1774, 1368, 1186, 1046, 975, 892; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.10 (s, 6H, 2 × CH3), 1.88 (dd, 1H, J3-4 = 6.3 e J3–5’ = 0.9, H3), 2.01 (ddd, 1H, J3–4 = 6.3, J4-5 = 5.2 e J4–5' = 1.2, H4), 4.10 (dt, 1H, Jgem = 9.9, J3–5' = 0.9 e J4–5' = 1.2, H5’), 4.31 (dd, 1H, Jgem = 9.9 and J4–5 = 5.2, H5); 13C-NMR (CDCl3): δ 14.6 (CH3), 23.3 [C(CH3)2], 25.4 (CH3), 30.3 (C4), 30.7 (C3), 66.8 (C5), 175.3 (C=O). MS, m/z (100%): [M•+] 126 (3.67), 125 (9.74), 111 (18.33), 97 (25.60), 85 (28.50), 83 (31.98), 71 (53.30), 69 (47.64), 57 (100.00), 55 (67.45).

 3.3. General Method to Preparation of Alkenes <italic><bold>8</bold></italic> to <italic><bold>12</bold></italic>

To a suspension of the Wittig salt (3.53 mmol) in dry THF (5 mL) under nitrogen at 0 °C n-butyl lithium was added (2.0 M in hexane, 1,8 mL ; 3.60 mmol). The reaction mixture was stirred for 20 min, and the aldehyde (7) (0.50 g; 3.20 mmol) in dry THF (5 mL) was added. After 30 min at 0 °C, the cooling bath was removed and the mixture was stirred for 3 h. The reaction was quenched with saturated aqueous ammonium chloride (10 mL), the THF was evaporated under reduced pressure and the aqueous residue was extracted with diethyl ether (5 × 10 mL). The combined organic layers was dried with anhydrous magnesium sulfate, filtered and concentrated in the rotary evaporator to give a yellow oil. The oil was purified by flash column chromatography (hexane:ethyl ether, 9:1 v/v). This procedure was used for the preparation of the compounds 8 to 12. The quantity of Wittig salts and yield for each reaction are shown in Table 1.

Mixture of isomers (Z)-(8a) and (E)-(8b) of methyl (1S,3S)-3-[2-(2-methoxyphenyl)ethen-1-yl]-2,2-dimethylcyclopropane-1-carboxylate. TLC: Rf = 0.45 (hexane-diethyl ether, 9:1 v/v); Specific rotation: [α]D20= −84.4° (c = 1.60, acetone); IR (, cm−1): 2950, 1724, 1598, 1438, 1244, 1167, 1029, 752; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.20 (s, 6H, 2 × CH3), 1.25 (s, 3H, CH3), 1.30 (s, 3H, CH3), 1.57 (d, 1H, J1-3cis = 5.4, H1cis), 1.69 (d, 1H, J1-3trans = 5.4, H1trans), 2.26 (dd, 1H, J1-3trans = 5.4 e J3-4trans = 8.7, H3trans), 2.34 (dd, 1H, J1-3 cis = 5.4 e J3-4 cis = 9.0, H3cis), 3.65 (s, 3H, OCH3), 3.70 (s, 3H, OCH3), 3.83 (s, 3H, CH3O-Ar), 3.83 (s, 6H, CH3O-Ar), 5.45 (dd, 1H, J3-4cis = 9.0 e J4-5cis = 11.5, H4cis), 5.96 (dd, 1H, J3-4trans = 8.7 e J4-5trans = 15.9, H4trans), 6.68 (d, 1H, J4-5cis = 11.5, H5cis), 6.92 (m, 5H, H5trans, H3' e H5'), 7.30 (m, 4H, H4' e H6'); 13C-NMR (CDCl3): δ 20.4 (CH3), 20.7 (CH3), 22.4 (CH3), 22.5 (CH3), 29.7 [C(CH3)2], 28.8 [C(CH3)2], 33.7 (C3cis), 34.6 (C1trans), 35.7 (C1cis), 37.6 (C3trans), 51.7 (OCH3), 51.8 (OCH3), 55.7 (CH3OAr), 55.8 (CH3OAr), 110.5–130.2 (C4, C5 e Ar), 156.5 (C2'), 157.1 (C2'), 172.5 (C=O), 172.7 (C=O); MS, m/z (100%): [M•+] 260 (35.02), 201 (100.00), 185 (46.55), 121 (56.32), 91 (95.16), 77 (57.62), 41 (73.00).

Mixture of isomers (Z)-(9a) and (E)-(9b) of methyl (1S,3S)-3-[2-(3-methoxyphenyl)ethen-1-yl]-2,2-dimethylcyclopropane-1-carboxylate. TLC: Rf = 0.45 (hexane-diethyl ether, 9:1 v/v); Specific rotation: [α]D20= −80.9° (c = 1.10, acetone); IR (, cm−1): 2948, 1728, 1438, 1219, 767, 751; 1H-NMR (CDCl3) δ (m, l, J (Hz), atrib.): 1.24 (s, 6H, CH3 cis), 1.26 (s, 3H, CH3 trans), 1.28 (s, 6H, CH3 cis), 1.34 (s, 3H, CH3 trans), 1.60 (d, 2H, J1-3cis = 5.7, H1cis), 1.73 (d, 1H, J1-3trans = 5.7, H1trans), 2.27 (m, 3H, H3cis e H3trans), 3.67 (s, 6H, OCH3 cis), 3.71 (s, 3H, OCH3 trans), 5.55 (dd, 2H, J3-4cis = 9.0 e J4-5cis = 11.4, H4cis), 5.97 (dd, 1H, J3-4trans = 9.0 e J4-5trans= 15.9, H4trans), 6.67 (d, 2H, J4-5cis = 11,4, H5cis), 6.95 (d, 1H, J4-5trans = 15.9, H5trans), 7.25 (m, 12H, Arcis e Artrans)*; 13C-NMR (CDCl3): δ 20.4 (2 × CH3), 20.6 (CH3), 22.4 (CH3), 29.7 [2 × C(CH3)2], 33.2 (C3cis), 34.8 (C1trans), 35.7 (C1cis), 37.0 (C3trans), 51.8 (2 × OCH3), 126.5–135.3 (C4, C5 e Ar), 172.4 (2 × C=O); MS, m/z (100%): [M•+] 260 (26.10), 201 (61.42), 185 (58.24), 159 (60.84), 115 (77.52), 102 (100.00), 91 (67.98), 77 (68.16), 41 (72.87).

Mixture of isomers (Z)-(10a) and (E)-(10b) of methyl (1S,3S)-3-[2-(2-chlorophenyl)ethen-1-yl]-2,2-dimethylcyclopropane-1-carboxylate. TLC: Rf = 0.55 (hexane-diethyl ether, 9:1 v/v); Specific rotation: [α]D20= −80.6° (c= 1.32, acetone); IR (, cm−1): 2956, 2752, 1738, 1714, 1434, 1237, 1173, 1112, 975; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.20 (s, 6H, 2 × CH3), 1.25 (s, 6H, 2 × CH3) 1.57 (d, 1H, J1-3cis = 5.4, H1cis), 1.67 (d, 1H, J1-3trans = 5.7, H1trans), 2.22 (dd, 1H, J1-3trans = 5.7 e J3-4trans = 8.4, H3trans), 2.45 (dd, 1H, J1-3cis = 5.4 e J3-4cis = 8.7, H3cis), 3.67 (s, 3H, OCH3), 3.69 (s, 3H, OCH3), 3.80 (s, 6H, 2 × CH3O-Ar), 5.40 (dd, 1H, J3-4cis = 8.7 e J4-5cis = 11.7, H4cis), 5.95 (dd, 1H, J3-4trans = 8.4 e J4-5trans = 15.9, H4trans), 6.54 (m, 2H, H5trans e H5cis), 6.90 (m, 6H, H2', H4' e H6'), 7.23 (m, 2H, H5’); 13C-NMR (CDCl3): δ 20.8 (CH3), 21.1 (CH3), 33.4 (C2), 34.3 (C1), 42.2 (C3), 52.2 (OCH3), 170.4 (COOCH3), 199.0 (HC=O); MS, m/z (100%): [M•++2] 266 (6.29), [M•+] 264 (19.09), 207 (28.14), 205 (100.00), 139 (43.93), 125 (84.02), 115 (31.50), 77 (25.86).

Mixture of isomers (Z)-(11a) and (E)-(11b) of methyl (1S,3S)-3-[2-(pentafluorophenyl)ethen-1-yl]-2,2-dimethylcyclopropane-1-carboxylate. TLC: Rf = 0.63 (hexane-diethyl ether, 9:1 v/v); Specific rotation: [α]D20= −74.6° (c = 2.60, acetone); IR (, cm−1): 2952, 1734, 1651, 1521, 1495, 1219, 1171, 1002, 869; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.23 (s, 6H, 2 × CH3), 1.34 (s, 6H, 2 × CH3) 1.65 (d, 1H, J1-3cis = 5.4, H1cis), 1.75 (d, 1H, J1-3trans = 5.4, H1trans), 2.16 (m, 1H, H3cis), 2.23 (m, 1H, H3trans), 3.65 (s, 3H, OCH3), 3.67 (s, 3H, OCH3), 5.75 (dd, 1H, J3-4cis = 9.6 e J4-5cis = 11.1, H4cis), 6.14 (d, 1H, J4-5cis = 11.1, H5cis), 6.27 (dd, 1H, J3-4trans = 9.0 e J4-5trans = 16.2, H4trans), 6.46 (d, 1H, J4-5trans = 16.2, H5trans); 13C-NMR (CDCl3): δ 20.5 (2 × CH3), 22.3 (CH3), 22.5 (CH3), 29.8 [C(CH3)2], 30.0 [C(CH3)2], 34.1 (C3cis), 34.2 (C1trans), 35.7 (C1cis), 37.7 (C3trans), 51.9 (OCH3), 52.0 (OCH3), 114.7 (C5cis), 115.8 (C5trans), 137.4 (C4cis e C4trans), 172.0 (2 × C=O); MS, m/z (100%): [M•+] 320 (8.37), 261 (100.00), 195 (24.67), 181 (98.29), 139 (38.03), 59 (38.77), 41 (57.36).

Mixture of isomers (Z)-(12a) and (E)-(12b) of methyl (1S,3S)-3-[2-(4-ethoxyphenyl)ethen-1-yl]-2,2-dimethylcyclopropane-1-carboxylate. TLC: Rf = 0.52 (hexane-diethyl ether, 9:1 v/v); Specific rotation: [α]D20= −71.4° (c= 2.80, acetone); IR (, cm−1): 2979, 2949, 1725, 1607, 1510, 1245, 1167, 1048, 841, 732; 1H-NMR (CDCl3) δ (m, l, J(Hz), atrib.): 1.20 (s, 3H, CH3), 1.21 (s, 3H, CH3), 1.30 (s, 3H, CH3), 1.32 (s, 3H, CH3), 1.54 (d, 1H, J1-3cis = 5.4, H1cis), 1.64 (d, 1H, J1-3trans = 5.4, H1trans), 2.18 (m, 1H, H3trans), 2.40 (m, 1H, H3cis), 3.67 (s, 3H, OCH3), 3.69 (s, 3H, OCH3), 4.03 (m, 4H, 2 × OCH2), 5.30 (dd, 1H, J3-4cis = 8.4 e J4-5cis = 11.5, H4cis), 5.82 (dd, 1H, J3-4trans = 8.7 e J4-5trans = 15.6, H4trans), 6.46 (m, 2H, H5trans e H5cis), 6.85 ( m, 4H, H3'), 7.25 (m, 4H, H2'); 13C-NMR (CDCl3): δ 15.1 (2 × OCH2CH3), 20.4 (2 × CH3), 22.4 (2 × CH3), 29.5 [C(CH3)2], 39.8 [C(CH3)2], 33.4 (C3cis), 34.5 (C1trans), 35.7 (C1cis), 37.1 (C3trans), 51.8 (2 × OCH3), 63.36 (2 × OCH2), 114.4 (C3'), 114.7 (C3'), 125.0 (C4trans), 126.7 (C4cis), 127.2 (2 × C1'), 129.8 (C2'), 130.2 (C2'), 131.5 (C5), 131.6 (C5), 158.1 (C4'), 158.5 (C4'), 172.7 (2 × C=O); MS, m/z (100%): [M•+] 274 (51.44), 215 (100.00), 199 (35.28), 107 (50.20), 77 (44.56), 29 (62.83).

 3.4. Bioassays

To evaluate the insecticidal activity of the synthesized compounds, biological assays were conducted with A. obtectus, adults of S. zeamais, second-instar larvae of A. monuste orseis, and second-instar nymph of P. americana.

The experimental design was completely randomized with four replicates. Each experimental unit consisted of a glass Petri dish (9.5 cm × 2.0 cm) containing ten insects. The average weight of each insect species was obtained by measuring, on an analytical balance, the mass of ten groups containing 10 insects each. Bioassays were conducted by topical application. For each individual insect was applied on the thoracic tergite, via a 10 µL Hamilton micro syringe, 0.5 µL of a solution of the test compound, dissolved in acetone, corresponding to dose of 5 (for P. americana), 10 (for A. monuste orseis) and 50 µg of compound per mg of the insect (for A. obtectus e S. zeamais). In a control experiment, carried out under the same conditions, 0.5 µL of acetone was applied on each insect. After application, the insects were kept in individual Petri dishes and A. monuste orseis and P.americana were supplied with appropriate food. No food was supplied to A. obtectus e S. zeamais.

In all cases the Petri dishes were placed in an incubator at 25 ± 0.5 °C, 75 ± 5% relative humidity, with a photoperiod of 12 h. The mortality counts were made after 12 h after treatment. Mortality included dead individuals and those without movements. Mortality data were analyzed using Tukey test at 0.05 probability level.

 4. Conclusions

In conclusion, we have successfully synthezed 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one (6) from the readily available furfural and of five novel pyrethroids 8–12 from D-mannitol. These compounds were evaluated for their biological activity against some key pests common in Brazil: A. obtectus, S. zeamais, A. monuste orseis, and P. americana. The results indicate that all compounds show insecticidal activity, and compounds 6 and 11 presented insecticidal activity statistically not different from the commercial insecticide for all species tested.

 Acknowledgments

We thank the Brazilian agencies FAPEMIG for financial support, and CNPq for student’s grants. Thanks also to Daniel Pattoni and William Howell (British students) for the manuscript proofreading.

 References Elliott M. Farnham A.W. Janes N.F. Needham P.H. Pulman D.A. Synthetic insecticide with a new order of activity Nature 1974 248 710 711 10.1038/248710a0 Soderlund D.M. Clark J.M. Sheets L.P. Mullin L.S. Piccirillo V.J. Sargent D. Stevens J.T. Weiner M.L. Mechanisms of pyrethroid neurotoxicity: Implications for cumulative risk assessment Toxicology 2002 171 3 59 10.1016/S0300-483X(01)00569-811812616 Elliott M. Janes N.F. Synthetic pyrethroids - a new class of insecticide Chem. Soc. Rev. 1978 7 473 505 10.1039/cs9780700473 Silvério F.O. de Alvarenga E.S. Moreno S.C. Picanço M.C. Synthesis and insecticidal activity of new pyrethroids Pest Manag. Sci. 2009 65 900 905 10.1002/ps.1771 Krief A. Bicyclohexane derivatives and their use in preparing cyclopropane carboxylic acid UK Pat. 2,246,129A 22 January 1992 Funk R.L. Munger J.D. The stereospecific total synthesis of (±) cis-chrysanthemic acid via the alicyclic Claisen rearrangement J. Org. Chem. 1978 50 707 709 Krief A. Swinne D. Novel synthesis of vinylcyclopropanecarboxylic acids: application to the synthesis of (d,l)- and (d)-cis-chrysanthemic acid Tetrahedron Lett. 1996 37 7123 7126 10.1016/0040-4039(96)01410-4 Zhang Q. Zhang W. Wang X. Li P. Immunoassay Development for the Class-Specific Assay for Types I and II Pyrethroid Insecticides in Water Samples Molecules 2010 15 164 177 10.3390/molecules15010164 Moreno S.C. Picanço M.C. Silvério F.O. de Alvarenga E.S. Carvalho G.A. Toxicity of new pyrethroids to the social insects Protonectarina sylveirae, Solenopsis saevissima and Tetragonisca angustula Sociobiology 2009 54 893 906 Jakovac I.J. Goodbrand H.B. Lok K.P. Jones J.B. Enzymes in organic synthesis. 24. Preparations of enantiomerically pure chiral lactones via stereospecific horse liver alcohol dehydrogenase catalyzed oxidations of monocyclic meso diols J. Am. Chem. Soc. 1982 104 4659 4665 10.1021/ja00381a024 Doyle M.P. Pieters R.J. High enantioselectivity in the intramolecular cyclopropanation of allyl diazoacetates using a novel rhodium(II) catalyst J. Am. Chem. Soc. 1991 113 1423 1424 10.1021/ja00004a059 Doyle M.P. Austin R.E. Bailey A.S. Dwyer M.P. Dyatkin A.B. Kalinin A.V. Kwan M.M.Y. Liras S. Oalmann C.J. Pieters R.J. Enantioselective intramolecular cyclopropanations of allylic and homoallylic diazoacetates and diazoacetamides using chiral dirhodium(II) carboxamide catalysts J. Am. Chem. Soc. 1995 117 5763 5775 10.1021/ja00126a016 Doyle M.P. Hu W. Chapman B. Marnett A.B. Peterson C.S. Vitale J.P. Stanley S.A. Enantiocontrolled macrocycle formation by catalytic intramolecular cyclopropanation J. Am. Chem. Soc. 2000 122 5718 5728 10.1021/ja9945414 Che C.M. Huang J.S. Lee F.W. Li Y. Lai T.S. Kwong H.L. Teng P.F. Lee W.S. Lo W.C. Peng S.M. Asymmetric inter- and intramolecular cyclopropanation of alkenes catalyzed by chiral ruthenium porphyrins. Synthesis and crystal structure of a chiral metalloporphyrin carbene complex J. Am. Chem. Soc. 2001 123 4119 4129 10.1021/ja001416f11457174 Sabbioni G. Jones J.B. Enzymes in organic synthesis. 39. Preparations of chiral cyclic acid-esters and bicyclic lactones via stereoselective pig liver esterase catalyzed hydrolyses of cyclic meso diesters J. Org. Chem. 1987 52 4565 4570 10.1021/jo00229a024 Milewska M.J. Gdaniec M. Poloński T. Synthesis, Stereochemistry, and chiroptical spectra of cyclopropyl lactones and thionolactones Tetrahedron: Asymmetry 1996 7 3169 3180 10.1016/0957-4166(96)00419-3 Teng P.F. Lai T.S. Kwonga H.L. Cheb C.M. Asymmetric inter- and intramolecular cyclopropanations of alkenes catalyzed by rhodium D4-porphyrin: A comparison of rhodium- and ruthenium-centered catalysts Tetrahedron: Asymmetry. 2003 14 837 844 10.1016/S0957-4166(03)00047-8 Sato H. Kim Y.S. Shibasaki M. A catalytic asymmetric synthesis of a versatile intermediate for phorbol derivatives TetrahedronLett. 1999 40 2973 2976 10.1016/S0040-4039(99)00340-8 Bosone E. Caprara G. Corda F. Gozzo F. Menconi A. Piccardi P. Caprioli V. Pyrethroids U.S. Patent 4,599,358 8 July 1986 Hirata N. Uemura T. Process for producing 6,6-dimethyl-3-oxabicyclo[3.1.0]hexan-2-one WO Patent Appl. 2007,052,383 10 May 2007 Li G.Y. Zhang J. Chan P.W.H. Xu Z.J. Zhu N. Che C.M. Enantioselective intramolecular cyclopropanation of cis-alkenes by chiral Ruthenium(II) Schiff base catalysts and crystal structures of (Schiff base)ruthenium complexes containing carbene, PPh3, and CO ligands Organometallics 2006 25 1676 1688 10.1021/om051009i Botton M. Lorini I. Afonso A.P.S. Ocorrência de Sitophilus zeamaisMots. (Coleoptera: Curculionidae) danificando a cultura da videira no Rio Grande do Sul (in Portuguese) Neotrop. Entomol. 2005 34 355 356 10.1590/S1519-566X2005000200027 Chu S.-S. Liu Z.-L. Du S.-S. Deng Z.-W. Chemical Composition and Insecticidal Activity Against Sitophilus zeamais of the Essential Oils Derived from Artemisia giraldii and Artemisia subdigitata Molecules 2012 17 7255 7265 10.3390/molecules17067255 Liu T.X. Biology and Life History of Ascia monuste monuste (Lepidoptera: Pieridae), a Potential Pest of Cruciferous Vegetables Ann. Entomol. Soc. Am. 2005 98 726 731 10.1603/0013-8746(2005)098[0726:BALHOA]2.0.CO;2 Näsman J.H. 3-Methyl-2(5H)-furanone-(2(5H)-furanone, 3-methyl) Org. Synt. 1998 68 162 174 Ohga K. Matsuo T. Photoinduced addition of isopropyl alcohol to α, β-unsaturated lactones J. Org. Chem. 1974 39 106 108 10.1021/jo00915a027 Sanseverino A.M. Mattos M.C.S. Hydrobromination of alkenes with PBr3/SiO2: a simple and efficient regiospecific preparation of alkyl bromides J. Braz. Chem. Soc. 2001 12 685 687 10.1590/S0103-50532001000500013 Ahmed A.S.E. Bashir N.H.H. Assad Y.O.H. Susceptibility of Periplaneta americana L. (Orthoptera: Blattidae) population from Wad Medani (Sudan Gezira) to three public health insecticides Resist. Pest Manag. Newsl. 2010 19 8 14 Pereira C.J. Pereira E.J.G. Cordeiro E.M.G. Della Lucia T.M.C. Totola M.R. Guedes R.N.C. Oganophosphate resistance in the maize weevil Sitophilus zeamais: magnitude and behavior Crop Prot. 2009 28 168 173 10.1016/j.cropro.2008.10.001 Silva G.A. Picanço M.C. Bacci L. Crespo A.L.B. Rosado J.F. Guedes R.N.C. Control failure likelihood and spatial dependence of insecticide resistance in the tomato pinworm, Tuta absoluta Pest Manag. Sci. 2011 67 913 920 10.1002/ps.2131 Gomez-Dantes H. San Martin J.L. Danis-Lozano R. Manrique-Saide P. Estrategias de prevencion y control de salud publica en Mesoamerica: un enfoque basado en evidencia Salud Publica Mex. 2011 53 349 357 Perrin D.D. Armarego W.L.F. Purification of Laboratory Chemicals 3rd Butterworths-Heinemann Oxford, UK 1997

Sample Availability: Samples are available from the authors.